OUT THE "SAFETY WARNINGS" TO PREVENT THE POSSIBILITY OF PERSONAL INJURY TO THE OPERATOR. Unbox the air compressor and write in the serial number in the space provided below. Inspect for signs of obvious or concealed freight damage. Be sure that all damaged parts are replaced and any mechanical problems are corrected prior to the operation of the air compressor.
READ ALL SAFETY WARNINGS BEFORE USING AIR COMPRESSOR HAZARD RISK OF EXPLOSION OR FIRE SAFETY WARNINGS POTENTIAL CONSEQUENCE Serious injury or death may occur from normal sparks in the engine ignition system or engine exhaust/ muffler. Injury or death may occur as a result of improper fueling.
If air tank develops a leak, replace the air tank immediately. Never repair, weld or make modifications to the air tank or its attachments. Use only genuine Senco repair ® parts for your air compressor. Never make adjustments to the factory set pressures.
READ ALL SAFETY WARNINGS BEFORE USING AIR COMPRESSOR HAZARD RISK OF BURNS RISK OF FLYING OBJECTS RISK FROM MOVING PARTS SAFETY WARNINGS POTENTIAL CONSEQUENCE Serious injury could occur from touching exposed metal parts. These areas can remain hot for some time after the air compressor is shutdown.
10°. Ensure the oil level is above the minimum notch and below the maximum notch on the dipstick. If low, add Senco part number ® PC0344 compressor pump oil. Always operate the air compressor in a stable, secure position to prevent air compressor from falling.
When the ring is released, it will reseat. Senco Gasoline Air Compressor Manual 2004 ® PC2017 FEATURES REVIEW AIR TANK DRAIN VALVE: The drain valve is used to remove moisture from the air tank(s) after the air com- pressor is shut off.
3. Read and understand the safety labels located on the air compressor. 4. A minimum of 86 octane fuel is recommended for use with this air compressor. Do not mix oil with gasoline. 5. Use of clean, fresh, lead free gasoline is recommended. Leaded gasoline may be used if lead free is not available.
5. Make sure all guards and covers are in place and securely mounted. START-UP: Read safety warnings before performing operation. 1. Flip the toggle on top of the pilot valve to the upright position. This provides a loadless start. The air compressor will unload and allow the engine to start easier.
Tighten fittings where air can be heard escaping. Check fittings with soapy water solution. Do not overtighten. SYMPTOM REMEDY Air tank must be replaced. Do not attempt to repair air tank! SYMPTOM REMEDY Contact Senco Customer Service @ 800-543-4596. Senco Gasoline Air Compressor Manual 2004 ®...
Page 13
Clean or replace. SYMPTOM REMEDY Clean or replace. Do not incline the air compressor more than 10° in any direction while running. Drain oil. Refill to proper level with Senco PC0344 oil. Clean. Repair. Contact Senco Customer Service 800-543-4596. SYMPTOM...
Page 14
Notes Senco Gasoline Air Compressor Manual 2004 ®...
Dimensions Basic L x W x H Shipping L x W x H Senco Gasoline Air Compressor Manual 2004 ® Specifications PC2017 SAE 10W 30 20 oz. Oil Alert Unleaded Gasoline 86 Octane Minimum .95 Gallon 3200 2.5" x 1.88"...
Senco warrants all parts (except those listed below) of your Senco air compressor to be free from defects in materials and workmanship during the following periods: 1.