Headlamps Turn signal control Bulb replacement Driver Controls Windshield wiper/washer control Steering wheel adjustment Power windows Speed control Locks and Security Keys Locks REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Table of Contents...
The more you know and understand about your vehicle, the greater the safety and pleasure you will derive from driving it. For more information on Mazda and its products visit the following website: • In the United States: www.mazdausa.com •...
Page 6
Warranties. For a detailed description of what is covered and what is not covered, refer to the Warranty Guide that is provided to you along with your Owner’s Guide. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Introduction...
Page 7
Be sure to read Driving off road in the Driving chapter. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 8
Using your vehicle as an ambulance WARNING: Do not use this vehicle as an ambulance. Your vehicle is not equipped with an ambulance preparation package. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Introduction...
Page 9
Non-Petroleum Based Hazard Warning Flasher Fuse Compartment Windshield Wash/Wipe Rear Window Defrost/Demist REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) See Owner’s Guide Fasten Safety Belt Air Bag-Side Child Seat Installation Warning Child Seat Tether...
Page 10
INFORMATION ABOUT THIS GUIDE The information found in this guide was accurate at the time of printing. Mazda may change the contents without notice. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Introduction Personal Alarm System...
Turn signal and wiper/washer control (pg. 46) * If equipped Parking brake release (pg. 148) REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Instrument cluster (pg. 12) Speed control* (pg. 52) Driver air bag (pg.
Page 12
Auxiliary power point (pg. 48) Fog lamp control* (pg. 35) Cigar lighter Climate control system Passenger air bag deactivate switch (pg. 32) (pg. 83) * if equipped REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
WARNING: Under engine misfire conditions, excessive exhaust temperatures could damage the catalytic converter, the fuel system, interior floor coverings or other vehicle components, possibly causing a fire. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 14
Normal braking is still functional unless the brake warning light also is illuminated. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Instrument Cluster BRAKE...
Page 15
(refer to Fuel gauge in this chapter). Door ajar: Illuminates when the ignition is in the ON position and any door is open. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 16
(the key is not in the ignition) and the driver’s door is opened. Door ajar warning chime: Sounds when any door is opened (or not fully closed). REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Instrument Cluster...
WARNING: Never remove the coolant reservoir cap and/or the radiator cap while the engine is running or hot, this may result in serious burns. Odometer: Registers the total miles (kilometers) of the vehicle. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 18
Refer to Filling the tank in the Maintenance and Specifications chapter for more information. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Instrument Cluster...
Treble: Press AUDIO Balance: Press AUDIO right speakers. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) to decrease/increase the bass setting. to decrease/increase the treble setting. to adjust the audio between the left and...
“nominal” listening level when the ignition is turned back AM/FM STEREO SINGLE CD/MP3 SYSTEM REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Entertainment Systems ) the radio frequency...
Page 21
5. TUNE: Press to manually go down/up ( ) the radio frequency and also to select various settings in menu mode. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 22
15. CD: Press to enter CD mode. If a CD is already present in the system, the disc will begin to play. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Entertainment Systems...
Due to technical incompatibility, certain recordable and re-recordable compact discs may not function correctly when used in Mazda CD players. Irregular shaped CDs, CDs with a scratch protection film attached, and CDs with homemade paper (adhesive) labels should not be inserted into the CD player.
Page 24
Directory mode. Track number/music name/file name: In MP3 mode, press MENU to view by track number, music name or file name. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Entertainment Systems MENU MENU...
Page 25
CD track. 12. REW (Rewind): In tape mode, press to rewind the tape. In CD mode, press to manually reverse in a CD track. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 26
Due to technical incompatibility, certain recordable and re-recordable compact discs may not function correctly when used in Mazda CD players. Irregular shaped CDs, CDs with a scratch protection film attached, and CDs with homemade paper (adhesive) labels should not be inserted into...
Page 27
3. EJ (CD eject): To eject an individual CD, press CD and select the correct slot number by pressing the memory preset buttons. Press and hold EJ to eject all loaded CDs. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 28
Track #/normal music name/file name: Press MENU to access and to scroll through MP3 display options (track #, normal music name or file name). REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Entertainment Systems MENU to set.
Page 29
CD/MP3 tracks. In MP3 directory mode, press to hear a brief sampling of all tracks in the current directory. Press again to stop. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) ) the radio...
Page 30
Due to technical incompatibility, certain recordable and re-recordable compact discs may not function correctly when used in Mazda CD players. Irregular shaped CDs, CDs with a scratch protection film attached, and CDs with homemade paper (adhesive) labels should not be inserted into the CD player.
Page 31
Due to technical incompatibility, certain recordable and re-recordable compact discs may not function correctly when used in Mazda CD players. Irregular shaped CDs, CDs with a scratch protection film attached, and CDs with homemade paper (adhesive) labels should not be inserted into the CD player.
Page 32
AUDIO SYSTEM WARRANTY AND SERVICE Refer to the Warranty Guide for audio system warranty information. If service is necessary, see your authorized Mazda dealership. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Entertainment Systems...
4. Direct the outer instrument panel vents toward the side windows. To increase airflow to the outer instrument panel vents, close the vents located in the middle of the instrument panel. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) position.
• To reduce humidity build up inside the vehicle: do not drive with the air flow selector in the OFF position. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Climate Controls position.
