Final Transmission Oil - Yamaha AL125FC 2012 Owner's Manual

PERIODIC MAINTENANCE AND ADJUSTMENT

Final transmission oil

ZAUU0624
1. Final transmission oil filler cap
The final transmission case must be
checked for oil leakage before each
ride. If any leakage is found, have a
Yamaha dealer check and repair the
7
scooter. In addition, the final transmis-
sion oil must be changed as follows at
the intervals specified in the periodic
maintenance and lubrication chart.
1. Start the engine, warm up the fi-
nal transmission oil by riding the
scooter for several minutes, and
then stop the engine.
2. Place the scooter on the center-
stand.
3. Place an oil pan under the final
EAU20066
transmission case to collect the
used oil.
1
4. Remove the final transmission oil
filler cap and its O-ring from the fi-
nal transmission case.
5. Remove the final transmission oil
drain bolt and its gasket to drain
the oil from the final transmission
case.
1
ZAUU0625
1. Final transmission oil drain bolt
6. Install the final transmission oil
drain bolt and its new gasket, and
then tighten the bolt to the speci-
fied torque.
7. Refill with the specified amount of
8. Install the final transmission oil
9. Check the final transmission case
7-13
Tightening torque:
Final transmission oil drain bolt:
22 Nm (2.2 m·kgf, 16 ft·lbf)
the recommended final transmis-
sion oil. WARNING! Make sure
that no foreign material enters
the final transmission case.
Make sure that no oil gets on
the tire or wheel.
[EWA11311]
Recommended final transmission oil:
See page 9-1.
Oil quantity:
0.20 L (0.21 US qt, 0.18 Imp.qt)
filler cap and its new O-ring, and
then tighten the oil filler cap.
for oil leakage. If oil is leaking,
check for the cause.