9-379 Trickle Bottle Full Rap; 9-400 Black Toner Near Empty Rap - Xerox DocuColor 12/DCCS50 Service Manual

9-379 Trickle Bottle Full RAP

Trickle Bottle Full. This status code is declared when the number of copies reach a specific
count after the Trickle Toner Full Sensor has detected a full trickle bottle.
Initial Actions
• Refer to BSD 9.3 and BSD 9.15 for the following procedure.
• Check the Trickle Toner Full Sensor for dirt or foreign matter
Check that the P/J122 on the Trickle Toner Full Sensor, and
are firmly connected.
Procedure
The Trickle Toner Bottle is full.
Y N
Enter dC330 009-251 Trickle Bottle Sensor. Press Start. The Display is (H)
Y N
Check the Trickle Toner Full Sensor for intermittent operation. If the sensor appears
to be good, replace the IOT Drive PWB
the Trickle Toner Full Sensor (PL
+5 VDC is measured between P/J417A-4 and GND on the IOT Drive PWB.
Y N
Replace the IOT Drive PWB (PL
+24 VDC is Measured between P/J417A-1 and P/J417A-3 on the IOT Drive PWB.
Y N
Go to the +24 VDC (IOT) Wirenet and check the wires between P/J23-1 on the IOT
LVPS and P/J417A-1 on the IOT Drive PWB for an open circuit. Go to the DC COM
(24 VRET) Wirenet and check the wires between P/J23-4 on the IOT LVPS and
J417A-3 on the IOT Drive PWB for an open circuit.
Go to Flag 2 on BSD 9.3. Check the wire for an open circuit. Check the wires between
J122-1 of the Trickle Toner Full Sensor and P/J417A-1 of the IOT Drive PWB and
between P/J122-3 of the Trickle Toner Full Sensor and P/J417A-3 of the IOT Drive PWB
for an open circuit. If the wires are good, replace the Trickle Toner Full Sensor
Replace the Trickle Toner Bottle (Section 6,
Status Indicator RAPs
9-379 Trickle Bottle Full RAP, 9-400 Black Toner Near
P/J417A on the IOT Drive PWB
(PL 9.2). If the problem continues, replace
6.5).
9.2).
Machine Consumables).

9-400 Black Toner Near Empty RAP

Control Logic has detected that the Black dispenser is almost empty.
Initial Actions
This is a message fault only. An operator action is required
Procedure
This fault should not require any service action. If this fault causes a problem, use the
Cyan Toner Dispenser Broken RAP
P/
P/
(PL 6.5).
1/05
2-126
manuals4you.com manuals4you.com
to troubleshoot the problem.
DocuColor 12/DCCS50
9-356
Reissue