Table of Contents
Advertisement
C500AP & C500APT
AIRPOT COFFEE BREWER
Service Manual
Throughout this service manual, whenever the airpot brewer model C500AP is mentioned,
this information is typical to both the C500AP and C500APT. All parts are common except
where noted.
6913 West Acco Street, Montebello, CA 90640-5403 U.S.A.
Wilbur Curtis Co., Inc.
Tel: (323) 837-2300
Table of Contents
Unpacking . . . . . . . . . .
Shipping List . . . . . . . . .
Rough-in Drawing . . . .
Start up . . . . . . . . . . . . .
Coffee Brewing . . . . .
Troubleshooting . . . . . .
Wiring Diagram . . . . . .
Illustrated Parts List . . .
Warranty . . . . . . . . .
Carton Contents
Qty
1
1
1
25
1
Fax: (323) 837-2401
1
1
1
2
2
3
3
5
7
Back
Cover
Item
Brewer, C500AP
Brew Cone, S/S
Fitting, Flare Elbow
Paper Filters
Service Manual
®
C
®
-
Advertisement
Table of Contents
Related Manuals for Curtis C500AP
Summary of Contents for Curtis C500AP
-
Page 1: Table Of Contents
AIRPOT COFFEE BREWER Service Manual Throughout this service manual, whenever the airpot brewer model C500AP is mentioned, this information is typical to both the C500AP and C500APT. All parts are common except where noted. 6913 West Acco Street, Montebello, CA 90640-5403 U.S.A. -
Page 2: Unpacking
All products manufactured by the Wilbur Curtis Company are thoroughly inspected at the factory and are warranted to be free of all defects and faulty workmanship. The C500AP unit is packaged for maximum protection for shipping. Make sure the shipping carton is not damaged or punctured. Un- pack the carton carefully, inspecting the contents for any damage that may have occurred in transit. -
Page 3: Start Up
C500AP Airpot Coffee Brewer START-UP 1. Remove top cover of brewer. Remove lid from heating tank. Hand fill tank until water level is approxmately two inches below probe tip. 2. Connect the water line to the brewer using ¼" copper tubing with ¼" female flare fitting. -
Page 4: Care & Maintenance
4. Clean the brew cone slide rails with a brush or damp cloth. Dry thoroughly. Stainless Steel Polish can be used to clean the outside surfaces of the C500AP coffee brewer. This is to prevent scratching of the stainless steel surfaces. - Page 5 C500 AP Air Pot Coffee Brewer TROUBLE SHOOTING CONTINUED: POSSIBLE CAUSE 4. Defective or burned out water level control board PROBLEM: WATER HEATING TANK OVERFLOWING. POSSIBLE CAUSE 5. Defective water inlet valve 6. Probe limed up 7. Non-grounded or loose terminal connections at liquid level control board...
-
Page 6: Wiring Diagram
C500 AP Air Pot Coffee Brewer TROUBLE SHOOTING CONTINUED: POSSIBLE CAUSE 13. Defective brew timer (WC-604) 14. Defective dump valve or coil WIRING DIAGRAM Make sure the timer is receiving 110 to 120 volts at terminals B and A. Measure the voltage across terminals 6 and A on the timer when it has been activated. - Page 7 WIRING DIAGRAM [ 6 ]...
-
Page 8: Illustrated Parts List
C500 AP Airpot Coffee Brewer ILLUSTRATED PARTS, MAIN VIEW [ 7 ]... - Page 9 C500 AP Airpot Coffee Brewer ILLUSTRATED PARTS, DETAIL BUBBLES ☯ 8 ]...
-
Page 10: Parts List
C500 AP Air Pot Coffee Brewer PARTS LIST INDEX PART NUMBER NUMBER WIRE BREW BASKET FOR WC-3323 WC-3317 WC-3323 BREW CONE COMPLETE, STAINLESS STEEL, 7 1/8" WC-3963 LABEL, CAUTION UNIVERSAL BREW CONE WC-3621 HOT WATER FAUCET WC-1809 WC-1806 FAUCET SEAT CUP, SILICONE WC- 114R ON/OFF SWITCH BREW SWITCH... - Page 11 ELEMENT, HEATING 1.6KW 120V W/ JAM NUT & SILICONE WASHERS WC-5409 CLIP, THERMOSTAT CAPILLARY WC-43058 PLUG, TANK DRAIN PP RED WC-3685 INSULATION, WRAP C500AP WC-3765L KIT, INLET VALVE REPAIR USE ON WC-825/WC-826/WC-826L/WC-847 WC- 829 WASHER, FLOW KIT, DUMP VALVE FOR WC866, WC889, WC816, WC817 & WC818 WC-3763 6913 West Acco Street, Montebello, CA 90640-5403 U.S.A.
- Page 12 Product Warranty Information The Wilbur Curtis Company certifies that its products are free from defects in material and workmanship under normal use. The following limited warranties and conditions apply: 3 Years, Parts and Labor, from Original Date of Purchase on digital control boards. 2 Years, Parts, from Original Date of Purchase on all other electrical components, fittings and tubing.