Advertisement
Table of Contents
Model Numbers:
THB-2500,THB-2510,
THB-2500,THB-2510,
THB-2500,THB-2510,
THB-2500,THB-2510,
THB-2500,THB-2510,
TBL-4600,TBL-4610,TBL-505
TBL-4600,TBL-4610,TBL-505
TBL-4600,TBL-4610,TBL-505
TBL-4600,TBL-4610,TBL-505
TBL-4600,TBL-4610,TBL-505
BL
BL
BLO O O O O WERS
WERS
WERS
WERS
BL
BL
WERS
TBL-4600
ISM, Inc. • 1028 4
www.tanakapowerequipment.com
Supplier To The Outdoor Power Equipment Industry
Street SW • Auburn, WA 98001 • Phone: (253) 333-1200 • Fax: (253) 333-1212
th
Owner'
Owner'
Owner' s Man
Owner'
Owner'
THB-2510
s Man
s Man
ual
ual
s Man ual
ual
s Man
ual
P/N 12626
Date 08-10-01
custsvc@tanaka-ism.com
Advertisement
Table of Contents
Related Manuals for Tanaka TBL-4600
Summary of Contents for Tanaka TBL-4600
- Page 1 Model Numbers: THB-2500,THB-2510, THB-2500,THB-2510, THB-2500,THB-2510, THB-2500,THB-2510, THB-2500,THB-2510, TBL-4600,TBL-4610,TBL-505 TBL-4600,TBL-4610,TBL-505 TBL-4600,TBL-4610,TBL-505 TBL-4600,TBL-4610,TBL-505 TBL-4600,TBL-4610,TBL-505 BLO O O O O WERS WERS WERS WERS WERS TBL-4600 ISM, Inc. • 1028 4 www.tanakapowerequipment.com Owner’ Owner’ Owner’ s Man Owner’ Owner’ Supplier To The Outdoor Power Equipment Industry Street SW •...
-
Page 2: Before Using This Unit
THB-2500/THB-2510/TBL-4600/4610,TBL-505 Before using this unit: Read the operator’s manual carefully. Check that the blower is correctly assembled and adjusted. Start the unit and check the carburetor adjustment. See “Maintenance”. The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects and other reproductive harm. - Page 3 THB-2500/THB-2510/TBL-4600/4610,TBL-505 Owner’s Manual www.tanakapowerequipment.com custsvc@tanaka-ism.com...
-
Page 4: Warnings And Safety Instructions
THB-2500/THB-2510/TBL-4600/4610,TBL-505 2. Warnings and safety instructions. Operator Safety IMPORTANT: A dust filter mask should be worn during operation. Always wear a safety face shield or goggles. Always wear heavy, long pants, boots and gloves. Do not wear loose clothing, jewelry, short pants, sandals or go barefoot. Secure hair so it is above shoulder length. -
Page 5: Assembly Procedures
Align groove (2) in straight pipe with projection (3) on blower housing (or another pipe) and slide the pipe onto the blower housing (or another pipe). Rotate the pipe clockwise to lock it into place, then tighten the clamp band (if so equipped, THB-2510). NOTE! (TBL-4600, optional) • Connect flexible pipe (2) to main body with clamp (1). Finger-tighten the clamp. -
Page 6: Operating Procedures
Fuel • Always use branded 89 octane unleaded gasoline. • Use Tanaka two-cycle oil or a quality two-cycle oil at mixing ratio of 25-50:1 (Gasoline (A) : Oil (B)), only for the state of California at 50: 1. • Never use multi-grade oil (10 W/30) or waste oil. - Page 7 THB-2500/THB-2510/TBL-4600/4610,TBL-505 Starting CAUTION! Do not start if the pipe is obstructed by the ground or any other object. 1 .Set ignition switch (1) to ON position. (Fig. 2-2, 2B, 2C) • Push priming bulb (4) several times so that fuel flows through return pipe (5) (if so equipped) (Fig. 2-3, 3B) •...
- Page 8 THB-2500/THB-2510/TBL-4600/4610,TBL-505 Operating blower (Fig. 2-6, 6B) Adjust shoulder harness to fit your stature before operating unit. Back-pack unit in a correct way. (Fig. 2-6B) WARNING! Do not direct discharge of air toward people or pet. 1. The unit should be operated in a well ventilated area.
-
Page 9: Maintenance
THB-2500/THB-2510/TBL-4600/4610,TBL-505 5. Maintenance MAINTENANCE, REPLACEMENT, OR REPAIR OF THE EMISSION CONTROL DEVICES AND SYSTEM MAY BE PERFORMED BY ANY NONROAD ENGINE REPAIR ESTABLISHMENT OR INDIVIDUAL. Carburetor adjustment (Fig. 3-1, 1 B, IC) In the carburetor, fuel is mixed with air. When the engine is test run at the factory, the carburetor is basically adjusted. -
Page 10: Cleaning The Air Filter
THB-2500/THB-2510/TBL-4600/4610,TBL-505 Air filter The air filter must be cleaned from dust and dirt in order to avoid: • Carburetor malfunctions. • Starting problems. • Engine power reduction. • Unnecessary wear on the engine parts. • Abnormal fuel consumption. Remove the air cleaner cover by pushing and pulling back the tab on the top. (Fig. 3-2) Cleaning the air filter Clean the cleaner element every day or every 8 hours of operation. -
Page 11: Spark Arrestor
THB-2500/THB-2510/TBL-4600/4610,TBL-505 Spark plug (Fig. 3-4) The spark plug condition is influenced by: • An incorrect carburetor setting. • Wrong fuel mixture (too much oil in the gasoline) • A dirty air filter. • Hard running conditions (such as cold weather). -
Page 12: Maintenance Schedule
THB-2500/THB-2510/TBL-4600/4610,TBL-505 Maintenance schedule Below you will find some general maintenance instructions. For further information please contact your service dealer. Daily maintenance • Clean the exterior of the unit. • Check the dust cover for damage or cracks. Change the cover in case of impacts or cracks. -
Page 13: Specifications
Owner’s Manual THB-2500/THB-2510/TBL-4600/4610,TBL-505 6. Specifications ANSI : Measured at 50 feet away from unit. CEN : Measured at operator's ear. NOTE : Equivalent noise level/vibration levels are calculated as the time-weighted energy total for noise/vibration levels under various working conditions with the following time distribution : ½ idle, ½ full speed. - Page 14 THB-2500/THB-2510/TBL-4600/4610,TBL-505 Tanaka Kogyo Co., Ltd., 3-4-29 Tsudanuma, Narashino, Chiba, Japan Nous,soussign6s, Noi, Der unterzeichnete, Nosotros, Declare under our sole responsibility that the product, power blower model D6clarons sous notre seule responsabilitd que le produit en question, souffleuse mdcanique mod~le Dichiariamo sotto la nostra unica responsabilita che it prodotto, it motosoffiatore modello...