Table of Contents
Advertisement
Model:
PP4300/PP6600/PP6600E/PP7600E
IMPORTANT - Please make certain the person
who uses this generator thoroughly reads these
instructions and all other instructions provided to
ensure proper safety, use, and care of your new
Consumers service: 1-800-849-1297
portable electric generator.
WWW.POULANPRO.COM
Advertisement
Table of Contents
Related Manuals for Poulan Pro PP4300
Summary of Contents for Poulan Pro PP4300
- Page 1 Model: PP4300/PP6600/PP6600E/PP7600E IMPORTANT - Please make certain the person who uses this generator thoroughly reads these instructions and all other instructions provided to ensure proper safety, use, and care of your new Consumers service: 1-800-849-1297 portable electric generator. WWW.POULANPRO.COM...
-
Page 2: Table Of Contents
TABLE OF CONTENTS INTRODUCTION ...2 SAFETY RULES ... 3-4 SYMBOLS... 5-7 FEATURES ... 8-10 ASSEMBLY ... 1 -1 OPERATION ... 14 6 ELECTRICAL...17 MAINTENANCE ... 18 19 STORAGE...20 TROUBLESHOOTING ...21 WARRANTY ...2 -2 PARTS ORDERING/SERVICING ... This product has many features for making its use more pleasant and enjoyable. Safety, performance, and dependability have been given top priority in the design of this product, making it easy to maintain and operate. -
Page 3: Safety Rules
DANGER Running generator gives off carbon monoxide, a n odorless, colorless, poison gas. Breathing carbon monoxide will cause nausea, fainting, or death. ● Operate generator ONLY outdoors. ● Keep clearance on all sides of generator for adequate ventilation. ● DO NOT operate generator inside any building or enclosure, including the generator compartment of a recreational vehicle (RV). -
Page 4: Safety Rules
WARNING Unintentional sparking can result in fire or electric shock. WHEN ADJUSTING OR MAKING REPAIRS TO YOUR GENERATOR ● Disconnect the spark plug wire from the spark plug and place the wire where it cannot contact spark plug. WARNING Running engines produce heat.Temperature of muffler and nearby areas can reach or exceed 150°F (65°C). -
Page 5: Symbols
Some of the following symbols may be used on this generator. Please study them and learn their meaning. Proper interpretation of these symbols will allow you to operate the generator better and safer. SYMBOL NAME Volts Amperes Hertz Watt Minutes Alternating Current Direct Current No Load Speed... - Page 6 The following signal words and meanings are intended to explain the levels of risk associated with this product. SYMBOL SIGNAL Indicates an imminently hazardous situation which, if not avoided, DANGER: or serious injury Indicates an imminently hazardous situation which, if not avoided, WARNING: or serious injury Indicates an imminently hazardous situation which, if not avoided,...
- Page 7 SAFETY LABELS The following labels are found on the generator. For your safety, please study and understand all of the labels before starting the generator. If any of the labels come off the unit or become hard to read, contact an authorized service center for replacement. FUEL WARNING DO NOT SMOKE when filling with gasoline.
-
Page 8: Features
Dry Weight Dimensions: Length Width Height Fuel Tank Capacity FEATURES PP4300 PP6600 60 Hz 60 Hz 120 / 240 Volts 120 / 240 Volts 120 / 240 Volts 120 / 240 Volts 4300 Watts 6600 Watts Single Cylinder, Forced Air Cooling, 4-Stroke... - Page 9 FUEL LEVEL GAUGE CHOKE LEVER AIR FILTER FUEL VALVE RECOIL STARTER GRIP HANDLE PP4300 CONTROL PANEL FEATURES FUEL TANK FUEL TANK GROUNDING TERMINAL OIL DRAINAGE BOLTS FOOT AC CIRCUIT BREAKER 120 VOLTS AC RECEPTACLES 120/240 VOLTS AC RECEPTACLES BATTRAY (IF EQUIPPED)
- Page 10 KNOW YOUR GENERATOR Fig. with all operating features and safety rules. GROUNDING TERMINAL The grounding terminal is used to assist in properly grounding the generator to help protect against electrical shock. Consult with a local electrician for grounding requirements in your area. RECEPTACLES Your generator has the following single phase, 60 Hz outlets: four 120 Volt AC, 20 Amp, and one 120 Volt/240...
-
Page 11: Assembly
ASSEMBLY UNASSEMBLED PARTS Fig. The following assembly hardware items are included with the generator. Whee l Assembly Handle Assembly...1 Foot Assembly...1 Fig. - Page 12 INSTRUCTIONS This product requires assembly. Carefully remove the generator and any accessories ■ from the box. NOTE: The generator is heavy. To avoid back injury, lift with your legs, not your back, and get help when needed. Make sure that all items listed in the unassembled ■...
- Page 13 INSTALLING WHEEL ASSEMBLY 2 wheels 2 flat washers 2 pins 4 olts 4 nuts Slide wheel over axle extension. ■ Slide flat washer on axle extension. ■ Install hex nut on axle extension and tighten to ■ secure. Repeat for second wheel. ■...
