Download  Print this page

Weil-McLain STAR-34 Supplement Manual

Special gas vent system vent and combustion air supplement
Hide thumbs
   

Advertisement

Hazard definitions
To the installer:
GOLD
GOLD
GOLD
GOLD
GOLD
W
W
ater boiler — Series 3
ater boiler — Series 3
W ater boiler — Series 3
W
W
ater boiler — Series 3
ater boiler — Series 3
Venting Supplement
StaR
StaR
-34
-34
StaR -34
-34
StaR
StaR
-34
Special gas vent system vent and combustion
Special gas vent system vent and combustion
Special gas vent system vent and combustion
Special gas vent system vent and combustion
Special gas vent system vent and combustion
air supplement
air supplement
air supplement
air supplement
air supplement
Flex-L International, Inc. StaR-34 AL29-4C
Stainless Steel Special Gas Vent System may be
used in new installations of GV-3 through GV-6
boilers.
The following terms are used throughout this Venting Supplement to bring attention to the
presence of hazards of various risk levels or to important information concerning the life of
the product.
Indicates presence of hazards that will cause severe personal injury, death
or substantial property damage.
Indicates presence of hazards that can cause severe personal injury, death
or substantial property damage.
Indicates presence of hazards that will or can cause minor personal injury
or property damage.
Indicates special instructions on installation, operation or maintenance
that are important but not related to personal injury or property damage.
This Venting Supplement must only be used by a qualified installer/service
technician. Read these instructions completely before beginning the
installation. Failure to follow these instructions in proper order can cause
severe personal injury, death or substantial property damage.
To install a new vent system follow instructions in:
• This Venting Supplement.
GV Boilers Vent/Air Intake Termination Assembly Instructions
using Weil-McLain Vent/Air Intake Termination Kit. — OR —
GV Water Boiler Series 2 & 3 Direct vent Through-roof or Through-
unused-chimney Venting Supplement
Through-Roof or Through-Unused-Chimney Termination Kit.
StaR-34
For installations above 5,500 feet use only direct vent (ducted combustion
air) when sidewall venting. All of the vertical (through-roof or through-
unused-chimney) methods in this Venting Supplement are acceptable. Can
result in severe personal injury, death or substantial property damage if
ignored.
manufacturer's instructions supplied with vent material.
GV
GV
GV
GV
GV
®
, if
, if using Weil-McLain
Part Number 550-110-268/0699

Advertisement

loading

  Related Manuals for Weil-McLain STAR-34

No related manuals

  Summary of Contents for Weil-McLain STAR-34

  • Page 1 To install a new vent system follow instructions in: • This Venting Supplement. • GV Boilers Vent/Air Intake Termination Assembly Instructions using Weil-McLain Vent/Air Intake Termination Kit. — OR — • GV Water Boiler Series 2 & 3 Direct vent Through-roof or Through- unused-chimney Venting Supplement Through-Roof or Through-Unused-Chimney Termination Kit.
  • Page 2: Combustion Air Supply

    GOLD GV Water boiler — Series 3 Combustion air supply Special note Refer to All boilers experience some condensation in section assembly during start-up. Unlike most conventional boilers, condensation is minimized in the system, maintaining boiler return water temperature above 130 Flue gas condensate is slightly acidic.
  • Page 3: Vent Termination

    1. When using direct vent method — Refer to separate instructions packed with Weil-McLain direct vent termination kit and vent pipe manufacturer's instructions for additional locations. 2. For location of non-direct vent vertical termination, see vent pipe manufacturer's instructions.
  • Page 4: Pre-Installation Planning

    Weil-McLain Through-Roof or Through-Unused-Chimney Termination Kit Notes 1. Flex-L International, Inc. part number. Parts available through Flex-L International, Inc. 2. Weil-McLain part number. Parts available through Weil-McLain distributor. Figure 2 Boiler output Total number of elbows 60 50 40 30 20 10 step 2.
  • Page 5 ¼” per foot. Vent pipe S l o Air pipe StaR-34 vent starter tee Figure 5 GV direct vent (using Weil-McLain Through-Roof or Through-Unused- Chimney Termination Kit) StaR-34 vent starter tee Part Number 550-110-268/0699 Figures 4 Figure 4...
  • Page 6: Installation & Assembly

    Connect vent run to Venting through sidewall termination 1. If using Weil-McLain Vent/Air Intake Termination Kit, see instructions provided in that 2. If using non-direct method with termination coupling only, see 3. Maintain minimum one-inch clearance from combustible materials to vent pipe; 0"...
  • Page 7 Pipe section Sealant Termination coupling Figure 9 Non-direct vent through sidewall (using termination coupling) Follow StaR-34 manufacturer’s instructions for proper installation of vent runs, including slope and support. StaR-34 vent starter tee Part Number 550-110-268/0699 ¼" to ¾" between stop...
  • Page 8 Vent and combustion air connector piping must be sealed gas-tight to prevent possibility of flue gas spillage and carbon monoxide emissions, resulting in severe personal injury or death. continued Figure 11 Installation of condensate tubing StaR-34 vent starter tee 5/8" O.D. tubing, 26806 provided by others...