IMPORTANT:READ SAFETY RULES AND INSTRUCTIONS CAREFULLY
Warning: This unit is equipped with an internal combustion engine and should not be used on or near any unimproved forest-covered, brush-
covered or grass-covered land unless the engine's exhaust system is equipped with a spark arrester meeting applicable local or state laws (if any).
If a spark arrester is used, it should be maintained in effective working order by the operator. In the State of California the above is required by law
(Section 4442 of the California Public Resources Code). Other states may have similar laws. Federal laws apply on federal lands. A spark arrester
for the muffler is available by contacting the service department at Troy-Bilt LLC, P.O. Box 361131 Cleveland, Ohio 44136-0019.
Page 1
(Section 4442 of the California Public Resources Code). Other states may have similar laws. Federal laws apply on federal lands. A spark arrester for the muffler is available by contacting the service department at Troy-Bilt LLC, P.O. Box 361131 Cleveland, Ohio 44136-0019.
Section Parts List PART DESCRIPTION GW-2555 Lever–Wheels/Tines/PTO Drive ... 1908156 Spring–clutch pawl... 710-0805 Bolt–hex hd., 5/16-18 x 1-1/2"... GW-2447 Bushing–3/8" ... 1177548 Lockwasher–external tooth, 5/16" . 712-0267 Nut–hex, 5/16"-18... 1916265 Roller Assembly ... GW-2165-1 Yoke–left side ... GW-2165-2 Yoke–right side... WHEELS/TINES/PTO DRIVE LEVER &...
Page 3
MODELS 682J &, E682L See Page 48 PART DESCRIPTION GW-2552 Engine Wire Harness Assy–forward interlock system (Incl. one red and one black wire, plug con- nector, neutral switch and PVC tubing. Parts not available separately... FORWARD INTERLOCK SYSTEM PART QTY.
Page 6
Parts List MODELS 682J &, E682L WHEEL SPEED LEVER, BELT DRIVE SYSTEM, ENGINES, WHEELS See Page 62 See Page 52...
Page 7
GW-1138-2 Shim–as above, 1/32" GW-9303 Key–engine pulley, 3/16"sq. x 2-1/2" 1 Contact an authorized engine dealer, Troy-Bilt dealer or the Factory for replacement engine information. Contact an authorized engine dealer for engine service or parts. Refer to the engine name- plate for engine model and type information.
Page 8
Parts List MODELS 682J &, E682L POWER UNIT TRANSMISSION ASSEMBLIES See Page 50 ,16A...
Page 12
Parts List MODELS 682J & E682L TILLER ATTACHMENT TRANSMISSION ASSEMBLIES NOTE 1: THESE SCREWS HAVE A SPECIAL SEALING DESIGN THAT CAN NOT BE REUSED WITHOUT RISKING THE LOSS OF TRANSMISSION OIL. IF THESE SCREWS ARE LOOSENED OR REMOVED, THEY MUST BE...
Page 14
Parts List MODELS 682J & E682L BOLO TINE ASSEMBLIES...
Page 15
MODELS 682J & E682L PART DESCRIPTION STANDARD TILLING TINES 1901975 Tine Holder–welded steel, fits left or right sides... 1982612 Bolt–hex hd., 3/8-16 x 2" ... GW-1270-1 Bolo Tine–single, left hand. Used on left and right side tine assy. Tine is stamped either “EL" or “AL"...
Page 16
Parts List MODEL E682L ELECTRIC START SYSTEM...
Page 17
MODEL E682L PART DESCRIPTION GW-96515 Cable–battery, positive and negative terminals ... GW-97020 Boot–terminal insulating ... GW-9552 Screw–self-threading, 1/4-20 x 1/2" ... 1186309 Bolt–hex hd., 1/4-20 x 5/8" ... 1901894 Wire–recharge (red) ... GW-2614 Battery Hold-down Clamp–with attached Key Switch Plate ... 777S30648 Decal–ignition switch instruc...
Page 19
Troy-Bilt PTO Log Splitter ® 290-258-081 ® The Troy-Bilt PTO Log Splitter provides you with a convenient and easy means of splitting about a half a cord of wood per hour when working alone. When connected to the PTO Power Unit, the tiller’s engine runs the splitter’s hydraulic...