Download Print this page

Motorola MOTOTRBO XIR R8200 Installation Manual

Professional digital two-way radio system repeater.
Hide thumbs

Advertisement

Advertisement

   Also See for Motorola MOTOTRBO XIR R8200

   Related Manuals for Motorola MOTOTRBO XIR R8200

   Summary of Contents for Motorola MOTOTRBO XIR R8200

  • Page 3: Foreword

    No duplication or distribution of this document or any portion thereof shall take place without the express written permission of Motorola. No part of this manual may be reproduced, distributed, or transmitted in any form or by any means, electronic or mechanical, for any purpose without the express written permission of Motorola.

  • Page 4: Installation Requirements For Compliance With Radio Frequency (rf) Energy Exposure Safety Standards

    Product Safety and RF Exposure booklet enclosed with each radio (Motorola Publication part number 6881095C99) to ensure compliance with Radio Frequency (RF) energy exposure limits. For a list of Motorola-approved antennas and other accessories, visit the following web site which lists approved accessories for your radio model: http://www.motorola.com/governmentandenterprise...

  • Page 5: Declaration Of Conformity

    FCC logo shown below. DECLARATION OF CONFORMITY Per FCC CFR 47 Part 2 Section 2.1077(a) Responsible Party Name: Motorola, Inc. Address: 1301 East Algonquin Road, Schaumburg, IL 60196-1078, U.S.A. Phone Number: 1-888-567-7347 Hereby declares that the product: Model Name: XPR 8300 conforms to the following regulations: FCC Part 15, subpart B, section 15.107(a), 15.107(d) and section 15.109(a)

  • Page 6

    Notes...

  • Page 7: Table Of Contents

    Related Publications ..................vii Repeater Model Numbering Scheme............ix Commercial Warranty ...................xi Limited Warranty ............................xi MOTOROLA COMMUNICATION PRODUCTS ................xi I. What This Warranty Covers and For How Long..............xi II. General Provisions .........................xi III. State Law Rights (Applicable Only in U.S.A.)............... xii IV. How to Get Warranty Service ....................xii V.

  • Page 8

    Antennas ..............................6-1 Cables ..............................6-1 Miscellaneous Accessories ........................6-1 Appendix A Replacement Parts Ordering..........A-1 Basic Ordering Information ......................A-1 Motorola Online..........................A-1 Appendix B Motorola Service Centers...........B-1 Servicing Information ........................B-1 Motorola de México, S.A........................B-1 Motorola de Colombia, Ltd......................B-1 February 2008 6816814H01...

  • Page 9: List Of Figures

    Locations of Connectors on the Rear Panel of the Repeater ..........4-1 Figure 4-2 Making Connections to a Backup Battery ................4-2 Related Publications MOTOTRBO XPR Series Mobile Radios Basic Service Manual ..........6816810H01 Motorola Quality Standards Fixed Network Equipment Installation Manual R56 .......6881089E50 Product Safety and RF Exposure booklet ................. 6881095C99...

  • Page 10

    List of Figures Notes February 2008 6816814H01...

  • Page 11: Repeater Model Numbering Scheme

    Repeater Model Numbering Scheme Repeater Model Numbering Scheme Model No.Example : Position Unique Model Variations AZ: Asia/Australia N: Standard Package LA: Latin America AA: North America (except Mexico) MD: Europe/Middle East/Africa Version Letter Repeater Feature Level 1: Mini-U MOTOTRBO Repeater 2: BNC Model Series 7: Rack Mount...

  • Page 12

    Notes February 2008 6816814H01...

  • Page 13: Commercial Warranty

    XPR 8300 Repeater Two (2) Years Motorola, at its option, will at no charge either repair the Product (with new or reconditioned parts), replace it (with a new or reconditioned Product), or refund the purchase price of the Product during the warranty period provided it is returned in accordance with the terms of this warranty.

  • Page 14: State Law Rights (applicable Only In U.s.a.)

    Warranty service will be provided by Motorola through one of its authorized warranty service locations. If you first contact the company which sold you the Product, it can facilitate your obtaining warranty service. You can also call Motorola at 1-888-567-7347 US/Canada.

  • Page 15: Vi. Patent And Software Provisions

    A. that MOTOROLA will be notified promptly in writing by such purchaser of any notice of such claim; B. that MOTOROLA will have sole control of the defense of such suit and all negotiations for its settlement or compromise; and C.

  • Page 16

    Commercial Warranty Notes February 2008 6816814H01...

  • Page 17: Chapter 1 Pre-installation Considerations

    If this is the first time this type of equipment is being installed, it is highly recommended that the user read: • this entire installation section before beginning the actual installation, and • the Motorola Quality Standard Fixed Network Equipment Installation manual, R56 (6881089E50), specifically refer to the information on ground connection for lightning protection.

  • Page 18: Equipment Ventilation

    Pre-Installation Considerations Equipment Ventilation For equipment operating in an area which is not environmentally controlled and with the repeater(s) cabinet mounted, airborne particle level must not exceed 90 µg/m³. If the repeater is to be installed in an environment which is usually dusty, dirty, or does not meet the air quality requirements, then the air used to cool the repeater modules must be treated using appropriate filtering devices.

