Related Manuals for Moffat TURBOFAN E20M
Summary of Contents for Moffat TURBOFAN E20M
- Page 1 20MSERIES E 2 0 M S e r i e s ( M a n u a l O p e r a t i o n ) I n s t a l l a t i o n a n d O p e r a t i o n M a n u a l 234090-1...
- Page 2 The reproduction or copying of any part of this manual by any means whatsoever is strictly forbidden unless authorized previously in writing by the manufacturer. In line with policy to continually develop and improve its products, Moffat Ltd. reserves the right to change the specifications and design without prior notice.
-
Page 3: Table Of Contents
E20M Series Turbofan Convection Ovens. Model Numbers Covered in this Manual E22M3 - Turbofan Oven - 3 Tray Convection Oven. E23M3 - Turbofan Oven - 3 Tray Convection Oven. E27M2 - Turbofan Oven - 2 Tray Convection Oven. E27M3 - Turbofan Oven - 3 Tray Convection Oven. -
Page 4: Introduction
Before using your new oven, please read this instruction manual carefully, pay particular attention to any information labelled ‘WARNING’, ‘CAUTION’, ‘IMPORTANT’ or ‘NOTE’ in this manual. Indicates a hazardous situation Warning which, if not avoided, will result in death or serious injury. Indicates a hazardous situation which, if not avoided, will result in Caution... -
Page 5: Specifications
E22M3 E23M3 E27M2 / E27M3 E28M4 Oven Power Ratings 110-120V, 1P+N+E, 60HZ, 1.5 kW E22M3 220-240V, 1P+N+E, 50/60HZ, 2.0 kW 208V, 1P+N+E, 50-60 HZ, 2.7 kW E23M3 220V, 1P+N+E, 50-60 HZ, 3.0 kW 230-240V, 1P+N+E, 50-60 HZ, 3.0 kW 208V, 1P+N+E, 50-60HZ, 2.7kW E27M2 220V,... -
Page 6: Installation
For ovens that are to be mounted to a stand, the oven feet are used to level the oven on the stand. Refer to the instructions supplied with separately ordered stands for mounting details. Oven Serial Number Oven Current Draw Model Number MOFFAT LIMITED E22M3 MODEL USE22M3 CODE xxxxxx SERIAL yywwxxx ******* V a.c. -
Page 7: Electrical Connection
Electrical Connection Warning This oven must be earthed / grounded. If the supply cord is damaged, it must be replaced by a suitably qualified person in order to avoid a hazard. Each oven should be connected to an adequately protected power supply and an isolation switch mounted adjacent to, but not behind the oven and must be readily accessible to the operator. -
Page 8: Operation
Operation Guide • Turbofan Ovens have been designed to provide simple operation. • This oven is intended for use in a commercial kitchen and must only be put to the use for which it was intended, i.e. cooking food product. To use this oven correctly please read the following sections carefully:- Oven Control Panel Description of Controls... -
Page 9: Cleaning
Cleaning Guidelines Caution Always turn electrical mains supply before commencing cleaning. This oven is not water proof. water jet spray to clean interior or exterior of the appliance. To achieve the best results, cleaning must be regular and thorough. If any small faults occur, have them looked at promptly. - Page 10 Lamp Glass (Not E22M3) a. With side racks and fan baffle removed, unscrew lamp glass, anti-clockwise. Unscrew Anti- Clockwise b. Clean the lamp glass using a soft cloth with a mild anti bacterial detergent and a hot water solution. c. Dry the lamp glass thoroughly with a dry cloth. d.
- Page 11 d. Whilst still holding the oven door in the open position, clean the inner glass and the inside of the outer glass with a conventional glass cleaner. e. Dry the oven glass thoroughly with a soft dry cloth. f. On completion of door glass cleaning, lower the inner glass back into the door, the glass will locate itself in the correct position.
-
Page 12: Fault Finding
This section provides a reference to the more common problems that may occur during the operation of your oven. This fault finding guide is intended to help you correct and accurately diagnose problems with your oven. When fault finding a problem, always use a process of elimination starting with the simplest solution and working through to the most complex. -
Page 13: Electrical Schematics
Electrical Schematics Electrical Schematic E22M3 Turbofan Oven Electrical Schematic E23M3 Turbofan Oven 110-120V, 60Hz. 220-240V 50/60Hz. 208V, 50-60Hz. 220V, 50-60Hz. 230-240V, 50-60Hz. - Page 14 Electrical Schematics Electrical Schematic E27M2 Turbofan Oven Electrical Schematic E27M3 Turbofan Oven Electrical Schematic E28M4 Turbofan Oven 208V, 50-60Hz. 220V, 50-60Hz. 230-240V, 50-60Hz. 208V, 50-60Hz. 220V, 50-60Hz. 230-240V, 50-60Hz. 208V, 50-60Hz. 220V, 50-60Hz. 230-240V, 50-60Hz.
-
Page 15: Replacement Parts List
Replacement Parts List Only genuine authorized replacement parts should be used for the servicing and repair of this oven. The instructions supplied with the parts should be followed when replacing components. For further information and servicing instructions, contact your nearest authorized service provider or Turbofan Dealer. When ordering replacement parts, please quote the part number and the description as listed below. - Page 16 Replacement Parts List Replacement Parts List (Continued). Item Description 233521 Side Rack LH, E22 233522 Side Rack RH, E22 232682 Side Rack LH, E23 232683 Side Rack RH, E23 233558 Side Rack LH, E27M3 233559 Side Rack RH, E27M3 234721 Side Rack LH, E27M2 234722 Side Rack RH, E27M2...
Need help?
Do you have a question about the TURBOFAN E20M and is the answer not in the manual?
Questions and answers