Table of Contents
Advertisement
OWNER/OPERATOR MANUAL
MANUAL DEL PROPIETARIO/OPERADOR
WARNING
The engine exhaust from this product
contains chemicals known to the State
of California to cause cancer, birth
defects or other reproductive harm.
WARNING
Before using our products, please
read this manual carefully to
understand the proper use of your
unit.
APPLICABLE SERIAL NUMBERS: 300001 and up
BACKPACK BLOWER
SOPLADOR DE MOCHILA
EBZ5000/EBZ5000RH
ADVERTENCIA
Los gases de escape del motor de
este producto contienen sustancias
químicas conocidas por el Estado de
California como causantes de cáncer,
malformaciones en recién nacidos y
otros problemas de reproducción.
ADVERTENCIA
Antes de usar nuestros productos,
lea detenidamente este manual a fin
de familiarizarse con el uso correcto
de este aparato.
NÚMEROS DE SERIE APLICABLES: 300001 y posteriores
848-L3B-93A1 (501)
Advertisement
Table of Contents
Related Manuals for RedMax EBZ5000
Summary of Contents for RedMax EBZ5000
- Page 1 OWNER/OPERATOR MANUAL MANUAL DEL PROPIETARIO/OPERADOR SOPLADOR DE MOCHILA EBZ5000/EBZ5000RH WARNING The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm. WARNING Before using our products, please read this manual carefully to understand the proper use of your unit.
-
Page 2: Safety First
@ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ soplador RedMax. Si no lee @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @... -
Page 3: Table Of Contents
English Contents SAFETY PRECAUTIONS …………………………………………4 OPERATOR USE OF BLOWER FUEL WORKING CONDITION AVOID NOISE PROBLEM AVOID CHANCES OF DAMAGE WARNING LABELS ON THE MACHINE …………………………8 SYMBOLS ON THE MACHINE ……………………………………9 PARTS LOCATION ………………………………………………10 SPECIFICATIONS …………………………………………………11 ASSEMBLY …………………………………………………………12 BLOWER TUBE THROTTLE LEVER THROTTLE CABLE FUEL…………………………………………………………………13... -
Page 4: Safety Precautions
? @ @ @ @ @ @ @ @ ? e @ @ @ @ @ @ @ @ e ? @ @ @ @ @ @ @ @ ? e @ @ @ @ @ @ @ @ e ? @ @ @ @ @ @ @ @ ? e @ @ @ @ @ @ @ @ e ? @ @ @ @ @ @ @ @ ? e @ @ @ @ @ @ @ @ e ? @ @ @ @ @ @ @ @ ? e @ @ @ @ @ @ @ @ e ? @ @ @ @ @ @ @ @ ? e @ @ @ @ @ @ @ @ e ? @ @ @ @ @ @ @ @ ? e @ @ @ @ @ @ @ @ e ? @ @ @ @ @ @ @ @ ? e @ @ @ @ @ @ @ @ ■ OPERATOR • Refrain from operating the blower if you are tired, ill, or upset, or if you are under the influence of alcohol, drugs or medication. - Page 5 • Avoid using accessory attachment other than those bearing the RedMax mark for use with the blower. • Drain the fuel from the fuel tank before transporting or storing the blower. • When storing the blower, choose a space indoors free from moisture and out of the reach of children.
