Subscribe to Our Youtube Channel
Related Manuals for Joerns HPL402 Hoyer
Summary of Contents for Joerns HPL402 Hoyer
- Page 1 User Manual Joerns® Lifting and Repositioning HPL402 Hoyer® Power Patient Lift To avoid injury, read user’s manual before using.
-
Page 2: Table Of Contents
Warn cradle parts 9. Raise boom to highest position, pull vinyl boot could fail, resulting in injury to resident/caregiver. over bolted connection. Hanger post should protrude cradle center by 1/16th inch (Figure 1). © 2015 Joerns Healthcare • 000-3558 RevD • 15-2003... - Page 3 Actuator Screw, Cntrol Box Mtg Control Box Adjustment Handle Wire Clips (2) (Opposite Side) Power Cord Washer (4) Caster (Wheel) Mast Bumper Spreader Lock Scuff Guard Mast Lock Bolt Figure 2 © 2015 Joerns Healthcare • 000-3558 RevD • 15-2003...
-
Page 4: Troubleshooting Power Unit
• Replace control box • Handset defective • Send handset for repair Control box okay apart • Control box defective • Send control box for repair from one direction on one channel © 2015 Joerns Healthcare • 000-3558 RevD • 15-2003... -
Page 5: Operation
To lock casters, step on cam lever on side of casters. To unlock brakes, step on highest cam lever. Battery 1. Emergency Stop 2. Control Box 3. LCD-Display Charging Cord Hand Control Cord Actuator Cord © 2015 Joerns Healthcare • 000-3558 RevD • 15-2003... -
Page 6: Hoyer 4-Point Sling Information
Note: Do not use Hoyer slings with any other Patient can be raised 4" higher by hooking up the manufacturer’s lift. inside strap to the cradle. Patient Size Guide Example of label found on back of Partner Slings © 2015 Joerns Healthcare • 000-3558 RevD • 15-2003... -
Page 7: Lifter Maintenance Checklist
Wheel and swivel bearings Cleaning* ✔ Use mild soap to clean; dry thoroughly. ✔ Apply auto or appliance wax ✔ Keep painted surfaces clean from oil * Do not wash under water pressure. © 2015 Joerns Healthcare • 000-3558 RevD • 15-2003... -
Page 8: Warranty
+44 (0)844 811 1156 +31 (0)30 6363799 Charlotte, NC 28273 (P) 800.966.6662 (P) 866.546.1151 +44 (0)844 811 1157 (P) 800.826.0270 (F) 800.232.9796 (F) 519.451.8662 (F) 800.457.8827 www.Joerns.com • www.RecoverCare.com email: info@joerns.com © 2015 Joerns Healthcare • 000-3558 RevD • 15-2003...
Need help?
Do you have a question about the HPL402 Hoyer and is the answer not in the manual?
Questions and answers
My hydraulic cylinder for the HPL402 goes up but not down under electric power or by pulling the emergency release. Can it be fixed or replaced?
Yes, the hydraulic (actuator) component of the Joerns HPL402 Hoyer can be replaced if it goes up but not down. Possible causes include a defective actuator, control box, or handset. The manual suggests replacing the actuator or sending the control box or handset for repair depending on the issue.
This answer is automatically generated