Page 35
WARNING: Do not place objects on top of the instrument panel as these objects may become projectiles in a collision or sudden stop. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Failure to activate your headlamps under these conditions may result in a collision. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Lights...
Page 37
If your vehicle is involved in an accident or if you have problems fixing the alignment of your headlamps, have them checked by a qualified service technician. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 38
(4). If the top edge of the high intensity area is not even with the horizontal line, follow the next step to adjust it. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Lights...
TURN SIGNAL CONTROL • Push down to activate the left turn signal. • Push up to activate the right turn signal. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Hi-mount brake lamp Rear stop/tail lamps Rear turn lamps Rear license plate lamps Backup lamps Dome lamp REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Lights Trade number 3457 AK (amber) 9007 9006 4157K or 3157K...
Page 41
For bulb replacement, see an authorized Mazda dealer. Replacing headlamp bulbs NOTE: The procedure can be difficult. Your Mazda dealer has the proper tools, training and parts to perform this task. If you have difficulty with this, visit your local Mazda dealer.
Page 42
“stop.” 3. Install the electrical connector into the plastic base until it snaps, locking it into position. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Lights...
Page 43
6. Install the bulb socket in lamp assembly by turning clockwise. 7. Align the lamp on the vehicle and push to snap in place. 8. Install the screw on lamp assembly. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 44
5. Install the bulb socket in lamp assembly by turning clockwise. 6. Install the lamp assembly and secure with four screws. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Lights...
Page 45
To install the brake lamp assembly: 1. Install the bulb socket into the lamp assembly by rotating clockwise. 2. Install the lamp assembly on the vehicle and secure with two screws. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 46
3. Pull out the old bulb from socket and push in the new bulb. 4. Install the bulb socket in lamp assembly by turning it clockwise. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Lights...
Check the wiper blades for wear at least twice a year or when they seem less effective. Substances such as tree sap and some hot wax treatments used by commercial car washes reduce the effectiveness of wiper blades. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 48
This can lead to loss of control or an accident. Never adjust the steering wheel while the vehicle is moving. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Driver Controls...
Press and hold the bottom part of the rocker switch to open the window. Press and hold the top part of the rocker switch to close the window. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 50
A correct zone setting will eliminate this error. Refer to Compass zone adjustment. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Driver Controls...
Page 51
Compass zone adjustment 1. Determine which compass zone you are in by referring to the zone map. 2. Turn ignition to the ON position. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) 7 8 9 1011...
Page 52
5 km/h [3 mph] in a circle until CAL indicator disappears in the display (about two or three circles). 6. The compass is now calibrated. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Driver Controls...
WARNING: Do not shift the gearshift lever into N (Neutral) with the speed control on. You may lose control of the vehicle or cause engine system damage. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 54
Disengaging the speed control will not erase previous set speed. Note: When you use the clutch pedal to disengage the speed control, the engine speed may briefly increase, this is normal. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Driver Controls...
Page 55
Each tap will decrease the set speed by 1 mph (1.6 km/h). • Depress the brake pedal or the clutch pedal (if equipped) until the desired vehicle speed is reached, press the SET + control. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 56
For additional information about the gearshift lever and the transmission control switch operation refer to the Automatic Transmission Operation section of the Driving chapter. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Driver Controls ON/OFF...
Page 57
1. Lower tailgate. 2. Pull the round knobs on each side of the extender to release it from the pickup box. 3. Pivot extender on to the tailgate. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 58
Note: Remove and store the bed extender when not in use. To install the bed extender, follow the removal procedure in reverse order. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Driver Controls...
• structures around the vehicle, or • other vehicles parked next to your vehicle. Your vehicle is equipped with a remote entry system which allows you to: REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) UNLOCK LOCK...
Page 60
Note: The panic alarm will only operate when the ignition is in the OFF or ACC position. Replacing the battery The remote entry transmitter uses one coin type three-volt lithium battery CR2032 or equivalent. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Locks and Security...
Page 61
How to reprogram your remote entry transmitters You must have all remote entry transmitters (maximum of four) available before beginning this procedure. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 62
• any door is open. The battery saver will shut off the interior lamps after several minutes if they are left on accidentally. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Locks and Security...
Lift the release bar to move seat forward or backward. Ensure that the seat is locked into place. Pull lever located at the side of the seat cushion up to adjust seatback. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 64
Pull up on the recliner handle. The seat will lean forward. Lift the release bar to move the seat forward to access the rear area of the cab. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
WARNING: Never let a passenger hold a child on his or her lap while the vehicle is moving. The passenger cannot protect the child from injury in a collision. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 66
WARNING: On four-door Cab Plus 4 vehicles, do not open the rear door when the rear seat belt is still buckled. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 67
5 mph (8 km/h) or more, the combination safety belts will lock to help reduce forward movement of the driver and passengers. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 68
How to disengage the automatic locking mode Disconnect the combination lap/shoulder belt and allow it to retract completely to disengage the automatic locking mode and activate the vehicle sensitive (emergency) locking mode. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 69
Safety belt maintenance section in this chapter. WARNING: Failure to replace the safety belt assembly after a crash has occurred could result in severe personal injuries in the event of a collision. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 70
Adjusting the center and rear center facing jump seat lap belts The lap belt does not adjust automatically. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 71
Also, use the safety belt extension only if the safety belt is too short for you when fully extended. NOTE: Do not use extensions to change the fit of the shoulder belt across the torso. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 72
REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Then... The safety belt warning light illuminates 1-2 minutes and the warning chime sounds 4-8 seconds.
