Page 1
OPERATOR'S MANUAL MODEL: PBGT26H54X GARDEN TRACTOR ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com Do Not Throw Away 03090 WARNING: Read this Man u al and follow all Warnings and Safety Instructions. Fail ure to do so can re sult in serious in ju ry.
Safe Operation Practices for Ride-On Mowers DANGER: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROW ING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH. WARNING: In order to prevent ac- ci den tal starting when setting up, trans port ing, ad just ing or making re- pairs, al ways dis con nect spark plug...
Page 3
Safe Operation Practices for Ride-On Mowers III. CHILDREN Tragic accidents can occur if the operator is not alert to the presence of children. Children are often attracted to the ma chine and the mowing activity. Never assume that children will remain where you last saw them. •...
Your new tractor has been assembled at the factory with exception of those parts left unassembled for shipping pur- poses. TOOLS REQUIRED FOR ASSEMBLY A socket wrench set will make assembly easier. Stan dard wrench sizes are listed. (1) 3/4" wrench (1) Utility knife (1) 9/16"...
Page 7
ASSEMBLE FRONT WHEEL TO MOWER (See Fig. 3) • Using shoulder bolt, washer and locknut from parts bag, as sem ble front wheel to mower as shown. Tighten securely. FIG. 3 INSTALL MOWER AND DRIVE BELT (See Figs. 4-12) See MOWER AND DRIVE BELT ASSEMBLY Supplement Sheet for additional guidance on this assembly.
Page 8
• ATTACH MOWER SIDE SUSPENSION ARMS (A) TO CHASSIS - Position hole in arm over pin (B) on outside of tractor chassis and secure with washer and retainer spring. • Repeat on opposite side of tractor. FIG. 8 • ATTACH REAR LIFT LINKS (C) - Insert rod end of lift link assembly into hole in tractor lift shaft suspension arm (L) and pivot link down to mower.
• Disengage belt tension rod (K) from locking bracket (L). • Install belt onto engine clutch pulley (M). IMPORTANT: Check belt for proper routing in all mower pulley grooves. FIG. 12 • Engage belt tension rod (K) on locking bracket (L). CAUTION: Belt tension rod is spring loaded.
These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their mean- ing. REVERSE NEUTRAL REVERSE ENGINE OFF OPERATION SYSTEM (ROS) LIGHTS ON BATTERY FUEL ATTACHMENT ATTACHMENT CLUTCH DISENGAGED CLUTCH ENGAGED FREE WHEEL (Automatic Models only) Failure to follow instructions could result in serious injury or...
Page 11
KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and ad just ments. Save this manual for future reference. Our tractors conform to the applicable safety standards of the American National Standards Institute. (A) ATTACHMENT LIFT LEVER –...
Page 12
The operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye dam age. Always wear safety glass es or eye shields while operating your tractor or per form ing any ad just ments or repairs. We rec om mend standard safety glasses or a wide vision safety mask worn over spectacles.
Page 13
TO USE THROTTLE CONTROL (See Fig. 16) Always operate engine at full speed (fast). • Operating engine at less than full speed (fast) reduces engines operating efficiency. • Full speed (fast) of fers the best bagging and mower per for mance. TO USE CHOKE CONTROL (D) (See Fig.
Page 14
FIG.19 TO OPERATE MOWER (See Fig. 20) Your tractor is equipped with an operator presence sensing switch. Any attempt by the operator to leave the seat with the engine running and the attachment clutch engaged will shut off the engine. You must remain fully and centrally positioned in the seat to prevent the engine from hesitating or cutting off when operating your equipment on rough, rolling terrain or hills.
Transmission Engaged Transmission Disengaged FIG. 21 SERVICE REMINDER/HOUR METER Service reminder shows the total number of hours the engine has run and flashes to indicate that the engine or mower needs servicing. When service is required, the service reminder will flash for two hours. To service engine and mower, see the Maintenance section of this manual.
Page 16
• The attachments and ground drive can now be used. If the engine does not accept the load, restart the engine and allow it to warm up for one minute using the choke as described above. COLD WEATHER STARTING (50° F and below) •...
