Repair Instructions; Brake Pad Inspection; Brake Pads Replacement (Front) - GMC chervolet camaro 1999 Service Manual

Table of Contents

Advertisement

Brakes
Repair Instructions
Brake Pad Inspection
• Inspect the disc brake pads every 10,000 km
(6,000 miles) and anytime the wheels are
removed.
• Inspect both ends of the outer pad by looking in at
each end of the caliper. The highest rate of wear
normally occurs at the ends.
• Inspect the thickness of the inner pad in order to
ensure that it has not worn prematurely. Look
through the window in the top of the caliper
in order to view the inner pad.
• Both front and rear disc brakes have wear
indicators that make a noise when the pads wear
below specifications. The wear indicator is an
integral part of the outer pad. When the pad
is worn the wear indicator contacts the rotor and
produces a warning noise as indicated in the
illustration above.
• Replace the pads when the thickness is worn
below specification. Replace all pads in axle sets.
Refer to Component Specifications.
• Measure the flatness of the inner and outer pads.
Place the pad surfaces together and measure
the gap between the surfaces. If a gap larger than
the specification exists midway between the
attaching lugs, replace the pads. Refer to
Component Specifications.
Brake Pads Replacement (Front)
Removal Procedure
1. Remove two-thirds of the brake fluid from the
master cylinder reservoir.
2. Raise and suitably support the vehicle. Refer to
Lifting and Jacking the Vehicle in General
Information.
3. Remove the tire and wheel assembly. Refer to
Tire and Wheel Removal and Installation (Wheel
Removal) in Tires and Wheels.
'
a
0
B
tJ
0
n
1
Disc Brakes 5-59
125
451525

Hide quick links:

Advertisement

Table of Contents
loading

This manual is also suitable for:

Pontiac firebird 1999

Table of Contents