Page 73
Reasons given... Crashes are rare events I’m not going far Belts are uncomfortable REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Then... The BeltMinder feature is activated - the safety belt warning light illuminates and the warning chime...
Page 74
The safety belt and safety belt warning system are there to protect your life. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Consider... Prime time for an accident. Safety Belt Warning Chime reminds us to take a few seconds to buckle up.
Page 75
3. Buckle then unbuckle the safety belt three times, ending with the safety belt unbuckled. This can be done before or during BeltMinder warning activation. 4. Turn on the parklamps/headlamps, turn off the parklamps/headlamps. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 76
Mazda recommends that all safety belt assemblies used in vehicles involved in a collision be replaced. However, if the collision was minor and an authorized Mazda technician finds that the belts do not show damage and continue to operate properly, they do not need to be replaced.
Always wear your safety belt. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 78
WARNING: Never place your arm or feet over the air bag module as a deploying air bag can result in serious arm fractures or other injuries. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 79
Mazda dealership before installation of additional equipment. WARNING: The front passenger air bag is not designed to offer protection to an occupant in the center front seating position. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 80
See Passenger air bag on/off switch in this chapter. WARNING: Do not install a child seat in a center facing jump seat. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 81
Rather, it means the forces were not of the type sufficient to cause activation. Air bags are designed to inflate in frontal and near-frontal collisions, not rollover, side-impact, or rear-impacts. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 82
• driver and passenger air bag modules (which include the inflators and air bags), • passenger air bag deactivation switch and restraint control module (RCM) • a readiness light and tone, REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 83
Disposal of air bags and air bag equipped vehicles (including safety belt pretensioners) For disposal of safety belt pretensioners, air bags, or air bag equipped vehicles, see your authorized Mazda dealership or qualified technician. Air bags MUST BE disposed of by qualified personnel. REVIEW COPY...
Page 84
Do not use a second key to turn off the passenger airbag, as the lock position might be changed without your knowing. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) PASSENGER AIRBAG PASSENGER AIRBAG...
Page 85
ON. 2. The OFF light will briefly illuminate when the ignition is turned to ON. This indicates that the passenger air bag is operational. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) PASSENGER AIRBAG...
Page 86
REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 87
OFF the air bag and allowing the passenger, even if belted, to hit the dashboard or windshield in a crash. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 88
• makes the potential harm from the passenger air bag deployment greater than the potential harm from turning OFF the air bag and experiencing a crash without the protection offered by the air bag REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
If you must use a forward facing child seat in the front seat, position the vehicle seat fully rearward and turn the passenger air bag off. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 90
Moving the child closer to the center of the vehicle may help provide a good shoulder belt fit. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 91
To improve the fit of both the lap and shoulder belt on children who have outgrown child safety seats, Mazda recommends use of a belt-positioning booster. Booster seats position a child so that safety belts fit better. They lift the child up so that the lap belt rests low across the hips and the knees bend comfortably.
Page 92
(top of ear level) above the top of the seat. In this case, use a high-backed booster seat. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 93
WARNING: Never use pillows, books, or towels to boost a child. They can slide around and increase the likelihood of injury or death in a collision. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 94
36 kg (80 pounds) using an upper torso harness and a belt-positioning booster. Mazda recommends the use of a child safety seat having a top tether strap. Install the child safety seat in a seating position with LATCH and...
Page 95
OFF. If you place a forward-facing child seat in the right front seat, turn the air bag on/off switch to OFF. See Passenger air bag on/off switch in this chapter. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 96
Make sure the tongue is latched securely by pulling on it. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 97
If the retractor is not locked, unbuckle the belt and repeat steps two through nine. 11. See Attaching child safety seats with tether straps in this chapter. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 98
WARNING: Attach the tether strap only to the appropriate tether anchor as shown. The tether strap may not work properly if attached somewhere other than the correct tether anchor. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 99
2. Route the child safety seat tether strap over the back of the seat. 3. Locate the correct anchor for the selected seating position. The tether anchor is located on the rear lower portion of the passenger seat. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 100
When installing a child safety seat in the center position, route the tether strap over the center arm rest and clip it to the center anchor. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 101
See Attaching safety seats with tether straps in this chapter. Your vehicle may be equipped with LATCH anchors for child seat installation at the following seating positions: • Bucket seats REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 102
(if equipped). WARNING: Do not attach two seats to one LATCH anchor bar. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 103
Each time you use the safety seat, check that the seat is properly attached to the lower anchors and tether anchor. Try to tilt the child REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 104
WARNING: If the tether strap is clipped incorrectly, the child safety seat may not be retained properly in the event of a collision. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
This increases traction which may enable you to safely drive over terrain and road conditions that a conventional two-wheel drive vehicle cannot. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 106
REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Tires, Wheels and Loading...
Page 107
10 to 12 inches or limited production tires as defined in Title 49 Code of Federal Regulations Part 575.104(c)(2). U.S. Department of Transportation-Tire quality grades: The U.S. Department of Transportation requires Mazda to give you the following information about tire grades exactly as the government has written it. Treadwear...
Page 108
• Tire label: A label showing the OE (Original Equipment) tire sizes, recommended inflation pressure and the maximum weight the vehicle can carry. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Tires, Wheels and Loading...