TRACTOR Always observe safety rules when per form ing any main- te nance. BRAKE OPERATION If tractor requires more than five (5) feet to stop at highest speed in high est gear on a level, dry concrete or paved surface, then brake must be serviced. (See “TO CHECK BRAKE”...
• Rinse the battery with plain water and dry. • Clean terminals and battery cable ends with wire brush until bright. • Coat terminals with grease or petroleum jelly. • Reinstall battery (See “REPLACING BATTERY" in the SERVICE AND ADJUSTMENTS section of this man u al).
ENGINE OIL FILTER Replace the engine oil filter every season or every other oil change if the tractor is used more than 100 hours in one year. MUFFLER Inspect and replace corroded muffler and spark arrester (if equipped) as it could create a fire hazard and/or dam- age.
SERVICE AND ADJUSTMENTS WARNING: TO AVOID SERIOUS INJURY, BEFORE PERFORMING ANY SER VICE OR AD JUST - MENTS: • Depress brake pedal fully and set parking brake. • Place attachment clutch in “DISENGAGED” position. • Turn ignition key to “STOP” and remove key. •...
Page 22
SERVICE AND ADJUSTMENTS • Go to side of mower you wish to adjust. • With a 3/4" or adjustable wrench, turn lift link adjust- ment nut (A) to the left to lower the mower, or, to the right to raise the mower. Turn nut right to raise mower 02948...
Page 23
SERVICE AND ADJUSTMENTS TO REPLACE MOWER BLADE DRIVE BELT MOWER DRIVE BELT REMOVAL (See Fig. 32) • Park tractor on a level surface. En gage parking brake. • Lower attachment lift lever to its lowest position. • Disengage belt tension rod (K) from lock bracket (L). CAUTION: Belt tension rod is spring loaded.
Page 24
SERVICE AND ADJUSTMENTS TO CHECK BRAKE If tractor requires more than five (5) feet to stop at highest speed in high est gear on a level, dry concrete or paved surface, then brake must be serviced. You may also check brake by: •...
Page 25
SERVICE AND ADJUSTMENTS WASH ERS RE TAIN ING RING AXLE COVER SQUARE KEY (REAR WHEEL ONLY) FIG. 34 TO START ENGINE WITH A WEAK BATTERY (See Fig. 35) WARNING: Lead-acid batteries gen- er ate ex plo sive gases. Keep sparks, flame and smoking ma te ri als away from bat ter ies.
Page 26
SERVICE AND ADJUSTMENTS TO REPLACE HEADLIGHT BULB • Raise hood. • Pull bulb holder out of the hole in the backside of the grill. • Replace bulb in holder and push bulb holder securely back into the hole in the backside of the grill. •...
Immediately prepare your tractor for storage at the end of the season or if the tractor will not be used for 30 days or more. WARNING: Never store the trac tor with gas o line in the tank inside a building where fumes may reach an open flame or spark.
TROUBLESHOOTING POINTS PROBLEM CAUSE Will not start 1. Out of fuel. 2. Engine not “CHOKED” properly. 3. Engine flooded. 4. Bad spark plug. 5. Weak or dead battery. 6. Dirty air filter. 7. Dirty fuel filter. 8. Water in fuel. 9.
TROUBLESHOOTING POINTS PROBLEM CAUSE Engine dies when 1. Reverse operation system tractor is shifted (ROS) is not "ON" while into reverse mower or other attachment is engaged. Engine continues to 1. Faulty operator-safety presence control system. run when operator leaves seat with attachment clutch engaged Poor cut - uneven...
The Manufacturer warrants to the original consumer purchaser that this product as manufactured is free from defects in materi- als and work man ship. For a period of two (2) years from date of purchase by the original consumer purchaser, we will repair or replace, at our option, without charge for parts or labor incurred in replacing parts, any part which we find to be defective due to materials or workmanship.