-
Page 14: Operation
GROUNDING THE GENERATOR The National Electrical Code requires that the frame and external electrically conductive parts of this generator be properly connected to an approved earth ground. Local electrical codes may also require proper grounding of the unit. For that purpose, a GROUNDING FASTENER is provided on the generator end (Figure ). -
Page 15: Oxygenated Fuels
DANGER: Failure to properly ground generator can result in electrocution, especiallyif the generator is equipped with a wheel kit. National Electric Code requires generator to be properly grounded to an approved earth ground. Call an electrician for local grounding requirements WARNING: Do not use any attachments or accessories not recommended by the manufacturer of this generator. -
Page 16: Starting The Engine
If using an oxygenated fuel, make sure it is unleaded and meets the minimum octane rating requirements. Before using an oxygenated fuel, try to confirm the fuel抯 contents. Some states/provinces require this information to be posted on the pump. The following are the EPA approved percentages of oxygenates: Ethanol (ethyl or grain alcohol) 10% by volume. -
Page 17: Electrical
DON'T OVERLOAD GENERATOR CAPACITY Make sure the generator can supply enough rated (running) and surge (starting) watts for the items you will power at the same time. Follow these simple steps: 1. Select the items you will power at the same time. 2. -
Page 18: General Maintenance
Only the parts shown on the parts list are intended to be repaired or replaced by the customer. All other parts should be replaced at a Poulan Pro Authorized Service Center. GENERAL MAINTENANCE... -
Page 19: Maintenance
CLEANING FUEL SEDIMENT CUP gotten into the fuel tank from entering the carburetor. If the engine has not been run for a long time, the sediment cup should be cleaned before use. Turn the fuel valve to the off position. ■... -
Page 20: Storage
MAINTENANCE SCHEDULE S E R V IC E IT E M S G e n e ra l In s p e c tio n C h e c k O il L e v e l C h a n g e E n g in e O il C le a n A ir C le a n e r C le a n C ylin d e r C o o lin g F in s C le a n S p a rk P lu g... -
Page 21: Troubleshooting
PROBLEM Engine will not start AC receptacle does not work Generator makes a "park knock"or " inging noise " If problem persists after trying the above solutions, please call 1- TROUBLESHOOTING POSSIBLE CAUSE Engine switch is OFF No fuel Oil level is low Check spark plug condition Fuel is not reaching carburetor Fuel valve is in OFF position... -
Page 22: Warranty
1. FEDERAL EMISSION CONTROL W ARRANTY STATEMENT YOUR WARRANTY RIGHTS AND OBLIGATIONS The United States Environmental Protection Agency(EPA), together with Husqvarna Consumer Outdoor Products NA, Inc., are pleased to explain the emission control system warranty on your new model year small off-road engines. - Page 23 II. EMISSION CONTROL SYSTEM WARRANTY Emission Control System Warranty (ECS Warranty) for 2009 and later model engines: (a) Applicability: This warranty shall apply to 2009 and later model year engines. The ECS Warranty Period shall begin on the date the new engine or equipment is purchased by/delivered to its original, end-use purchaser/owner and shall continue for 24 consecutive months thereafter.
- Page 24 WARRANTY Husqvarna Consumer Outdoor Products NA, Inc. engine. Such use voids this ECS Warranty and shall be sufficient grounds for disallowing an ECS Warranty claim. Husqvarna Consumer Outdoor Products NA, Inc. shall not be held liable hereunder for failures of any warranted parts of a Husqvarna Consumer Outdoor Products NA, Inc.
- Page 25 EMISSIONS MAINTENANCE SCHEDULE AND WARRANTED PARTS LIST Emissions Parts AIR FILTER ASSY INCLUDES: FILTER...X...X SPARK SCREEN...X CARBURETOR ASSY INCLUDES: HEAT DAM GASKETS FUEL TANK ASSY INCLUDES: FUEL LINES...X FUEL CAP ...X FUEL FILTER IGNITION ASSY INCLUDES SPARK PLUG...X ALL EMISSIONS-ELATED PARTS ARE WARRANTED FOR TWO YEARS, OR FOR THE PERIOD OF TIME PRIOR TO PART'S FIRST SCHEDULED REPLACEMENT-HICHEVER COMES FIRST.
-
Page 26: Limited Warranty
This is a limited Warranty within the meaning of that term as defined in the Magnuson-Moss Act of 1975. LIMITED WARRANTY Poulan Pro HOP Customer Service Dept. 1030 Stevens Creek Road Augusta, GA 30907 USA... - Page 27 SERVICE NOTES...
- Page 28 Now that you have purchased your tool, should a need ever exist for repair parts or service, simply contact your nearest Poulan Pro Authorized Service Center. Be sure to provide all pertinent facts when you call or visit. Please call 1-8 Pro Authorized Service Center.