Summary of Contents for I.C.E Crane WH6-120-6
- Page 1 OWNERS AND SERVICE MANUAL INNOVATIVE CONCEPTS IN ENTERTAINMENT INC. 10123 MAIN STREET, CLARENCE, NY 14031 SERVICE: 1-716-759-0360 FAX: 1-716-759-0884 E-MAIL: service@icegame.com WEBSITE: www.icegame.com...
-
Page 2: Table Of Contents
TABLE OF CONTENTS INTRODUCTION………………………………………...PAGE 3 GAME FEATURES • GAME PLAY • SET-UP / TESTING / MAINTENANCE………………..PAGE 4 SAFETY PRECAUTIONS • GAME SET-UP • ASSEMBLY • TESTING • CLEANING • PROGRAMMING………………………………………..PAGE 5 - 9 OPTION MODES • ERROR CODES • QUICK TROUBLESHOOTING…………………………PAGE 10 - 11 PROBLEMS AND SOLUTIONS •... -
Page 3: Introduction
GAME FEATURES Thank you for your purchase of the new PINNACLE CRANE™ game from I.C.E. The brand new PINNACLE CRANE™ all metal crane game by I.C.E. was designed with the operator in mind. Reliability, low maintenance, themed cabinetry and all metal construction are the key design features, exactly what is needed to ensure a combination of long life and high profit. -
Page 4: Setup / Testing / Maintenance
SETUP / TESTING / MAINTENANCE BEFORE YOU BEGIN IMPORTANT: FAILURE TO FOLLOW THESE DIRECTIONS CLOSELY COULD CAUSE SERIOUS DAMAGE TO YOU AND/OR YOUR GAME. WARNING: WHEN INSTALLING THIS GAME, A 3 PRONG GROUNDED A.C. RECEPTACLE MUST BE USED. FAILURE TO DO SO COULD RESULT IN INJURY TO YOURSELF OR OTHERS. -
Page 5: Programming
MODE DESCRIPTION (Credit Display) Game Type Game Mode Time Coin Bill Counter Type Attract Attract Type F / B Speed L / R Speed Up Speed Down Speed Right Time Forward Time Tickets to Play Tickets if Lose Factory Default Center On / Off Snap On / Off Up / Down Motor Test... - Page 6 0. GAME TYPE—There are 5 game types: − 0 Left, Right, Forward, Backward, Nudge—This mode is for a control panel that commonly has a joystick and allows the player to lower the claw each time the drop button is pressed. This allows the player to hone in on the prize they are attempting to win.
- Page 7 12. RIGHT TIME—This option allows the operator to adjust the time the right drive motor will stay on, for centering purposes at game start up. Available time settings are 0—40 intervals of 1/4 sec. EXAMPLE: If this option is set at 5, then at coin up the right drive motor will stay on for (5 * 1/4 sec.
- Page 8 PROGRAMMING Entering the Programming Mode To enter the programming mode, open the front door and press the button marked PROG, located near the main board, and the crane will move to the front center of the game. NOTE: The game WILL NOT go into the programming mode if the door is “closed”, or the door switch has been pulled to its outer most position.
-
Page 9: Error Codes
Every time that the game is powered up, the door is closed or exiting programming mode, the game will run through a test mode to check the following items: - HOME BACK SWITCH - HOME LEFT SWITCH - UP SWITCH - DOWN SWITCH If any of the above items are malfunctioning, the game will light up the 4 decimal points on the podium dis- plays. -
Page 10: Quick Troubleshooting
QUICK TROUBLESHOOTING PROBLEM THE DECIMALS ON THE 4 THIS IS IN FACT NOT A PROBLEM BUT A WAY DISPLAYS ARE LIT UP OF LETTING THE OPERATOR KNOW THAT THERE WAS A PROBLEM DURING THE START UP MODE NO GAME POWER ON-OFF SWITCH ON THE GAME IS TURNED OFF BLOWN A.C. -
Page 11: Quick Troubleshooting
QUICK TROUBLESHOOTING - NOTE: A self test will be performed each time the front door is “closed” , the game is powered up, or when you exit programming mode. - NOTE: The game will not count credits or plush out on either the mechanical or software counters while the front door is open. -
Page 12: Game Repair
WARNING: ALWAYS REMOVE POWER FROM THE GAME BEFORE ATTEMPTING ANY SER- VICE, UNLESS NEEDED FOR SPECIFIC TEST- ING. FAILURE TO OBSERVE THIS PRECAU- TION COULD RESULT IN SERIOUS INJURY TO YOURSELF AND / OR OTHERS. TROUBLESHOOTING PHILOSOPHY To find problems with the game, always check the obvious first. - Page 13 8. Remove bolts holding playfield in place near bottom of the glass. 9. Install new glass from the inside of the game and drop into channel in the playfield. 10. Reinstall retainers, lights, brackets, marquee, playfield bolts and rails in reverse order. PLUSH RETAINER WALL REPLACEMENT 1.
- Page 14 STRING REPLACEMENT 1. Remove all A.C. power from the game. 2. Unlock and open front door. 3. Remove crane assembly as previously stated. 4. Disconnect the claw assembly from the crane as- sembly by removing the two bolts securing the alu- minum coil cap to the coil housing.
- Page 15 FUSE REPLACEMENT CAUTION FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE ONLY WITH THE SAME TYPE OF FUSE HAVING THE SAME ELECTRICAL RATING. AREA LOCATION MAIN BOARD POWER MOD — ROPE LIGHT — CONTROLLER CORD REPLACEMENT IF THE SUPPLY CORD IS DAMAGED, IT MUST BE REPLACED BY THE MANUFACTURER OR ITS SERVICE AGENT OR A SIMILARLY QUALIFIED PERSON IN ORDER TO AVOID A HAZARD.
-
Page 16: Electrical / Electronic Repair
MECHANICAL PARTS 5011 SPRING BC1002 LEFT REAR CORNER BC1003 RIGHT REAR CORNER BC1004 CABINET FRAME BC1005 DOOR PANEL BC1006 DOOR FRAME BC1007 PRIZE DOOR BC1008 SIDE PANEL BC1011 SIDE WINDOW RETAINER BC1013 LOCK CAM BC1014 UPPER LOCK ROD BC1015 LOWER LOCK ROD BC1016 DOOR WHEEL BRACKET BC1017... -
Page 39: Warranty Information
Warranty I.C.E warrants all components in the PINNACLE CRANE™ game to be free of defects in materials and workmanship for a period of ninety days from the date of purchase. This warranty does not cover items damaged due to normal wear and tear, subjected to abuse, improperly assembled by the end user, modified, repaired, or operated in a fashion other than that described in the service manual. - Page 40 WARRANTY ICE Inc warrants that all of its products will be free from defects in material and workmanship. When placing a warranty request, please be prepared to provide the following information: • Serial Number of Game or Bill of Sale •...