Model Number/Manufacturer's I.D. Number b. Description of part. For Techical Assistance: call 1-800-829-5886 For a Parts Manual, go to our website: www.poulan-pro.com/support.asp NOTE: HOP provides parts and service through its au thor ized dis tribu tors and dealers; there fore, all requests for parts and service should be directed to your local dealer(s).
Page 33
à mises votre S.V.P contactez Manuel, caractéristiques produits. philosophie proche. plus pièces mande toute conséquent l’intermédiaire www.poulan-pro.com/support.asp 1-800-849-1297 appelez autorisé: d’effectuer machine votre durabilité pour Comme stricts. dards stan CHANGE concernant l’assistance tions dans décrites celles différentes complète gamme nence agréé...
Page 35
1975. droits donne vous garantie Cette vous. conséquent, implicite garantie d’une Certaines FABRICANT. EXPLICITES IMPLICITE GARANTIE TOUTE CONSÉQUENT Ontario concessionnaire l’adresse ainsi contactez: concessionnaire à machine votre retourner standard, visserie normaux, réglages normal. usage utilisés modifiés, été produits instructions conformément entretenus quatre-vingt- à...
Page 36
moteur. avant lent) rapide (entre intermédiaire position dans commande transmission. déplacement. d'entraînement courroie position libre roue commande l’alternateur. régulateur. connexions. toutes Vérifiez/remplacez batterie. fusible. connexions. câblage phares. l’interrupteur Vérifiez/remplacez lampe(s). l'ampoule(s) (ON). marche position dans l’interrupteur trous ouvrir pour mandrin faces manuel.
Page 37
endommagées. pièces Remplacez lâches. pièces lame. mandrin lame. boulon fond à Serrez lame. autorisé. d’entretien centre Réglages. Entretien dans Carburateur” Régler “Pour section câblage. tout silencieux. Nettoyez/remplacez moteur/ailettes. d’air tamis d’allumage. bougie serrez d’essence. filtre fraîche, l’essence avec réservoir carburateur, réservoir l’essence fraîche.
Page 38
SONT D’ÉCHAPPEMENT ENDROITS QUAND TRACTEUR JAMAIS COUVREZ tracteur. condensation formation permet obstrue plastique plastique. N’uti perméable. couverture avec saleté. poussière couvrez-le possible, l’intérieur, à tracteur causera l’essence dans saleté et/ou rouiller. à commence s’il d’essence l’autre. à saison d’une d’essence SUPPLÉMENTAIRE d’allumage.
Page 39
réglage. et/ou réaration autorisé d'entretien centre gazon à tondeuse teur, avec problèms cause tion fonc moteur votre réglable. CARBURATEUR voir né réglage nécessaire. réglage l’usine à préréglée été COMMANDE RÉGLER voir nécessaire, réglage nécessaire. réglage l’usine à préréglée été CÂBLE FIG.
Page 40
FIG. 02954 (NOIR) NÉGATIF CÂBLE restent. taquets à écrou boulon borne à NOIR batterie masse au-dessus borne couverture Glissez fond. comme taquets à écrou boulon avec à ROUGE batterie câble branchez batterie. même dans bornes avec batterie batterie enlevez ROUGE batterie NOIR batterie...
Page 41
pneu. corrosion l'asséchement péces. dépositaure votre chez acteter pouves vous fuites, cause à pour pneus crevaisons boucher couvre-essieu. d’essieu. retenue bague fond à insérez rondelles carrée. clé Insérez l’essieu. arrière dans rainures alignez seulement: rassemblez-le. pas). perdez carrée arrière roue roue l’enlèvement permettre...
Page 42
haute. plus position à levage enclenchez-la tige fermement ressort. à mécanisme possède cour- tension tige ATTENTION manette courroie tension vis. toutes (Q). droit gauche mandrins couvercles tondeuse. poulies place bien courroie Assurez-vous électrique l’embrayage poulie montré. tension mandrins poulies autour D’ENTRAÎNEMENT COURROIE REGLAGES...
