Table of Contents
Advertisement
Quick Links
Installation and Operation Instructions
DECORATIVE GAS APPLIANCE FOR INSTALLATION IN ODSR36/42A FIREPLACES
IF THE INFORMATION IN THIS MANUAL IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLOSION MAY RESULT,
CAUSING PROPERTY DAMAGE, INJURY, OR LOSS OF LIFE.
DO NOT STORE GASOLINE OR OTHER FLAMMABLE VAPORS OR LIQUIDS NEAR THIS OR
ANY OTHER APPLIANCE.
•
SHUT OFF ALL GAS TO THE APPLIANCE.
•
DO NOT TRY TO LIGHT ANY APPLIANCE; EXTINGUISH ANY OPEN FLAME
•
IMMEDIATELY PHONE YOUR GAS SUPPLIER FROM A NEIGHBOR'S PHONE. FOLLOW
THE SUPPLIER'S INSTRUCTIONS.
•
IF YOU CANNOT REACH THE GAS SUPPLIER, PHONE THE FIRE DEPARTMENT.
ATTENTION
INSTALLATION AND SERVICE MUST BE PER-
FORMED BY A QUALIFIED AGENCY, INDIVIDUAL,
FIRM, CORPORATION, OR COMPANY, EXPE-
RIENCED IN THE INSTALLATION, REPAIR, AND
SERVICING OF THIS TYPE OF GAS APPLIANCE.
DO NOT MODIFY, ALTER OR TAMPER WITH ANY
PART OF THIS HEATER, CONTROL, OR LOGS.
CSA 7.94 U.S. manually lighted decorative gas appliance for installation in solid fuel burning fire-
places and the applicable requirements of UL127 factory-suit fireplaces.
Vented Gas Log Sets
Model OD24SHKN/P
W A R N I N G
FOR YOUR SAFETY:
WHAT TO DO IF YOU SMELL GAS:
CFM Specialty Home Products
410 Admiral Blvd. • Mississauga, Ontario, Canada L5T 2N6 • 905-670-7777
www.majesticproducts.com • www.vermontcastings.com
SAVE THIS MANUAL FOR FUTURE REFERENCE
for
INSTALLER PLEASE NOTE:
DO NOT BEGIN INSTALLATION OF THIS GAS
LOGSET UNTIL ALL INSTRUCTIONS HAVE
BEEN READ AND UNDERSTOOD.
OWNER PLEASE NOTE:
READ THESE INSTRUCTIONS AND FOLLOW THE
WARNINGS.
Certified as:
GAS-FIRED
20007967 5/05 Rev. 1
Advertisement
Table of Contents
Related Manuals for Vermont Castings OD24SHKN
Summary of Contents for Vermont Castings OD24SHKN
- Page 1 410 Admiral Blvd. • Mississauga, Ontario, Canada L5T 2N6 • 905-670-7777 SAVE THIS MANUAL FOR FUTURE REFERENCE Vented Gas Log Sets Model OD24SHKN/P W A R N I N G FOR YOUR SAFETY: DO NOT BEGIN INSTALLATION OF THIS GAS LOGSET UNTIL ALL INSTRUCTIONS HAVE BEEN READ AND UNDERSTOOD.
- Page 2 Improper installation, adjustment, alteration, service or maintenance can cause injury or property dam- age. Read these directions thoroughly before installation. For assistance or additional information, consult your gas log dealer, qualified installer, service agency or gas supplier. If not installed, operated, and maintained in accordance with the manufacturer’s instructions, this prod- uct could expose you to substances in fuel or fuel combustion which are known to the State of California to cause cancer, birth defects, or other reproductive harm.
-
Page 3: General Information
In order to assure a safe and effective instal- lation, only a qualified service person who is familiar with the building codes and installation techniques appropriate to your area may install and service this appliance. The Logsets have been designed and tested to oper- ate safely when installed according to the installation instructions contained in this manual. -
Page 4: Pre-Installation Checklist
Pre-Installation Checklist Is the gas type you are using the same as the gas type listed on the rating plate for this appliance? Does the firebox meet the minimum size dimensions below? Is the gas supply inlet pressure correct? Refer to Table below. Is your fireplace plumbed with gas on the right side (facing) of the fireplace? If not, refer to page 5. - Page 5 4. Attach one end of the Flexible Gas Connector to the brass Burner Inlet Fitting which has been factory installed into the burner. 5. Attach the other end of the Gas Connector to the flared side of the Gas Supply Fitting. Remember to use pipe thread sealant or teflon tape only on the straight pipe threads.
-
Page 6: Damper Stop Installation
After connecting the gas supply, test for leaks. Use a 50/50 solution of liquid soap and water to test for leaks at gas fitting and joints. Apply water/soap solution with brush only - do not over apply. NEVER test with an open flame. WARNING: DO NOT USE AN OPEN FLAME TO TEST FOR LEAKS! NOTE: Always perform a leak test any time the appliance has been moved or disconnected from the gas supply line. -
Page 7: Ember Placement
Grate Assembly Place grate assembly over top of burner so the front middle leg of the grate is 1¹⁄₂” back from the front edge of the main burner pan assembly. (Fig. 7) 1¹⁄₂" Fig. 7 Grate placement. Add Pan Material 1. -
Page 8: Log Placement
Log Placement 1. Place the larger bottom logs (longer log in back, shorter (2) logs in front) onto the grate, leaving as much space between them as possible. (Fig. 12) Back Log Front (2) Shorter Logs Grate Retainer Fig. 12 OD24SHK log placement. 2. -
Page 9: Lighting Instructions
WARNING: If you do not follow these directions exactly, a fire or explosion may result caus- ing property damage, personal injury, or loss of life. • Do not try to light any appliance. • Do not touch any electrical switch, do not use any phone in the immediate area. •... -
Page 10: Troubleshooting
Troubleshooting Log Set Is Smoking/Sooting Excessively It is natural and unavoidable for vented gas log sets to produce moderate levels of carbon (soot) where flame contacts the logs. The logs can be cleaned using a soft-bristle brush. However, if soot is pro- duced where there is no flame impingement, one of the following may be the cause: Fireplace venting system not drafting properly: Make sure the damper is wide open at all times. - Page 11 CFM Specialty Home Products reserves the right to make changes in design, materials, specifications, prices and discontinue colors and products at any time, without notice. OD24SHK Vented Gas Logs Ref. Description Complete Log Set Top Log #3 Top Log (2) Rear Log Left Front Log Right Front Log...
- Page 12 LIMITED 2/20 YEAR WARRANTY For VERMONT CASTINGS Decorative Gas Appliances CFM Specialty Home Products extends the warranties specified in paragraphs A and B below with respect to its Vermont Castings Decorative Gas Appliances (the “Gas Ap- pliance”), including CFM Specialty Home Products supplied accessories and components referred to in those para- graphs, subject to the following conditions and limitations: (1) These warranties are extended only to the Gas Ap-...