Table of Contents
Advertisement
Quick Links
INSTALLATION, OPERATION AND MAINTENANCE MANUAL
Please read carefully before proceeding with installation. Failure to follow attached
instructions or operating parameters may lead to the product's failure.
******************************************************************************************
ZERO WASTE REVERSE OSMOSIS SYSTEM
Premier, Inc.
Phone: 800-752-5582
#199229
Warning
Save manual for future reference.
Model ZRO-4
System is in compliance with the Uniform Plumbing
Code (UPC®),International Plumbing Code (IPC®),
and IGC 159-2000A
8716 W Ludlow Drive Suite #1
www.PremierH2o.com
Peoria, AZ 85381
Fax: 623-866-5666
Manual Date: 02/22/2016
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Premier ZRO-4
Summary of Contents for Premier ZRO-4
- Page 1 Please read carefully before proceeding with installation. Failure to follow attached instructions or operating parameters may lead to the product’s failure. ****************************************************************************************** Save manual for future reference. Model ZRO-4 ZERO WASTE REVERSE OSMOSIS SYSTEM System is in compliance with the Uniform Plumbing Code (UPC®),International Plumbing Code (IPC®), and IGC 159-2000A Premier, Inc.
- Page 2 . There may also be some local water issues in your area such as high levels of lead, radium and copper. This Premier water treatment system has been designed and tested to provide you with high quality water for years to come.
-
Page 3: Table Of Contents
Thank you for your purchase of a Premier Zero Waste Reverse Osmosis system. With proper installation and maintenance, this system will provide you with high quality water for years to come. All of Premier water enhancement products are rigorously tested by independent laboratories for safety and reliability. -
Page 4: Operational Parameters
Premier supplies speciality fi lters (part number 107008) that can be used if copper tubing follows the Reverse Osmosis unit. Be sure to follow any state or local regulations during installation. -
Page 5: Important Notice
***IMPORTANT NOTICE*** Not recommended for use on homes equipped with tankless water heaters. Contact Premier for specifi c details regarding this unit and tankless water heaters. System was tested in a laboratory setting utilizing a hot water heater of 40 gallons set at 120º F. -
Page 6: Installation Of Faucet
Installation of Faucet Step 6 Place the escutcheon chrome plate and the black rubber washer on the faucet shank. (Parts found in faucet parts bag). Step 7 Insert the faucet shank through the hole in sink and let it rest on the sink top. Step 8 From the underside of the sink, slide on the locating washer, lock washer and brass nut onto the shank. -
Page 7: Adapt-A-Valve Installation
Attach the Adapt-a-Valves as illustrated in the three photos above, choosing the confi guration that fi ts your plumbing. WARNING: Do not use tefl on tape with the Premier Adapt-a-Valve. Connect the Green and Black Tubing Step 13 Locate the 1/4” green tubing attached to the RO system. Insert the open end of the green 1/4”... -
Page 8: Blue Tube Connection (From The Ro Module To Tank)
Blue Tube Connection (From The RO Module To TANK) Step 17 Position tank in desired location. Stand it upright or lay it on its side (using the black plastic stand). Measure the blue tube (marked “TANK”) from the RO module to the tank and cut it to length leaving a straight, square edge. -
Page 9: Month System Maintenance
Stage 2 - Carbon Block Filter (part #: 101009-White End Caps) Note: The fi lter wrench pictured (Part # 164003) may be purchased from Premier to aid with twist- ing off fi lter housings but is not required. Step 1 Close the ball valve on the RO storage tank and open the RO Faucet. -
Page 10: Annual Maintenance
Annual Maintenance - Filter Kit #560032 Items needed: √ Stage 1 - Sediment Filter (part #: 104017) √ Stage 2 - Carbon Block Filter (part #: 101009-White end caps) √ Stage 4 - 10” Final Polishing fi lter (part # 560010) √... -
