Carrier OptiClean FN1AAF Series Operation And Maintenance Manual

FN1AAF
OptiClean™ Negative Air Machine and Air Scrubber
NOTE: Read all instructions and data in this manual before operating.
Fig. 1 – FN1AAF
A Note About Safety
Any time you see this symbol
unit, be aware of the potential for personal injury. There are three levels
of precaution:
DANGER identifies the most serious hazards which will result in severe
personal injury or death.
WARNING signifies hazards that could result in personal injury or
death.
CAUTION is used to identify unsafe practices which would result in
minor personal injury or product and property damage.
NOTE is used to highlight suggestions which will result in enhanced
installation, reliability, or operation.
WARNING
!
PERSONAL INJURY OR PROPERTY DAMAGE
HAZARD
Failure to follow this warning could result in personal injury or
property damage.
Improper installation, adjustment, alteration, service, maintenance, or
use can cause conditions which may cause personal injury or property
damage. Consult a qualified installer or your distributor for information
or assistance. Read and follow all instructions and warnings, including
labels shipped with or attached to unit before operating.
WARNING
!
ELECTRICAL SHOCK HAZARD
Failure to follow this warning could result in personal injury or death.
Disconnect all electrical power to the unit before removing access
panels to perform any maintenance.
Operation and Maintenance Manual
in manuals, instructions and on the
PORTABLE UNIT AND METAL SHARP EDGES
HAZARD
Failure to follow this Warning could cause personal injury or death.
This unit must be used in a location where unsupervised children are
not allowed to play. The unit is portable, and areas inside and under the
unit could cause personal injury. If the unit is used in a horizontal
configuration, physical barriers must be installed around the unit to
prevent unauthorized access.
About the Negative Air Machine/Air Scrubber
The OptiClean™ is a portable solution primarily designed to help
convert normal hospital rooms into Airborne Infectious Isolation Rooms
(AIIR). Designed to ASHRAE's Standard 170 for Ventilation of Health
Care Facilities, the OptiClean™ uses highly efficient filters and a heavy
duty, yet quiet, motor to remove contaminated air from the room. The
resulting negative air pressure, or "vacuum effect," helps limit the spread
of air-based contaminants into surrounding areas.
If negative pressure is not required, such as in an open-air temporary
A200220GEN
hospital, a business location or home, the machine can be used as an air
"scrubber," pulling air in, removing many contaminants, and discharging
cleaner air back into the room.
The OptiClean™ negative air machine/scrubber features:
• 99.97% efficient long-life HEPA filter removes particles as small as
0.3 microns
• Standard MERV 7 or higher pre-filter
• Minimum 200 CFM and Maximum 1500 CFM
• Meets or exceeds ASHRAE Standard 170: Ventilation of Health Care
Facilities
• Vertical design for smaller footprint compared to many competitors,
and can be mounted and operated horizontally when necessary
• Portable and adaptable to nearly any location
• Heavy duty locking casters for easy and smooth transport
• HEPA filter rack and sealing design meet air leakage requirement
• Red lighted indicator to alert user when filters are overloaded
(generally means pre-filter requires replacement)
• Green ON/OFF switch illuminates to verify when running
• 3-speed selector switch on 006 and 015 size models for various air
flow ranges
• 10-foot long power cord with strain relief
• 115V
• Galvanized steel, pre-painted cabinet is fully insulated
• Exhaust transition plate to standard 10-inch round (005/006 size) or
12-inch oval (015 size) duct included
• UL® Listed
• One year limited warranty
WARNING
!
UL and the UL logo are trademarks of UL LLC.