Maintenance And Lubrication - Suzuki Wagon R Plus RB310 Service Manual

MAINTENANCE AND LUBRICATION

WARNING:
For vehicles equipped with a Supplemental Restraint (Air Bag) System:
• Service on and around the air bag system components or wiring must be performed only by an
authorized SUZUKI dealer. Refer to "System Components and Wiring Location View and Connec-
tors" under "General Description" in air bag system section in order to confirm whether you are
performing service on or near the air bag system components or wiring. Please observe all WARN-
INGS and "Service Precautions" under "On-Vehicle Service" in air bag system section before per-
forming service on or around the air bag system components or wiring. Failure to follow
WARNINGS could result in unintentional activation of the system or could render the system inop-
erative. Either of these two conditions may result in severe injury.
• Technical service work must be started at least 90 seconds after the ignition switch is turned to the
"LOCK" position and the negative cable is disconnected from the battery. Otherwise, the system
may be activated by reserve energy in the Sensing and Diagnostic Module (SDM).
Maintenance Schedule ...................................0B-3
Maintenance Schedule Under Normal
Driving Conditions .........................................0B-3
Maintenance Recommended Under
Severe Driving Conditions.............................0B-5
Maintenance Service.......................................0B-6
Drive Belt Inspection (M13 Engine)...............0B-6
Water pump and generator drive belt
inspection ..................................................0B-6
A/C Compressor drive belt (if equipped)
inspection ..................................................0B-6
Drive Belt Replacement (M13 Engine)..........0B-6
Water pump and generator drive belt
replacement...............................................0B-6
A/C Compressor drive belt (if equipped)
replacement...............................................0B-6
Drive Belt Inspection (G10 Engine) ...............0B-7
A/C compressor drive belt inspection (If
equipped) ..................................................0B-7
Water pump belt inspection.......................0B-7
Drive Belt Replacement (G10 Engine) ..........0B-8
A/C compressor drive belt replacement ....0B-8
Water pump belt replacement ...................0B-8
Camshaft Timing Belt Replacement
(G10 Engine).................................................0B-8
Valve Lash (Clearance) Inspection
(M13 Engine).................................................0B-8
Engine Oil and Oil Filter Replacement ..........0B-9
Engine Coolant Replacement .....................0B-11
Exhaust System Inspection.........................0B-11
Spark Plugs Replacement...........................0B-11
SECTION 0B
CONTENTS
Distributor Cap and Rotor Inspection
(G10 Engine)............................................... 0B-12
Air Cleaner Filter Inspection........................ 0B-12
Air Cleaner Filter Replacement................... 0B-12
Fuel Lines and Connections Inspection ...... 0B-12
Fuel Tank Inspection................................... 0B-13
PCV Valve Inspection ................................. 0B-13
Fuel Evaporative Emission Control
System Inspection....................................... 0B-13
Brake Discs and Pads (Front) Inspection ... 0B-13
Brake Drums and Shoes (Rear)
Inspection.................................................... 0B-14
Brake Hoses and Pipes Inspection ............. 0B-14
Brake Fluid Replacement............................ 0B-14
Brake Lever and Cable Inspection.............. 0B-14
Clutch Inspection ........................................ 0B-15
Tires Inspection........................................... 0B-15
Wheel Discs Inspection............................... 0B-16
Wheel Bearing Inspection ........................... 0B-16
Suspension System Inspection................... 0B-16
Steering System Inspection ........................ 0B-16
Drive Shaft (Axle) Boots Inspection ............ 0B-17
Propeller Shafts (4WD) Inspection.............. 0B-17
Manual Transmission Oil Inspection ........... 0B-18
Manual Transmission Oil Replacement ...... 0B-18
Automatic Transmission Fluid Level
Inspection.................................................... 0B-18
Automatic Transmission Fluid
Replacement............................................... 0B-19
Automatic Transmission Fluid Cooler
Hose Inspection .......................................... 0B-19
MAINTENANCE AND LUBRICATION 0B-1
0B