• If technical assistance is required, contact Huffy Sports. • Minimum operational height is 6’6” (1.98m) to the bottom of backboard. Most injuries are caused by misuse and/or not following instructions. P/N 21173402 12/28/04 NOTICE TO ASSEMBLERS AND/OR PROPERTY DAMAGE AND WILL VOID WARRANTY.
Nut, Hex Flange, 5/16-18 Slam Jam Bracket, Black Bolt, “Tee” 3/8 - NC x 5 Long Bracket Reinforcement, Slam Jam Spring, Black Nut, Special 3/8-NC Washer, Flat 5/8 I.D. x 1-1/2 O.D. Bolt, Hex-Flange 5/16-18 x 2" Long 12/28/04 P/N 21173402...
Page 4
P/N 21173402 12/28/04 WARNING FAILURE TO FOLLOW THESE WARNINGS MAY RESULT IN SERIOUS INJURY AND/OR PROPERTY DAMAGE. Owner must ensure that all players know and follow these rules for safe operation of the system. • DO NOT HANG on the rim or any part of the system including backboard, support braces or net.
Page 6
Get to know the basic parts of your basketball system... BOARD POLE BASE WHEEL CARRIAGE ASSEMBLY Toll-Free Customer Service Number for U.S. : 1-800-558-5234 P/N 21173402 12/28/04 http://www.huffysports.com...
Page 7
Correctly identify each pole section. Poles have an identification sticker that will be used as a reference point in the next step. Reference Stickers MIDDLE BOTTOM Toll-Free Customer Service Number for U.S. : 1-800-558-5234 12/28/04 P/N 21173402 http://www.huffysports.com...
Page 8
POUNDED TOGETHER, THE POLE SECTIONS SHOULD HAVE A 3-1/2" MINIMUM OVERLAP, LEAVING 1- 1/2" BETWEEN THE OVERLAPPING POLE AND THE IDENTIFICATION STICKER. FIG B. scrap wood (Not Supplied) P/N 21173402 12/28/04 IMPORTANT! CAUTION! IDENTIFICATION STICKER middle pole IDENTIFICATION STICKER middle pole...
Page 9
IMPORTANT!: THE SPACER (10) WILL FIT LOOSELY UNTIL SECURED INTO THE CAVITY OF THE BASE. IMPORTANT!: BE SURE THAT THE SQUARE PORTION OF THE CARRIAGE BOLT IS PROPERLY SEATED IN THE SQUARE CUT-OUT OF THE WHEEL BRACKET. 12/28/04 P/N 21173402...
Page 10
When properly tightened, the wheel bracket will be tight against the base. An assistant is recommended to hold the base in place during this step. P/N 21173402 12/28/04 FIG B Toll-Free Customer Service Number for U.S. : 1-800-558-5234 http://www.huffysports.com...
Page 11
Secure free ends of tank struts to tank with carriage bolt (16), washer (22), and knob (17) as shown. Repeat for other side. WARNING! KNOBS MUST BE TIGHTENED COMPLETELY AND CHECKED PERIODICALLY FOR TIGHTNESS. Toll-Free Customer Service Number for U.S. : 1-800-558-5234 http://www.huffysports.com 12/28/04 P/N 21173402...
Page 12
Mount brackets (20 & 26) to backboard and finger tighten as shown. NOTE: Final adjustments will be made in Step 10. P/N 21173402 12/28/04 Toll-Free Customer Service Number for U.S. : 1-800-558-5234 http://www.huffysports.com...
Page 13
Install special nut (30) and washer (31) onto “T” bolt (27). E • Tighten nut (30) until flush with end of “T” bolt (27). Toll-Free Customer Service Number for U.S. : 1-800-558-5234 http://www.huffysports.com Install Slam Jam Rim to Backboard 12/28/04 P/N 21173402...
Page 14
While still in the horizontal position, carefully slide backboard components onto pole. Secure hardware at desired position as shown and tighten all hardware completely at this time. P/N 21173402 12/28/04 SAWHORSE OR SUPPORT TABLE Toll-Free Customer Service Number for U.S. : 1-800-558-5234 http://www.huffysports.com...
Page 15
(21) into ground and hooking T-strap (11) onto tie down stake (21). Toll-Free Customer Service Number for U.S. : 1-800-558-5234 http://www.huffysports.com CAUTION! ADD TWO GALLONS (7.6 LITERS) OF NON-TOXIC ANTIFREEZE IN SUB- FREEZING CLIMATES. 12/28/04 P/N 21173402...
Page 16
COULD RESULT IN BODILY HARM. BE SURE TO FOLLOW DIRECTIONS CAREFULLY. P/N 21173402 12/28/04 Insert one “arm” of clip into ram as shown. Twist “body” of clip slightly so that second “arm” slides over the top of the first “arm” as shown.
Page 17
Install net. Twist net until it snaps into position. Net must be centered through clip. Toll-Free Customer Service Number for U.S. : 1-800-558-5234 http://www.huffysports.com Insert net into bottom of clip as shown. SIDE VIEW NETCLIP SIDE VIEW NETCLIP 12/28/04 P/N 21173402...
Page 18
Attach height and moving label (15) to front of pole as shown. Regulation rim height is 10 feet. P/N 21173402 12/28/04 HEIGHT ADJUSTMENT Rest unit on support table. Remove adjustment knobs (A) and carriage bolts (B) to extend or retract backboard and rim.