TCL Air Conditioner Service Manual IMPORTANT NOTICE This service manual is intended for use by individuals possessing adequate backgrounds of electrical, electronic and mechanical experience. It is to be installed and service by a licensed HVAC technician. Any attempt to repair the appliance may result in personal injury and property damage.
Note : If the air conditioner you purchased is a Cooling Only one, but you preset the remote controller as Heat Pump, it doesn t matter. But if the air conditioner you purchased is a Heat Pump one, and you preset the remote controller as Cooling Only, then you CAN NOT preset the Heating operation with the remote controller.
Page 5
TCL Air Conditioner Service Manual REMOTE CONTROLLER The four types of remote controller is as follow: GYKQ-05 GYKQ-10e (optional) GYKQ-11e (optional) GYKQ-12e (optional) Note: The function of remote controller above is the same.
Page 6
2. “I Feel” Mode Operation (1) When the “I Feel” mode is selected, the operation mode and initial set temperature are determined by the initial room temperature at start-up of the operation except to turn off the air conditioner and operates it again.
Page 7
Stop the fan During the heating operation, if the compressor stops that it will adjust the indoor fan speed, after 30 seconds to stop the fan. TCL Air Conditioner Service Manual More than 2 min More than 2 min Set Speed...
Page 8
Defrost terminating conditions When the condition c) or d) is satisfy, the defrosting operation will terminate. c) The outdoor defrost sensor reads 68 ℉ or more. d) The defrosting time exceeds 10 minutes. TCL Air Conditioner Service Manual -△IPT(14.4℉)...
Page 9
(2) When the rotational frequency feedback signal has not output for 5 seconds (or when the microprocessor can’t detect the signal for 5 seconds), the fan motor is regarded locked-up. Then the electric current to the fan TCL Air Conditioner Service Manual 5S Defrost Count MAX 12min 19S...
Page 10
(5) SWING mode When presses the SWING button, the vane swings. 12. TIMER Operation (1) To activate the air conditioner at the desire time, follow the procedure specified below(the remote control and air conditioner are switched off): Press the Timer button.
Page 11
Press the Timer button(‘h’ flashes). Use the ▲▼ button to select the time at which the air conditioner must activate (between 0 and 10 hours can be set at every half hour-between 10 and 24 hours can be set at every hour).
Page 12
In the display board the lamp from left is the POWER lamp(Red), the SLEEP lamp(Yellow), the TIMER lamp(Yellow), the RUN lamp(Green). g) When it gives the control power, the buzzer sounds long for 0.3 second per cycle. TCL Air Conditioner Service Manual...
1071990048 1070500246 1070350135 1070190013 1090500118 1070250425 1090050318 1070060003 1190470001 1190060054 1190060055 TCL Air Conditioner Service Manual Part Name Transformer Indoor Sensor Assembly In And Out Pipe Fixer Installation Plate Base Cross Fan Bearing Mount Heater Indoor Motor Indoor Motor Cover...
Page 23
1070500312 1073090114 1090700209 1073090121 1070500008 1090050318 1070060003 1190060003 1190060019 1190060020 1190060002 1190060021 TCL Air Conditioner Service Manual Part Name Installation Plate Base Cross Fan Bearing Mount Indoor Motor Indoor Motor Clamp Vane Motor Clip Base Evaporator Water Drainage Assembly Vertical Vane Supporter...
Page 25
1080010006 1170100032 1080020001 1120350781 1080170001 1070030016 1170040064 1080050004 1190070020 1190070002 1190070022 1190070021 TCL Air Conditioner Service Manual Part Name Grille Top Cover Condenser Left Grille Supporter Left Grille Front Plate Fan Guard Base Compressor And It Accessories 4-way Valve 4-way Valve Assembly...
Page 26
1170100030 1081990049 1120500852 1174561801 1141990004 1070030025 1170040112 1081990042 1190060191 1190500707 1190060190 1190070052 TCL Air Conditioner Service Manual Part Name Grille Top Cover Condenser Left Grille Supporter Left Grille Front Plate Fan Guard Base Compressor And It Accessories 4-way Valve 4-way Valve Assembly...
Page 27
1080010004 1170100029 1080050056 1120700526 1174561801 1140020003 1070030023 1170040115 1080050050 1190430001 1170230005 1190070041 TCL Air Conditioner Service Manual Part Name Grille Top Cover Condenser Left Grille Supporter Left Grille Front Plate Fan Guard Base Compressor And It Accessories 4-way Valve 4-way Valve Assembly...