Dtc 1-1 (Shift Pedal Angle Sensor Malfunction) - Honda CTX700N/ND Service Manual

i
DUAL CLUTCH TRANSMISSION ( DCT ) ( CTX 700 D / ND )
DTC 1 - 1 ( SHIFT PEDAL ANGLE
SENSOR ( OPTIONAL ) MALFUNCTION )
NOTE :
• Before starting this inspection , check for loose or
poor contact
on the shift pedal angle
sensor 3 P
( Blue ) connector and PCM 33 P connectors , and
recheck the DTC
.
• If the PCM is replaced
,
perform the following :
-
Clutch Initialize Learning Procedure (
page 12
-
81 )
- DCT Shift Pedal ( Optional ) Registration
( page 12
-
79 )
•
If the DCT
shift pedal ( Optional ) is removed from the
vehicle , perform the DCT Shift Pedal Registration
Cancellation ( page 12
-
80 )
.
1
.
Recheck the DTC
Erase the
DTCs ( page 12
-
10 ) .
Turn the ignition switch ON and engine stop
switch
"
O
"
.
Operate the DCT shift pedal up and down several
times with the engine stopped .
Recheck the DTC with the
MCS .
Is the DTC 1
-
1
indicated
?
YES
-
GO TO STEP 2
.
NO
-
Intermittent failure
2
.
Shift Pedal
Angle Sensor
Input
Voltage
Inspection
Turn the ignition switch OFF .
Remove the left under side cowl (
page
2
- 13 )
Disconnect the shift pedal angle sensor 3 P ( Blue )
connector .
Turn the ignition switch ON
.
Measure the voltage between the wire harness side
shift pedal angle sensor 3 P ( Blue ) connector [ 1 ]
terminals
.
Connection : Yellow / red ( + ) -
Green / yellow ( -
)
Is the voltage within 4.75 - 5.25 V ?
YES
-
GO TO STEP 4
.
NO
-
GO TO STEP 3
.
1
Y / R G/ Y
V
© ©
3
.
Shift Pedal Angle Sensor Open Circuit
Inspection
Turn the ignition switch OFF
.
Disconnect
the PCM 33 P ( Gray ) connector
( page 4
-
34 )
.
Check for continuity between the wire
harness side
shift pedal angle sensor 3 P ( Blue ) connector [ 1 ] and
PCM 33 P ( Gray) connector [ 2 ] terminals
.
Connection : Green/ yellow - B 22
Yellow / red
-
B 14
TOOL :
Test probe , 2 packs 07 ZAJ - RDJA 110
Is there continuity ?
YES
- Replace the PCM with a known good one ,
and recheck
.
[ 2 ]
O
Y
/ R
G/ Y
/
Q
[ 1 ] B 22
B 14
NO
-
• Open
circuit in Green/ yellow wire
• Open
circuit in Yellow / red wire
)
)
I
)
I
J
19
-
54