  • Page 19: Site Grounding And Lightning Protection

    NOTE: Motorola recommends the following reference source: Motorola Quality Standards Fixed Network Equipment Installation Manual R56……………………...……………........6881089E50 1.6.4...

  • Page 20

    Pre-Installation Considerations Notes February 2008 6816814H01...

  • Page 21: Chapter 2 Mechanical Installation

    - 13.4 cm (5.25 inches) high - Two mounting rails 5 cm (2 inches) from the front of the cabinet with front mounting holes 5.7 cm (2.25 inches) apart (center to center). Contact Motorola Technical Support for specific question(s) regarding mounting equipment in customer-supplied cabinets.

  • Page 22

    Mechanical Installation Notes February 2008 6816814H01...

  • Page 23: Chapter 3 Indicators And Connectors

    Chapter 3 Indicators and Connectors Front Panel 3.1.1 LED Indicator Descriptions Status Description Solid GREEN Repeater powered by AC. Power Solid RED Repeater powered by backup battery. Repeater powered off. Solid RED Repeater function disabled. Repeater Blinking RED Repeater in self-test mode. Disabled Repeater in normal operational mode.

  • Page 24: Rear Panel

    Indicators and Connectors Rear Panel 3.2.1 Rear Panel Part Item Description Rx Connector BNC (Female). Power Supply On/Off Turns on or off the power to the repeater from AC input. Switch Battery Backup Connector Backup battery supplies backup power to the repeater. The (DC Input) battery is an optional accessory.

  • Page 25: Rear Accessory Connector

    3.2.2 Rear Accessory Connector The rear accessory connector is located above the ethernet connector. Most of the Motorola- approved accessories are supplied with female terminals crimped to a 20-gauge wire specifically designed to fit the housing of the rear accessory connector.

  • Page 26

    Indicators and Connectors Rear Panel Table 3-1 Rear Accessory Connector Pin Functions Pin Name Pin Function Pin Name Pin Function USB + (Data) Rx Audio Receive Live Audio USB - (Data) AUX Audio 2 PUBLIC Address 2 USB Power (5V from USB VBUS Ground accessory/cable)

  • Page 27: Chapter 4 Electrical Connections

    Chapter 4 Electrical Connections After the MOTOTRBO Repeater has been mechanically installed, electrical connections must be made. This involves making the following connections: • AC power cord, and • antenna coaxial cables Figure 4-1 shows the position of the various connectors and connections on the rear panel of the repeater.

  • Page 28: Ground Connection

    The repeater is equipped with a ground screw located on the rear of the repeater. Connect the site ground cable to the ground screw. Refer to Motorola Quality Standards Fixed Network Equipment Installation Manual R56 (6881089E50), for complete information regarding lightning protection.

  • Page 29: Rf Antenna Connections

    The antenna must be connected to the duplexer with a high grade 50 Ohm transmission line (hardline). The line must have connectors to match the connectors on the duplexer and antenna. For proper antenna installation, please also consult the Motorola Quality Standards Fixed Network Equipment Installation Manual R56 (6881089E50).

  • Page 30

    Electrical Connections Notes February 2008 6816814H01...

  • Page 31: Chapter 5 Post-installation Checklist

    Chapter 5 Post-Installation Checklist After the MOTOTRBO Repeater has been mechanically installed and all electrical connections have been made, power may now be applied and the repeater checked for proper operation. Applying Power Before applying power to the repeater, make sure all boards are securely seated in the appropriate connectors on the backplane and that all RF cables are securely connected.

  • Page 32

    Post-Installation Checklist Notes February 2008 6816814H01...

  • Page 33: Chapter 6 Accessories

    Chapter 6 Accessories Antennas RDD4527_ VHF 3.0 dB Gain Antenna, 150 – 158 MHz RDE4557_ 3.8 dB Gain Omni Antenna 403 – 420 MHz RDE4556_ 3.8 dB Gain Omni Antenna 450 – 470 MHz RDE4555_ 3.8 dB Gain Omni Antenna 470 – 488 MHz RDE4554_ 3.8 dB Gain Omni Antenna 488 –...

  • Page 34

    Accessories Notes February 2008 6816814H01...

  • Page 35: Appendix A Replacement Parts Ordering

    XPR 8300 Repeater Basic Service Manual (Motorola publication part number 6816810H01) includes complete parts lists and parts numbers.

  • Page 36

    Replacement Parts Ordering Parts Identification Parts Identification Radio Products and Solutions Organization* (United States and Canada) 1-800-422-4210 Product Customer Service Radio Products and Solutions Organization (United States and Canada) 1-800-927-2744 * The Radio Products and Solutions Organization (RPSO) was formerly known as the Radio Products Services Division (RPSD) and/or the Accessories and Aftermarket Division (AAD).

  • Page 37: Appendix B Motorola Service Centers

    If a unit requires further complete testing, knowledge and/or details of component level troubleshooting or service than is customarily performed at the basic level, please send the radio to a Motorola Service Center as listed below. Motorola Service Center 45D Butterfield Trail...

  • Page 38

    Motorola Service Centers Notes February 2008 6816814H01...

Comments to this Manuals

Symbols: 0
Latest comments:
  • Chitta Sarker May 29, 2018 11:15:
    Hello,
    I would like to get your help about DC Lead connector of MOTOTRBO XIR R8200 Repeater.