Page 43
réglage. l’écrou contre fermement serrez clé avec place réglage à inférieure 1/2’’ à 1/8’’ lame avant jusqu’à nécessaire ajustez mesures, 1/8’’. d’environ tondeuse modifie réglage l’écrou complet tour FIG. d’abord. contre-écrou 02950 tondeuse. baisser pour d’ajustement tondeuse. l’écrou Desserrez d’ajustement FIG.
Page 44
soulever. pour droite abaisser pour gauche vers levage l’écrou tournez 3/4», ajustable nécessaire. ajustement désiré. surélevé, côté ton- abaissé côté soulever pouvez bas. plus coupe tondeuse côté uniforme, façon coupée semble adéquatement. gonflés soient pneus Fig. (Voir VISUEL LATÉRAL correctement. ajustée croire faire...
Page 45
votre tracteur votre débris gazon, enlever pour feuilles à souffleuse l’air Utiliser tracteur. votre transmission, moteur l’intérieur. à l’eau l’infiltration soient transmission moteur votre nettoyer pour pression sous lavage d’arrosage tuyau d’un l’utilisation d’auto. cire avec peintes surfaces etc. l”huile l’essence, enlevant roues...
Page 46
moteur. manuel Voir sales. endroits dans utilisé souvent plus à filtre avec correctement fonctionne séchés. gomme fibres toutes enlever pour comprimé l’air toyez- surchauffage. cause à moteur pour céréale balle saleté libre D’AIR TAMIS fini. avez vous quand fond à Serrez d’huile.
Page 48
TYPE POUDRE SEC, LUBRIFIANT AVEC SEULEMENT UTILISEZ LUBRIFIÉS, QU’ILS PENSEZ VOUS AUTOMATIQUE. À PALIERS DURABILITÉ POUSSIÈRE ATTIRENT NYLON. PALIERS GRAISSE HUILE METTEZ MOTEUR SOUS ENTRETIEN SECTION USAGE 02956 MANDRIN PRESSION À ➀ GRAISSEUR ➁ MOTEUR ANTÉRIEURE ROUE PALIER PRESSION À ➀...
Page 49
l’ac à terrain convient toujours choisissez accessoires, coupe. meilleure tondeuse donne course vitesse Choisissez ment char dé tondre rendement pour plein à commande avec tondre. avant l’herbe sécher Laissez mouillée ’herbe mouillée. elle quand désirée. hauteur à faire doit haute. assez coupe pour...
Page 50
encore. sayez d'étrangleur commande pas, dé moteur encore. quelques d'étrangleur commande cinq quatre essayé avoir après démarre minute. secondes quinze plus pendant sans démarreur N’utilisez démarre. clé relâchez (START) démarrage d’une aiguilles sens dans clé sui- instructions lisez commencer, nécessaire. ceci chaud teur...
Page 51
etc.). câble, (corde, Utilisez tracteur. fixé fermé soit capot que, camion tracteur pendant dommages capot protéger procédé inversez transmission, mph). km/h vitesse à tracteur votre jamais poussez désengagée. à soit qu’elle pour relâchez-la rainure à vers au-dehors libre roue d’ac levage commande tion...
Page 52
trou même dans roue Installez côté. Serrez approprié. trou dans roue légèrement montées être devraient coupe hauteur pour désirée à fonctionnment section dans COUPE HAUTEUR RÉGLER (Voyez désirée coupe hauteur à tracteur quand roues terrains. plupart dégazonnement pour place carter gardent roue coupe...
Page 53
FIG. etc. se-herbe, vider tracteur; quitter ci-dessus, décrit comme ment, tracteur toujours Arrêtez ATTENTION: gazon. tracteur moteur toujours coupez dommages, causer peunent chaud moteur ralenti, marche tracteur PLAT) BATTERIE OFF, POSITION LASISSÉ D'ALLUMAGE CONTACT arrêter pour commande autorisée. l’emploi empêcher pour vous quand...
Page 54
pour utilisé – 12-VOLT PUISSANCE nécessaire. tondeuse lorsque Indique D’ENTRETIEN/HOROMÈTRE démarrer permet DÉTRANGLEUR moteur quand tracteur remorquage transmission débraye LIBRE ROUE reculer faire à Sert ARRIÈRE MARCHE avancer faire à Sert AVANT MARCHE pédale appuyer sans voulue avancer faire à Sert VITESSE COMMANDE...