Page 109
• Rim: The metal support (wheel) for a tire or a tire and tube assembly upon which the tire beads are seated. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
(if equipped), at least monthly and before long trips. You are strongly urged to buy a reliable tire pressure gauge, as automatic service station gauges may be inaccurate. Mazda recommends the use of a digital or dial type tire pressure gauge rather than a stick type tire pressure gauge.
Page 111
Always inflate your tires to the Mazda recommended inflation pressure even if it is less than the maximum inflation pressure information found on the tire. The Mazda recommended tire inflation pressure is found on the tire label or certification label which is B-Pillar or the edge of the driver’s door.
Page 112
(such as P-metric versus LT-metric or all-season versus all-terrain) as those originally provided by Mazda. Use of any tire or wheel not recommended by Mazda can affect the safety and performance of your vehicle, which could result in an increased risk of loss of vehicle control, vehicle rollover, personal injury and death.
Safety Compliance Label • Tow a trailer • Use snow chains • Use more than one temporary emergency spare tire • Use commercial car washing equipment REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 114
P (Park) (automatic transmission) or 1 (First) (manual transmission). 2. Set the parking brake and turn engine OFF. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Tires, Wheels and Loading...
Page 115
Do not start the engine when your vehicle is on the jack. The jack is only meant for changing the tire. • Front REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 116
12. Stow the jack and lug wrench. Make sure the jack is fastened so it does not rattle when you drive. 13. Unblock the wheels. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Tires, Wheels and Loading...
20 * Torque specifications are for nut and bolt threads free of dirt and rust. Use only Mazda recommended replacement fasteners. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Wheel lug nut torque* lb.ft.
Page 118
2. 215: Indicates the nominal width of the tire in millimeters from sidewall edge to sidewall edge. In general, the larger the number, the wider the tire. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Tires, Wheels and Loading...
Page 119
Note: You may not find this information on all tires because it is not required by federal law. Letter rating REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Speed rating - mph (km/h) 81 mph (130 km/h)
Page 120
A tire marked C may have poor traction performance. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Tires, Wheels and Loading Speed rating - mph (km/h) ⁄...
Page 121
4. Maximum Load Single lb. (kg) at psi (kPa) cold: Indicates the maximum load and tire pressure when the tire is used as a single; defined as two tires (total) on the rear axle. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 122
Measure and inspect the tire tread on all your tires periodically. Advanced and unusual tire wear can reduce the ability of tread to grip REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Tires, Wheels and Loading...
Page 123
Driving habits have a great deal to do with your tire mileage and safety. • Observe posted speed limits • Avoid fast starts, stops and turns REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 124
Wheel misalignment in the front or the rear can cause uneven and rapid treadwear of your tires and should be corrected by a qualified technician at a Mazda dealer. Front wheel drive (FWD) vehicles and those with an independent rear suspension require alignment of all four wheels.
Page 125
Specifications chapter) will help your tires wear more evenly, providing better tire performance and longer tire life. • Front Wheel Drive (FWD) vehicles (front tires at top of diagram) REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 126
Sometimes irregular tire wear can be corrected by rotating the tires. Note: If your tires show uneven wear ask a qualified technician at a Mazda dealership to check for and correct any wheel misalignment, tire imbalance or mechanical problem involved before tire rotation.
It does not include passengers, cargo, or optional equipment. Vehicle Curb Weight – is the weight of your new vehicle when you picked it up from your dealer plus any aftermarket equipment. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 128
Note: For trailer towing information refer to Trailer towing found in this chapter or the RV and Trailer Towing Guide provided by your dealership. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Tires, Wheels and Loading...
Page 129
REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 130
GVWR and GAWR limitations. Replacement tires with a higher limit than the originals do not increase the GVWR and GAWR limitations. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Tires, Wheels and Loading...
Page 131
2 years. Measuring the inside of the vehicle with the rear seat folded down, you have room for 12-100 REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Towing a trailer places an additional load on your vehicle’s engine, transmission, axle, brakes, tires and suspension. Inspect these components carefully after any towing operation. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Tires, Wheels and Loading...
Page 133
Maximum trailer weight is shown. The combined weight of the completed towing vehicle (including hitch, passengers and cargo) and the loaded trailer must not exceed the Gross Combined Weight Rating (GCWR). REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Maximum Maximum...
Page 134
Maximum trailer weight is shown. The combined weight of the completed towing vehicle (including hitch, passengers and cargo) and the loaded trailer must not exceed the Gross Combined Weight Rating (GCWR). REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Maximum Maximum trailer frontal area weight - lb.
Page 135
Maximum trailer weight is shown. The combined weight of the completed towing vehicle (including hitch, passengers and cargo) and the loaded trailer must not exceed the Gross Combined Weight Rating (GCWR). REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Maximum Maximum trailer frontal weight - lb.
Page 136
REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Tires, Wheels and Loading Maximum Maximum...
Page 137
The braking system of the tow vehicle is rated for operation at the GVWR not GCWR. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 138
Refer to the following chart for information regarding the factory-equipped trailer tow connector: REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Tires, Wheels and Loading...
Page 139
If you tow a trailer for long distances, your vehicle will require more frequent service intervals. Refer to your Service Maintenance Section for more information. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Comment Circuit activated when brake...
These guidelines are designed to ensure that your transmission is not damaged. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Tires, Wheels and Loading...
Page 141
If a distance of 50 miles (80 km) or a speed of 35 mph (56 km/h) must be exceeded, you must disconnect the front (4x4 only) and rear driveshafts. Mazda recommends the driveshafts be removed/installed only by a qualified technician. See your local dealer for driveshaft removal/installation.