-
Page 6: Fuel
• Make sure the unit is properly assembled and in good operating condition. ■ WORKING CONDITION • Check the work area that the blower will be used in and remove or cover all valuables that may be damaged by the air blast or thrown debris. -
Page 7: Avoid Noise Problem
• Watch out for children, pets, open windows or freshly washed cars, and blow debris safely away. • Use the full blower nozzle extension so the air stream can work close to the ground. • After using blowers and other equipment, CLEAN UP! Dispose of debris in trash receptacles. -
Page 8: Warning Labels On The Machine
(3) Handling this machine improperly could result in accidents causing serious injury or death. Read this manual carefully and practice using the blower until you are fully acquainted with all operations and have learned to use it correctly. IMPORTANT If warning label peel off or become soiled... -
Page 9: Symbols On The Machine
IMPORTANT ENGINE INFORMATION THIS ENGINE MEETS U.S. EPA PH2 EMISSION REGULATIONS FOR SI SORE’s COMPLIANCE PERIOD : CATEGORY A ENGINE FAMILY : 5KZXS. 0484HI ; EM ENGINE DISPLACEMENT : 48cc REFER TO OWNER’S MANUAL FOR MAINTE- NANCE SPECIFICATIONS AND ADJUSTMENTS. MANUFACTURED: MADE IN JAPAN INFORMATION IMPORTANTE CONCERNANT LE MOTEUR... -
Page 10: Parts Location
English Parts Location 1. Frame 2. Shoulder Strap 3. Spark Plug Cap 4. Throttle Lever 5. Ignition Switch (behind) 6. Net 7. Choke Lever 8. Air Cleaner 9. Volute Case 10. “CAUTION” Label 11. “CAUTION” Net Label (behind) 12. Elbow 13. -
Page 11: Specifications
English Specifications MODEL EBZ5000/EBZ5000RH Dimensions (L x W x H) mm (in) ...530 x 540 x 475 (20.9 x 21.3 x 18.7) ...(RH) 1352 x 496 x 475 (13.9 x 19.6 x 18.7) Dry Weight kg (lbs) ...8.9 (19.6) Fuel Tank Capacity liter (fl. oz) ...2.0 (67.6) -
Page 12: Assembly
[EBZ5000RH] [EBZ5000RH] English Assembly ■ BLOWER TUBES 1. Connect the blower and swivel joint with flexible hose. Clamp both ends of the flexible hose securely with the hardware supplied with the unit. 2. Align the protrusion and the groove provided on the tube ends and twist the tube until connection is locked up. -
Page 13: Fuel
English Fuel ■ FUEL WARNING • Gasoline is very flammable. Avoid smoking or bringing any flame or sparks near fuel. Make sure to stop the engine and allow it cool before refueling the unit. Select outdoor bare ground for fueling and move at least 3m (10ft) away from the fueling point before starting the engine. -
Page 14: How To Mix Fuel
English Fuel ■ HOW TO MIX FUEL IMPORTANT Pay attention to agitation. 1. Measure out the quantities of gasoline and oil to be mixed. 2. Put some of the gasoline into a clean, approved fuel container. 3. Pour in all of the oil and agitate well. 4. - Page 15 English Fuel of rubber and/or plastic parts and disruption of engine lubrication. 3. OIL FOR 4-CYCLE ENGINE USE – It can cause spark plug fouling, exhaust port blocking, or piston ring sticking. 4. Mixed fuels which have been left unused for a period of one month or more may clog the carburetor and result in the engine failing to operate properly.
-
Page 16: Operation
• Do not let a person stand near the blower or the exhaust port. Español ■ BRAZO DE CONTROL [EBZ5000] • Sostenga el extremo superior del brazo de control en la mano y, mientras tira de él, gire el brazo hacia adelante (en el sentido contrario a las agujas del reloj, en la dirección de la flecha) hasta... -
Page 17: Adjusting Idle Speed
“O” “ I ” [EBZ5000] [EBZ5000RH] English Operation 5. Once the engine is running, gradually open the choke if it was set closed, and let the engine run at idle speed for a minute to warm it up. NOTE When the engine fails to start after several attempts due to overchoking, open the choke and repeat pulling the rope. -
Page 18: Maintenance
