Mitsubishi Electric Mr.Slim PUZ-HA42NKA Service Manual page 61

Split-type, heat pump air conditioners r410a
Hide thumbs Also See for Mr.Slim PUZ-HA42NKA:
Table of Contents

Advertisement

Indication
Outdoor controller board
LED1 (Green) LED2 (Red)
Abnormality of Discharge
3 blinking 1 blinking
temperature (TH4) and Comp.
surface temperature (TH34)
Abnormality of superheat due
to low discharge temperature
Abnormal high pressure (High
2 blinking
pressure switch 63H worked.)
Abnormal low pressure (Low
pressure switch 63L worked.)
3 blinking
Abnormality of outdoor fan
motor rotational speed
Protection from overheat operation(TH3)(T
Compressor overcurrent
4 blinking
breaking(Start-up locked)
Compressor overcurrent breaking
Abnormality of current sensor (P.B.)
Abnormality of power module
Open/short of discharge
5 blinking
thermistors (TH4) (TH34)
Open/short of outdoor thermistors
(TH3, TH32, TH6, TH7 and TH8)
6 blinking
Abnormality of heatsink
temperature
7 blinking
Abnormality of voltage
4 blinking
1 blinking
Abnormality of room temperature thermistor (TH1)
Abnormality of pipe temperature thermistor /Liquid (TH2)
Abnormality of pipe temperature
thermistor/Condenser-Evaporator
2 blinking
Abnormality of drain sensor (DS)
Float switch connector open (FS)
Indoor drain overflow protection
3 blinking
Freezing (cooling)/overheating
(heating) protection
4 blinking
Abnormality of pipe
temperature
* Check code displayed on remote controller
**Refer to service manual for indoor unit.
OCH567
Check
Contents
code*
1 Check if stop valves are open.
2 Check if connectors (TH4, TH34, LEV-A, and LEV-B) on outdoor
U2
controller board are not disconnected.
3 Check if unit is filled with specified amount of refrigerant.
4 Measure resistance values among terminals on indoor valve and
U7
outdoor linear expansion valve using a tester.
1 Check if indoor/outdoor units have a short cycle on their air ducts.
U1
2 Check if connector(63H)(63L) on outdoor controller board is not disconnected.
3 Check if heat exchanger and filter is not dirty.
4 Measure resistance values among terminals on linear expansion valve
UL
using a tester.
1 Check the outdoor fan motor.
U8
2 Check if connector (TH3) (
connected.
)
Ud
63HS
1 Check if stop valves are open.
UF
2 Check looseness, disconnection, and converse connection of
compressor wiring.
3 Measure resistance values among terminals on compressor using a tester.
UP
4 Check if outdoor unit has a short cycle on its air duct.
UH
U6
1 Check if connectors(TH3,TH32,TH34,TH4, and TH7/6)on outdoor
U3
controller board and connector (CN3) on outdoor power board are not
disconnected.
2 Measure resistance value of outdoor thermistors.
U4
1 Check if indoor/outdoor units have a short cycle on their air ducts.
U5
2 Measure resistance value of outdoor thermistor(TH8).
1 Check looseness, disconnection, and converse connection of
U9
compressor wiring.
2 Measure resistance value among terminals on compressor using a tester.
3 Check if power supply voltage decreases.
4 Check the wiring of CN52C.
5 Check the wiring of CNAF.
1 Check if connectors (CN20, CN21, CN29 and CN44) on indoor
P1
controller board are not disconnected.
P2
2 Measure resistance value of indoor thermistors.
P9
1 Check if connector (CN31)(CN4F) on indoor controller board is not
P4
disconnected.
2 Measure resistance value of indoor thermistors.
3 Measure resistance value among terminals on drain-up machine using
P5
a tester.
4 Check if drain-up machine works.
5 Check drain function.
1 Check if indoor unit has a short cycle on its air duct.
P6
2 Check if heat exchanger and filter is not dirty.
3 Measure resistance value on indoor and outdoor fan motors.
4 Check if the inside of refrigerant piping is not clogged.
1 Check if indoor thermistors(TH2 and TH5) are not disconnected from holder.
P8
2 Check if stop valve is open.
3 Check converse connection of extension pipe. (on plural units connection)
4 Check if indoor/outdoor connecting wire is connected correctly.
(on plural units connection)
Error
Inspection method
T
) on outdoor controller board is dis-
63HS
Detailed
reference
page
P.27
P.29
P.27
P.31
P.29
P.29
P.31
P.29
P.27
P.28
P.28
P.28
P.29
**
**
**
**
**
**

Hide quick links:

Advertisement

Table of Contents
loading

Table of Contents