Only use the accelerator when you have difficulty starting the engine. For more information on starting the vehicle, refer to Starting the engine in this chapter. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Driving...
Page 143
Seating and Safety Restraints chapter. 2. Make sure the headlamps and electrical accessories are off. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 144
This condition may occur when: • front wheels are turned • front wheel is against the curb REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Driving...
Page 145
In cold weather, ethanol fuel distributors should supply winter grade 85) ethanol. If summer grade (E REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) light may not illuminate. 85) ethanol is used in cold weather,...
Page 146
Cold starting performance can also be improved by using an engine block heater. Engine block heaters are available as an option and can be obtained from your Mazda dealer. Consult the engine block heater section for proper use of the engine block heater.
ABS warning light will come on. If the vehicle has continuous vibration or shudder in the steering wheel while braking, the vehicle should be inspected by an authorized Mazda dealership. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002),...
Page 148
Even when the ABS is disabled, normal braking is still effective. (If your BRAKE warning lamp illuminates with the parking brake released, have your brake system serviced immediately.) REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Driving BRAKE...
Page 149
Pull the release lever to release the brake. Driving with the parking brake on will cause the brakes to wear out quickly and reduce fuel economy. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) BRAKE...
Page 150
Your vehicle has larger tires and increased ground clearance, giving the vehicle a higher center of gravity than a passenger car. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Driving...
P (Park) position without the brake pedal depressed. To avoid unwanted vehicle movement, always set the parking brake. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 152
P (Park) to another position. If you do not hold the brake pedal down, your vehicle may move unexpectedly and injure someone. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Driving...
Page 153
Drive is activated when the transmission control switch is pressed. • This position allows for all forward gears except overdrive. • O/D OFF lamp is illuminated. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) ON/OFF...
Page 154
2. Press the clutch pedal to the floor, then put the gearshift lever in the neutral position. 3. Start the engine, then press the brake pedal and release the parking brake. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Driving...
Page 155
This is a lockout feature that protects the transmission from accidentally being shifted into R (Reverse) from 5 (Overdrive). REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Transfer case position (if equipped) 2WD and 4H...
Page 156
If equipped with the Electronic Shift 4WD System, and 4WD Low is selected while the vehicle is moving, the 4WD system will not REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Driving...
Page 157
Note: Do not perform this operation if the rear wheels are slipping. Shifting to/from 4X4 LOW 1. Bring the vehicle to a complete stop 2. Depress the brake REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) HIGH...
Page 158
WARNING: Do not spin the wheels at over 35 mph (56 km/h). The tires may fail and injure a passenger or bystander. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Driving...
Page 159
When speed control is on and you are driving uphill, your vehicle speed may drop considerably, especially if you are carrying a heavy load. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 160
(4x4 vehicles only) are submerged may allow water into the transmission or transfer case and cause internal transmission/transfer case damage. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Driving (Overdrive) into...
This device stops the electric fuel pump from sending fuel to the engine when your vehicle has had a substantial jolt. After an accident, if the engine cranks but does not start, this switch may have been activated. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Note: Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Roadside Emergencies...
Page 163
REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Cartridge Maxi Fuse link...
Page 164
Radio (RUN/ACCY) Headlamp illumination indicator Restraints Control Module (RCM), PADI (Passenger Air bag Deactivation Indicator) Cluster air bag indicator Cluster (RUN/START), 4x4 module (RUN/START) REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Roadside Emergencies Description...
Page 165
Climate control blower relay/blend doors, 4x4 module 4x4 module B+ Cigar lighter, Diagnostic connector (OBD Power mirrors Front park lamps, Rear park lamps, License plate lamps REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Description...
Page 166
If the battery has been disconnected and reconnected, refer to the Battery section of the Maintenance and specifications chapter. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Roadside Emergencies Description...
Page 167
40A** — 50A** — 40A** — 40A** — 30A** REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Power Distribution Box Description Passenger compartment fuse panel Not used Passenger compartment fuse panel Not used Passenger compartment fuse...
Page 168
— — — — 7.5A* — — 15A* REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Roadside Emergencies Power Distribution Box Description Not used Blower motor (climate control) Not used Not used Not used...
Page 169
— — — — — * Mini Fuses ** Maxi Fuses REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Power Distribution Box Description Trailer tow (left turn) Not used Not used Wiper HI/LO relay...
Page 170
— Not used 30A** Powertrain Control Module (PCM) relay fuse — Not used 30A** Blower motor (climate control) — Not used — Not used REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Roadside Emergencies...
Page 171
Not used — Not used 15A* HEGOs 7.5A* Trailer tow (left turn) — Not used — Not used — Wiper HI/LO relay — Wiper Park/Run relay REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
• If neither coolant nor steam is escaping: open the hood and idle the engine until it cools. If this does not lower the temperature, stop the engine and let it cool. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Roadside Emergencies...
1. Use only a 12–volt supply to start your vehicle. 2. Do not disconnect the battery of the disabled vehicle as this could damage the vehicle’s electrical system. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 174
Note: In the illustrations, lightning bolts are used to designate the assisting (boosting) battery. 2. Connect the other end of the positive (+) cable to the positive (+) terminal of the assisting battery. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Roadside Emergencies...