■ AIR CLEANER • Never operate the blower without an air filter or with a deformed or broken filter element. • Check the air cleaner every 25 hours of use or more frequently if used under dusty conditions. -
Page 19: Fuel Filter
English Maintenance Set the packing into the air cleaner body. Set the cover with 2 fixing screws. (1) Cover Cleaner (5) Packing (2) Screen (6) Yellow (3) Cleaner Body (7) Black (4) Element NOTE • Assure that the screen is securely fitted to the packing. -
Page 20: Spark Plug
• Inspect periodically, the muffler for loose fasteners, any damage or corrosion. If any sign of exhaust leakage is found, do not use the blower and have it repaired immediately. • Note that failing to do so may result in the engine catching on fire. -
Page 21: Air Inlet Net
(1) Net WARNING Never use the blower without the net of the blower. Before each use, check that the net is attached in place and is free from any damage. -
Page 22: Storage
English Storage BEFORE STORING THE BLOWER: 1. Drain a fuel tank and push the primer bulb until it becomes empty of fuel. 2 .Remove the spark plug and drop a spoonful of 2-cycle oil into the cylider. Crank the engine several time and install the spark plug. -
Page 23: Parts List
APPLICABLE SERIAL NUMBERS: 300001 and up PARTS LIST LISTA DE PIEZAS BACKPACK BLOWER SOPLADOR DE MOCHILA EBZ5000/EBZ5000RH NOTA: 1. Para reparaciones o cambios, utilice piezas 2. KOMATSU ZENOAH no garantiza máquinas 3. Al solicitar piezas para reparación y/o 4. Las piezas incluidas en la lista de piezas 5. - Page 24 Parts List : EBZ5000/EBZ5000RH Fig.1 BLOWER GROUP (S/N 300001 and up)
- Page 25 EBZ5000/EBZ5000RH Fig.1 BLOWER GROUP Key# Part Number Description T4017-31110 VOLUTE CASE 2 848-L36-55B0 VOLUTE COVER T4970-52510 SCREW T4970-52510 SCREW T4030-31410 ELBOW 07000-02095 O-RING T4960-57030 SCREW 3310-53331 T4017-31310 FUNNEL 10 848-8K4-0010 CLAMP T4970-51410 SCREW 2750-31290 TUBE T4017-31510 T4950-63031 BOLT T4017-31610 ENGINE COVER...
- Page 26 Parts List : EBZ5000/EBZ5000RH Fig.2 ENGINE GROUP (S/N 50100000 and up)
- Page 27 EBZ5000/EBZ5000RH Fig.2 ENGINE GROUP Key# Part Number Description T1108-12110 CYLINDER T1108-12210 GASKET, BASE 4820-12130 BOLT T1108-12310 PLATE T4960-50810 SCREW T1108-13160 INSULATOR 848-815-2001 BOLT 8 848-GC0-14B1 GASKET, INSU T1108-13130 GASKET, CARB T1108-15110 MUFFLER T1108-15120 ARRESTER 1410-86130 CLIP T4950-67031 BOLT T4950-61431 BOLT T1108-15210 GASKET, MUFF T1108-21101 CRANKCASE COMP.
- Page 28 Parts List : EBZ5000/EBZ5000RH Fig.3 CARBURETOR COMPONENTS Key# Part Number Description T1108-81450 Body assy ————— Screen ————— Valve ————— Spring ————— Screw ————— ————— Lever 1850-81490 Body 1850-81520 Cover 1751-81510 Pump 5500-81160 Washer 1881-81140 Swivel 1751-81130 Ring 4810-81410 Gasket 1065-81420...
- Page 29 Parts List : EBZ5000/EBZ5000RH Fig.4 LEVER SET [EBZ5000] (S/N 300001 and up) Key# Part Number Description T4017-25000 LEVER SET T4012-25100 • LEVER 3310-53331 • NUT 01642-20508 • WASHER T4012-25211 • ARM T4012-25311 • BRACKET 3495-25410 • BOLT 3495-25420 • SPRING 3495-25440 •...
-
Page 30: Limited Warranty
ZENOAH AMERICA INC. AT (770)-381-5147. IMPORTANT: YOU WILL RECEIVE A WARRANTY REGISTRATION CARD AT TIME OF PURCHASE.PLEASE FILL OUT THE CARD AND SEND IT TO RedMax / KOMATSU ZENOA AMERICA WITHIN SEVEN (7) DAYS.BE SURE TO KEEP A COPY FOR YOUR RECORDS. - Page 31 ZENOAH AMERICA INC. LLAMANDO AL (770)-381-5147. IMPORTANTE: RECIBIRÁ UNA TARJETA DE REGISTRO DE GARANTÍA EN EL MOMENTO DE LA COMPRA. LLENE LA TARJETA Y ENVÍELA A RedMax / KOMATSU ZENOAH AMERICA DENTRO DE SIETE (7) DÍAS. ASEGÚRESE DE CONSERVAR UNA COPIA PARA SUS REGISTROS.
- Page 32 Telles sont les limites de la garantie. Le coût du transport de l'unité jusqu'au revendeur RedMax et depuis celui-ci sera à la charge de l'acheteur. L'acheteur ne supportera pas le coût de main d'oeuvre du diagnostic qui amène à la conclusion qu'une pièce garantie est défectueuse, si ce diagnostic est effectué...