Page 55
propriété. l'endommagement blessures mort, conséquence pourrait évité, n'est s'il propriété. et/ou sérieuses conséquence comme avoir s'il qui, risque indique et/ou tracteur résulter pourrait situation symbole sans utilisé mineures blessures évité, n'est s'il qui, risque sérieuses. conséquence comme n'est s'il qui, risque mort conséquence...
Page 56
nuel dans TRANSMISSION” DÉMARRER “POUR sections sion trans purge démarrage instructions Suivez fois. première démarrer avant transmission purger manuel). Entretien chapitres (Cf. correctement fonctionnent arrière marche fonctionnement l’opérateur présence Système ris- sans fonctionne frein système com- toutes l’emplacement fonction vous assurez-vous moteur, plomb...
Page 57
FIG. (J). ressort-arrêtoir d’une l’aide à fermement fixez tondeuse support l’orifice dans bielle embout support. derrière situé bielle ressort-arrêtoir 7/16 d’un l’aide à fermement tracteur avant suspension support dans bielle l’assemblage l’embout gauche à Commencez – AVANT vers droites, soient roues sorte FIG.
Page 58
FIG. montré. ressort-arrêtoir, d’un rondelle d’une l’aide à place barre. insérer pour besoin tondeuse tondeuse arrière support l’arrière extrémité l’autre insérez vous vers barre FIG. 02995 (T). transmission support l’orifice dans insérez tondeuse, droit côté (S). ANTI-ROULIS BARRE D’ABORD celui-ci. soit qu’elle jusqu’à...
Page 59
suivantes. instructions “Stop”. neutre. vitesse levier placez frein actionner tracteur, arrêter pour palette. hors diriger l’avant vers vitesse levier stationnement. commande dé moteur, manuel).. Fonctionnement section DÉ- (POUR (voir moteur démarrez haute. plus position dans d’accessoire dispositif placer levage levier (N).
Page 60
Vidange Guide-pente 3/8-16 Épaulement frein Écrou Rondelle O.D. 1-1/4 Roue MONTÉES Clés Arrières Bielles Clés Tube Rondelle O.D. à Boulon Roue Rondelle PIÉCES mouvement Barre 1-3/16 5/16 Retenue Ressort Petit 7/16 Retenue O.D. Ressort Grand Tondeuse...
Page 61
28-29 DÉPANNAGE 21-26 RÉGLAGES 17-20 manuel). PIÈCES tion (Voir proche plus centre disponible silencieux l’opérateur. etat maintenu être doit Quand applicables. locales lois pare-étincelles d’un muni n’est d’herbe d’arbrisseaux, d’arbres, près utilisé être doit à moteur d’un équipé tracteur propriétaire. manuel Entretien sections...
Page 62
descente. dans lentement tournez dans nécessaire, n’est cela pentes dans virage lentement. reculez arrière lames, dégagez montée, s’arrête pente. vers lames dégagez plus, n’adhèrent dans virages arrêts démarrages, pentes. dans vitesse devoir afin faible vitesse transversalement. maxi), (15° descendant montant arrière.
Page 63
s’éboule. bord par-dessus l’improviste à culbuter risque fossés ravins, proximité pied mettant machine stabiliser l’utilisez machine. risquent accessoires d’autres avec machine utilisez vous lorsque machine. culbuter faire vitesse brusquement jamais changez lents mouvements n’effectuez pente. vers lames dégagez plus, n’adhèrent dans virages arrêts...
Page 64
É.-U. IMPRIMÉ 12-10-07 418793 sécurité. tions ments aver résulter peuvent sérieuses bles- sécurité. ments aver soigneusement AVERTISSEMENT: JETEZ www.poulan-pro.com l’utilisation. lors PBGT26H54X struc lisez vous sures tions struc tous suivez Lisez L'OPÉRATEUR 03090 web: site notre sécurité lunettes toujours JARDIN TRACTEUR MODÈLE:...