Page 175
Jump starting 1. Start the engine of the booster vehicle and run the engine at moderately increased speed. 2. Start the engine of the disabled vehicle. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 176
Note: In the illustrations, lightning bolts are used to designate the assisting (boosting) battery. 2. Remove the jumper cable on the negative (-) connection of the booster vehicle’s battery. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Roadside Emergencies...
Page 177
After the disabled vehicle has been started and the jumper cables removed, allow it to idle for several minutes so the engine computer can relearn its idle conditions. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
It is recommended that your vehicle be towed with a wheel lift or flatbed equipment. Do not tow with a slingbelt. Mazda has not approved a slingbelt towing procedure. On 4x2 vehicles, it is acceptable to tow the vehicle with the front wheels on the ground and the rear wheels off the ground.
Mazda vehicle in top condition. If you have any questions or recommendations for improvement regarding the service of your Mazda vehicle or servicing by Mazda Dealer personnel, we recommend that you take the following steps: STEP 1: Contact Your Mazda Dealer Discuss the matter with an Authorized Mazda Dealer.
Page 180
6. Your question(s) If you live outside the U.S.A., please contact your nearest Mazda Distributor. CUSTOMER ASSISTANCE (CANADA) Your complete and permanent satisfaction is our business. We are here to serve you. All Authorized Mazda Dealers have the knowledge and the tools to keep your Mazda vehicle in top condition.
Page 181
Your complete satisfaction is the goal of Mazda Canada Inc. and our dealers. Mazda’s participation in CAMVAP makes a valuable contribution to our achieving that goal.
Page 182
Authorized Mazda Dealers have the knowledge and the tools to keep your Mazda vehicle in top condition. If you have any questions or recommendations for improvement regarding the service of your Mazda vehicle or servicing by Mazda Dealer personnel, we recommend that you take the following steps: STEP 1 Discuss the matter with an Authorized Mazda Dealer.
Page 183
00936–2722 Tel: (787) 788–9300 This way, we can be sure to respond to you as efficiently as possible. That is our goal. If you live outside the U.S.A., please contact your nearest Mazda Distributor. MAZDA IMPORTERS/DISTRIBUTORS U.S.A (Importer/Distributor) Mazda North American Operations 7755 Irvine Center Drive Irvine, CA 92618–2922...
Page 184
TEL: (684) 699–1854 ADD-ON NON-GENUINE PARTS AND ACCESSORIES Non-genuine parts and accessories for Mazda vehicles can be found in stores. These may fit your vehicle, but they are not approved by the manufacturer for use with Mazda vehicles. When you install non-genuine parts or accessories, they could affect your vehicle’s performance or...
Page 185
Mazda assumes no responsibility for death, injury, or expenses that may result from the installation of add-on non-genuine parts or accessories. WARRANTIES FOR YOUR MAZDA •...
Page 186
NOT take your Mazda outside the United States. However, in the event that you are moving to Canada permanently, Mazda vehicles built for use in the United States could be eligible for exportation to Canada with specific vehicle modifications to comply with the Canadian Motor Vehicle Safety requirements.
Page 187
P.O. Box 19734 Irvine, CA 92623–9734 Customer Assistance Center or toll free at 1 (800) 222–5500 If you live outside of the U.S.A., please contact the nearest Mazda Distributor. See the Mazda Importers/Distributors section of this manual. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002),...
Page 188
Factory-authorized Mazda service publications are available for owners who wish to do some of their own maintenance and repair. When requesting any of our publications through an Authorized Mazda Dealer, refer to the chart below. If they don’t have what you need in stock, they can order it for you.
However, NHTSA cannot become involved in individual problems between you, your dealer or Mazda Corporation. To contact NHTSA, you may either call the Auto Safety Hotline toll-free at 1–800–424–9393 (202–366–0123 in the Washington D.C.
Cleaning WASHING THE EXTERIOR Wash your vehicle regularly with cool or lukewarm water and a neutral Ph shampoo, such as an approved shampoo available from your Mazda dealer. • Never use strong household detergents or soap, such as dish washing or laundry liquid.
Page 191
• Spray Engine Shampoo and Degreaser, available at your authorized Mazda dealer, on all parts that require cleaning and pressure rinse clean. • Cover the highlighted areas to prevent water damage when cleaning the engine.
Page 193
• Wiper blades can be cleaned with isopropyl (rubbing) alcohol or windshield washer solution. Be sure to replace wiper blades when they appear worn or do not function properly. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 194
Mazda dealer. • If grease or tar is present on the material, spot-clean the area first with Spot and Stain Remover, available at your authorized Mazda dealer. • Never saturate the seat covers with cleaning solution.
Page 195
Cleaning MAZDA CAR CARE PRODUCTS Your Mazda dealer has many quality products available to clean your vehicle and protect its finishes. These quality products have been specifically engineered to fulfill your automotive needs; they are custom designed to complement the style and appearance of your vehicle. Each product is made from high quality materials that meet or exceed rigid specifications.
Mazda workmanship, will not be honored. Any auto repair shop using parts equivalent to your Mazda’s original equipment may perform maintenance. But we recommend that it always be done by an Authorized Mazda Dealer using genuine Mazda parts.
Page 197
Inspect tires for wear and rotate (X = recommended interval for optimal tire life) REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) whichever comes first) Replace at first 45,000 miles (72,000 km) or 36 months, after that, every 30,000 miles...