Page 11: Membrane Maintenance
TDS reduction falls below 75%. A water sample may be sent to Premier for a free diagnosis of your membrane performance. To send a water sample, use two (2) clean containers and fi ll ½ cup of tap water in one container and ½... -
Page 12: Check Air Pressure In The Tank
Check Air Pressure in the Tank Important: Check air pressure only when tank is empty of water! Check air pressure in the storage tank when you notice a decrease in available water from the RO system. Air can be added with a bicycle pump using the schrader valve that is located on the lower side of the tank behind a blue plastic cap. -
Page 13: Faucet Adjustment
Adjust Faucet If the faucet has developed a drip it can be corrected by following the steps outlined below. Step 1 Remove faucet Spout fi rst. Position both thumbs on the back edge of the lever and push forward. Step 2 Lever will slide forward and completely off of the faucet base. -
Page 14: Performance Data Sheet
Performance Data Sheet ZRO-4 Zero Waste RO Premier Inc. 8716 W Ludlow Drive Suite #1 Peoria, AZ 85381 480) 675-7995 wpmail@Premierind.com GENERAL USE CONDITIONS: 1. System to be used with municipal or well water sources treated and tested on regular basis to insure bacteriological safe quality. Do not use with water that is microbiologically unsafe or unknown quality without adequate disinfection before and after the system. -
Page 15: Arsenic Fact Sheet
The RO component of this Premier reverse osmosis system must be maintained in order to ensure proper contaminant removal from your water. As detailed out on Page 2 of this manual, prefi... -
Page 17: Parts List
Item # Part # Description Item # Part # Description 137013 BRACKET-4SV-STEEL WHITE 116023 FAUCET-AG-CHROME 146001 SCREW- #10-3/4” PHIL PAN HEAD 134018 VALVE-BALL-PLAS-ELB 146004 SCREW- #10-1” PHIL PAN HEAD 119007 TANK PRESS 3 GAL WHITE 164006 CLIP-MTG-MEM-VESSEL 119028 TANK STAND 337002 BRACKET 16 GAUGE CRS 125017 CON-PL-1/4C X 1/4M 113007 LID-WHITE 1/4”... -
Page 18: Other Products By Premier
Other Products from Premier Premier has other fi ne water fi ltration products and accessories to enhance your water and to compliment your existing RO System. Listed on the next several pages are only a few of the items we offer. - Page 19 Replacement Filter Kit Compatible with Premier Zero Waste Reverse Osmosis system. These fi lters provide an extra level of fi ltration by allowing for more contact between the carbon media and your water. Includes a 10” Final in-line Filter, Sediment Filter and a Carbon Block Filter.
- Page 20 Removing chlorine from your shower Special Chlorgon & KDF media – More effective then carbon medias with hot water applications in the removal of the following. Free Chlorine (CL-) Iron oxide (rust water) Combined Chlorine (Sodium Hypochlorite) ...
-
Page 21: Warranty Registration
We want to offer you four ways to communicate with us. 1.Online, 2.Fax, 3.Telephone, and 4. Mail the form below. By registering your product you will receive the full benefi t of our warranty. Premier will also send you a semiannual fi lter change reminder beginning six months from date of installation. - Page 22 Iowa Department of Public Health - Sales in Iowa require this to be completed, signed and returned. These signatures will be retained on fi le for two years. Insert into envelope and return to Premier Premier 8716 W Ludlow Drive Suite #1...
-
Page 23: Service Record
SERVICE RECORD DATE OF PURCHASE DATE OF INSTALL INSTALLED BY SERIAL NO. NAME: Date of (6 mos.) (6 mos.) (1 yr.) (2-5 yrs.) OTHER Maintenance 1st stage 2nd stage Final Filter TFM Memb. Sediment Carbon Block Carbon NOTES:... -
Page 24: Warranty
Then, ship your Zero Waste unit (less tank) to our factory, freight and insurance prepaid, with proof of date of original purchase. Please include a note stating the problem. Premier will repair it, or replace it, and ship it back to you prepaid.
Need help?
Do you have a question about the ZRO-4 and is the answer not in the manual?
Questions and answers