Advertisement
GENERAL INFORMATION
SERVICE RULES
1. Use genuine Honda or Honda-recommended parts and lubricants or their equivalents. Parts that do not meet Honda's design
specifications may cause damage to the
motorcycle.
2.
Use the special tools designed for this product to avoid damage and incorrect
assembly.
3.
Use only metric tools when servicing the motorcycle. Metric bolts, nuts and screws are not interchangeable with English
fasteners
.
4.
Install new gaskets,
0-rings,
cotter pins
,
and lock plates when reassembling.
5.
When tightening bolts or
nuts,
begin with the larger diameter or inner bolt first. Then tighten to the specified torque diagonally in
incremental steps unless a particular sequence is specified
.
6.
Clean parts in cleaning solvent upon
disassembly.
Lubricate any sliding surfaces before reassembly.
7. After
reassembly,
check all parts for proper installation and operation.
8. Route all electrical wires as shown in the Cable and Harness Routing (page 1-19).
9.
Do not bend or twist control cables
.
Damaged control cables will not operate smoothly and may stick or bind
.
ABBREVIATION
Throughout this manual, the following abbreviations are used to identify the respective parts or systems.
Abbrev. term
Full term
ABS
Anti-lock Brake System
CKP sensor
Crankshaft Position sensor
DLC
Data Link Connector
DTC
Diagnostic Trouble Code
ECM
Engine Control Module
ECT sensor
Engine Coolant Temperature sensor
EEPROM
Electrically Erasable Programmable Read Only Memory
EVAP
Evaporative Emission
IACV
Idle
Air Control Valve
IAT
sensor
Intake Air Temperature sensor
MAP sensor
Manifold Absolute
Pressure
sensor
MCS
Motorcycle Communication System
MIL
Malfunction Indicator Lamp
PAIR
Pulse Secondary Air Injection
PGM-FI
Programmed Fuel
Injection
SCS connector
Service Check Short connector
TP sensor
Throttle
Position sensor
VS sensor
Vehicle Speed sensor
DESTINATION CODE
Throughout this
manual,
the following codes are used to identify individual types for each region.
DESTINATION CODE
REGION
A
49-State
AC
50-State (meets California emissions standards)
CM
Canada
1-2
Advertisement