Page 198
Canada and California vehicles. *4 Refer to vehicle emission control information label for spark plug and gap specifications. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) whichever comes first) Replace every 150,000 miles (240,000 km)
Page 199
Clutch reservoir fluid level Front wheel bearings (4x2) REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) whichever comes first) 95 100 105 110 115 120 Replace at first 45,000 miles (72,000 km)
Page 200
Canada and California vehicles. *4 Refer to vehicle emission control information label for spark plug and gap specifications. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) whichever comes first) 95 100 105 110 115 120...
Page 201
(door-to-door delivery, taxi, police, power/utility company trucks, or similar duty), then Mazda recommends you increase the frequency of oil and filter changes to an interval equivalent to 200 ENGINE HOURS or use. Since most vehicles are not equipped with hour-meters, it may be necessary for you to approximate your idle time and plan oil/filter changes accordingly.
Page 202
The owner or a qualified service technician should make these vehicle inspections at the indicated intervals to ensure safe and dependable operation. Bring any problem to the attention of an Authorized Mazda Dealer or qualified service technician as soon as possible. REVIEW COPY...
Page 203
• Check windshield washer spray and wiper operation. Clean wiper blades with clean cloth dampened with washer fluid. • Check safety warning lamps (brake, ABS, air bag, safety belt) for operation. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 204
Check your “Warranty Information” to find out which parts and services are covered. Use only recommended fuels, lubricants, fluids and service parts conforming to specifications. Genuine Mazda parts are designed and built to provide the best performance in your vehicle. PRECAUTIONS WHEN SERVICING YOUR VEHICLE •...
Page 205
3. Lift the hood and support it with the prop rod. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
5. Engine oil filler cap 6. Brake fluid reservoir 7. Power distribution box 8. Clutch fluid reservoir (manual transmission) 9. Battery 10. Power steering fluid reservoir 11. Air filter assembly REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 207
5. Engine oil dipstick 6. Brake fluid reservoir 7. Power distribution box 8. Clutch fluid reservoir (manual transmission) 9. Battery 10. Power steering fluid reservoir 11. Air filter assembly REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 208
5. Brake fluid reservoir 6. Power distribution box 7. Clutch fluid reservoir (manual transmission) 8. Battery 9. Power steering fluid reservoir 10. Air filter assembly 11. Engine coolant reservoir REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 209
In very cold weather, do not fill the reservoir completely. Only use a washer fluid that meets Mazda specification . Refer to Lubricant specifications in this chapter. State or local regulations on volatile organic compounds may restrict the use of methanol, a common windshield washer antifreeze additive.
P (Park) (automatic transmission) or 1 (First) (manual transmission). 4. Open the hood. Protect yourself from engine heat. 5. Locate and carefully remove the engine oil level indicator (dipstick). • 2.3L I4 engine REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 211
Maintenance and Specifications • 3.0L V6 engine • 4.0L SOHC V6 engine REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 212
• If the oil level is below the MIN mark, add enough oil to raise the level within the MIN-MAX range. • 2.3L I4 engine SAE 5W-20 • 3.0L V6 engine SAE 5W-20 REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 213
To avoid possible oil loss, DO NOT operate the vehicle with the engine oil level indicator and/or the engine oil filler cap removed. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 214
Lubricant Standardization and Approval Committee (ISLAC), comprised of U.S. and Japanese automobile manufacturers. Use an equivalent oil Mazda specification. SAE 5W-20 oil provides optimum fuel economy and durability performance meeting all requirements for your vehicle’s engine. Change your engine oil and filter according to the appropriate schedule listed in the service maintenance section.
Mazda production and aftermarket (Mazda) oil filters are designed for added engine protection and long life. If a replacement oil filter is used that does not meet Mazda Material and design specifications, start-up engine noises or knock may be experienced.
Page 216
To begin this process: 1. With the vehicle at a complete stop, set the parking brake. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 217
ENGINE COOLANT Checking engine coolant Your engine’s cooling system has been factory-filled with a 50/50 mixture of distilled water and Mazda Genuine Engine Coolant, or an equivalent premium engine coolant that meets Mazda specification. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002),...
Page 218
Maintenance and Specifications A 50/50 mixture of distilled water and Mazda Genuine Engine Coolant provides: • maximum cooling system efficiency. • freeze protection down to -34°F (-36°C). • boiling protection up to 265°F (129°C). • protection against rust and other forms of corrosion.
Page 219
WARNING: Automotive fluids are not interchangeable; do not use engine coolant, antifreeze or windshield washer fluid outside of its specified function and vehicle location. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 220
Maintenance and Specifications Adding engine coolant Use only Mazda Genuine Engine Coolant or a premium engine coolant that meets a Mazda specification. • DO NOT USE Extended Life Engine Coolant (orange in color). • DO NOT USE a DEX-COOL engine coolant or an equivalent engine coolant.
Page 221
Recycled engine coolant Not all coolant recycling processes produce coolant which meets Mazda specification. Use of a recycled engine coolant which does not meet Mazda specifications may harm engine and cooling system components.
Page 222
REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 223
3. If this is not possible, wait for the engine to cool down. 4. When the engine has cooled down, first check the coolant level. If low, then use a rag and carefully turn the cap one notch REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 224
WARNING: Automotive fuels can cause serious injury or death if misused or mishandled. WARNING: Fuel ethanol and gasoline may contain benzene, which is a cancer-causing agent. Observe the following guidelines when handling automotive fuel: REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 225
Pure ethanol is the alcohol which is the intoxicating agent in liquor, beer and wine. It is distilled from the fermentation of plants such as field corn REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 226
Use the following guidelines to avoid static build-up when filling an ungrounded fuel container: REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) 100 meaning 100% pure ethanol...
