Rear Cover Removal - Sony KDL-40HX750 Service Training Manual

REAR COVER REMOVAL

CAUTION:
Hold down the Rear Cover as shown in the steps below to avoid deforming or damaging the hooks in the Rear
Cover and Bezel.
The portion of the Rear Cover near the Switch Unit is very fragile. When lifting this section, support the area to avoid
breaking the cover.
Trying to remove the Rear Cover as shown in this illustration will break the hooks securing it to the Bezel.
A To avoid damaging the AC Power Supply Cord,
remove the screw from the AC Cover and
disconnect the AC Power Cord.
B Remove the remaining screws from the
Rear Cover.
19 from KDL-40HX750 Only
21 from KDL-46HX750/46HX751 Only
21 from KDL-55HX750/55HX751 Only
C Gently hold down the Rear Cover from the
center, then carefully start to lift the Rear Cover
from the bottom to create clearance between
the Bezel and the Rear Cover.
D Gently hold down the Rear Cover as shown in the steps below, then grasp the inside bottom corner and carefully lift
the Rear Cover to release the hooks.
E Lift the Rear Cover from the bottom and push
forward to release the top hooks.
KDL-40HX750/46HX750/46HX751/55HX750/55HX751
SECTION 4 - DISASSEMBLY/PART NUMBER INFORMATION
Bezel hook
Rear Cover hook
Hold the
Power Supply Cord
USE CAUTION
to avoid breaking this
area of the Rear Cover
NOTE: Les composants identifies per un trame et
NOTE: The components identified by shading
une marque sont critiques pour la securite.
!
and mark are critical for safety. Replace only
!
Ne les remplacer que par une piece portant le
with part number specified.
numero specifie.
56
REF. NO. PART NO. DESCRIPTION [ASSEMBLY INCLUDES]
51 4-415-489-41 REAR COVER (40 ZEU) A [52]
(KDL-40HX750 ONLY)
51 4-415-492-41 REAR COVER (46 ZEU) A [52]
(KDL-46HX750/46HX751 ONLY)
51 4-415-494-41 REAR COVER (55 ZEU) A [52]
(KDL-55HX750/55HX751 ONLY)
52 4-299-526-01 BRACKET, VESA
53 4-400-428-01 LABEL, SIDE TERMINAL
ORDER THIS PART WHEN REPLACING THE REAR COVER
54 4-400-433-01 LABEL, UNDER TERMINAL
ORDER THIS PART WHEN REPLACING THE REAR COVER
NOTE: The components identified by a red outline and a
confidential information. Specific instructions must be adhered to whenever
these components are repaired and/or replaced.
See Appendix A: Encryption Key Components in the back of this manual.
53
52
51
54
55
REF. NO. PART NO. DESCRIPTION
55 4-299-528-01 AC COVER
! 56 1-839-696-11 CORD, POWER (WITH CONNECTOR)
△ 4-159-298-01 SCREW, +PSW M4X10
■ 7-685-648-79 SCREW +BVTP 3X12 TYPE2 IT-3
□
2-580-639-01 SCREW, +BVTP 4X12 TYPE2 IT-3
◆
4-400-043-01 JOINT, SCREW
(SCREWS USED WHEN STAND IS ATTACHED
- NOT USED WITH WALL MOUNTS)
◇
4-256-393-01 SCREW, +PSW M3X6 W12
mark contain
[ASSEMBLY INCLUDES]
20