Page 227
Otherwise, fuel may spray out and injure you or others. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 228
Mazda dealership to prevent any engine damage. Unleaded Gasoline engines Your vehicle is designed to use “Regular” unleaded gasoline with an (R+M)/2 octane rating of 87.
Page 229
“Regular” unleaded gasoline. “Premium” unleaded gasoline is not recommended (particularly in the United States) because it may cause these problems to become more pronounced. If the problems persist, see your authorized Mazda dealership. FFV engine (if equipped) Your FFV will operate well on ordinary “Regular”...
Page 230
“Check Engine” indicator, refer to the Instrument Cluster chapter. Fuel Filter For fuel filter replacement, see your authorized Mazda dealership. Refer to the service maintenance section for the appropriate intervals for changing the fuel filter. Replace the fuel filter with an authorized Mazda part. The customer warranty may be void for any damage to the fuel system if an authorized Mazda fuel filter is not used.
Page 231
Driving style — good driving and fuel economy habits Give consideration to the lists that follow and you may be able to change a number of variables and improve your fuel economy. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 232
• Carrying unnecessary weight may reduce fuel economy (approximately 1 mpg [0.4 km/L] is lost for every 400 lb [180 kg] of weight carried). REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 233
The scheduled maintenance items listed in the scheduled maintenance section are essential to the life and performance of your vehicle and to its emissions system. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 234
If other than Mazda authorized parts are used for maintenance replacements or for service of components affecting emission control, such non-Mazda parts should be equivalent to genuine Mazda parts in performance and durability. WARNING: Do not park, idle, or drive your vehicle in dry grass or other dry ground cover.
Page 235
Then, start the engine and complete the above driving cycle. The engine must warm up to its normal operating temperature. Once started, do not turn off the engine until the above driving cycle is complete. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 236
Maintenance and Specifications CHECKING AND ADDING POWER STEERING FLUID • 2.3L I4 engine • 3.0L V6 engine • 4.0L V6 engine REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 237
15 minutes. Seek medical attention if irritation persists. If taken internally, drink water and induce vomiting. Seek medical attention immediately. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 238
If the fluid level drops, refill the fluid level to the step in the reservoir. Use only a DOT 3 brake fluid designed to meet Mazda specification. Refer to Lubricant Specifications in this chapter. WARNING: Brake fluid is toxic. If brake fluid contacts the eyes, flush eyes with running water for 15 minutes.
Page 239
Low fluid level Do not drive the vehicle if the fluid level is at or below the bottom of the dipstick. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 240
8. Install and tighten the fill plug securely. Use only fluid that meets Mazda specifications. Refer to Lubricant specifications in this chapter. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002),...
Page 241
8. Install and tighten the fill plug securely. Use only fluid that meets Mazda specifications. Refer to Lubricant specifications in this chapter. DRIVELINE UNIVERSAL JOINT AND SLIP YOKE Your vehicle may be equipped with universal joints that require lubrication.
8. Install and tighten the fill plug securely. Use only fluid that meets Mazda specifications. Refer to Lubricant Specifications in this chapter. REFILL CAPACITIES Fluid Mazda Part...
Page 243
Mazda fluid MERCON ATF Mazda MERCON V Engine coolant Premium Engine Coolant REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Application Capacity Fill to range on dipstick 5-speed manual 2.8 quarts (2.65L) 4x2 vehicles 9.9 quarts...
Page 244
Add the coolant type originally equipped in your vehicle. DO NOT MIX different colors or types of coolant. DO NOT USE Mazda Extended Life Engine Coolant (orange in color). Refer to Adding engine coolant, in this chapter.
Maintenance and Specifications Traction-Lok axles use 4.75–5.0 pints (2.2–2.4L) of rear axle lubricant. Add 4 oz. (118 ml) of Additive Friction Modifier meeting Mazda specifications for complete refill of Traction-Lok axles. Service refill capacities are determined by filling the rear axle 1/4 inch to 9/16 inch (6 mm to 14 mm) below the bottom of the filler hole.
Page 246
Automatic transmission (5R44E and 5R55E) Windshield washer fluid Add 118 ml (4 oz.) of Additive Friction Modifier meeting Mazda specifications for complete refill of Traction-Lok axles. If submerged in water, the rear axle lubricant should be changed. Ensure the correct automatic transmission fluid is used. Transmission fluid requirements are indicated on the dipstick or on the dipstick handle.
Page 248
Certification Label may be located. The Certification label is located on the structure by the trailing edge of the driver’s door or the edge of the driver’s door. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus)
Page 249
The engine number (the last eight numbers of the vehicle identification number) is stamped on the engine block, transmission, frame and transfer case (if equipped). REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) XXXXXXXXXXXXXXXXX...
In addition, the gasoline distributors are warning against using cell phones during refueling procedures, due to their increased concern about static electricity fires in the self-service pump environment. REVIEW COPY 2005 Mazda B Series (mbs), Owners Guide (post-2002-fmt) (own2002), Market: USA_English (fus) Accessories...
Need help?
Do you have a question about the 2005 B2300 Truck and is the answer not in the manual?
Questions and answers