Table of Contents
Advertisement
Rear Discharge Grooming Mowers
FDR2572 & FDR2584 and
20658
Table of Contents
Read the Operator's Manual entirely. When you
!
see this symbol, the subsequent instructions and
warnings are serious - follow without exception.
Your life and the lives of others depend on it!
Cover photo may show optional equipment
not supplied with standard unit.
© Copyright 2012
310-262M
Operator's Manual
5/04/12
Printed
Advertisement
Table of Contents
Related Manuals for Land Pride FDR2584
Summary of Contents for Land Pride FDR2584
- Page 1 Rear Discharge Grooming Mowers FDR2572 & FDR2584 and 20658 Table of Contents Read the Operator’s Manual entirely. When you see this symbol, the subsequent instructions and warnings are serious - follow without exception. Your life and the lives of others depend on it! Cover photo may show optional equipment not supplied with standard unit.
-
Page 2: Table Of Contents
Land Pride assumes no responsibility for errors or omissions. Neither is any liability assumed for damages resulting from the use of the information contained herein. Land Pride reserves the right to revise and improve its products as it sees fit. This publication describes the state of this product at the time of its publication, and may not reflect the product in the future. -
Page 3: Safety At All Times
For Your Protection Thoroughly read and understand the “Safety Label” section, read all instructions noted on them. FDR2572 & FDR2584 and Rear Discharge Grooming Mowers 310-262M WARNING Indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury, and includes hazards that are exposed when guards are removed. - Page 4 Lower the implement to the ground, put tractor in park, turn off engine, and remove key before performing maintenance. FDR2572 & FDR2584 and Rear Discharge Grooming Mowers 310-262M Table of Contents Transport Machinery Safely Comply with state and local laws.
- Page 5 When removing and installing wheels, use wheel handling equipment adequate for the weight involved. FDR2572 & FDR2584 and Rear Discharge Grooming Mowers 310-262M Avoid High Pressure Fluids Hazard Escaping fluid under pressure can penetrate the skin causing serious injury.
-
Page 6: Safety Labels
Read and follow their directions. Keep all safety labels clean and legible. Replace all damaged or missing labels. To order new labels go to your nearest Land Pride dealer or visit our dealer locator at landpride.com. Some new equipment installed during repair requires safety labels to be affixed to the replaced component as FDR2572 &... - Page 7 Important Safety Information 5/04/12 Table of Contents 17362 30262 ROTATING DRIVELINE KEEP AWAY! 13314 17359 FDR2572 & FDR2584 and Rear Discharge Grooming Mowers 310-262M 818-543C Danger: Guard Missing 818-142C Danger: Rotating Driveline 818-552C Danger: Rotating Driveline 818-558C Warning: General...
- Page 8 Important Safety Information FDR2572 & FDR2584 and Rear Discharge Grooming Mowers 310-262M Table of Contents 17360 17361 838-270C Caution: V-Belt Installation FDR2572 17362 818-555C Danger: Rotating Blade 818-556C Danger: Thrown Object 838-116C Caution: V-Belt Installation FDR2584 5/04/12...
-
Page 9: Introduction
Introduction Introduction Land Pride welcomes you to the growing family of new product owners. This implement has been designed with care and built by skilled workers using quality materials. Proper assembly, maintenance, and safe operating practices will help you get years of satisfactory use from the machine. -
Page 10: Section 1: Assembly & Set-Up
Operator’s Manual. Remove temporary solid plug from top of gearbox and replace with vented dipstick. See your nearest Land Pride Dealer if dipstick is missing. FDR2572 & FDR2584 and Rear Discharge Grooming Mowers 310-262M Table of Contents Pre-Assembly Checklist Make sure miscellaneous assembly tools are on hand: Hammer, tape measure, hacksaw, assortment of wrenches &... -
Page 11: A-Frame
5/8" flange bolts (#3) and flange nut (#4) already mounted in the holes of the front hitch plates. 8. Tighten all hardware in the rear hitch braces and A-frame. Hitch Braces Assembly Figure 1-2 FDR2572 & FDR2584 and Rear Discharge Grooming Mowers 310-262M 17365... -
Page 12: Tractor Hook-Up
Do not use a PTO adaptor with a quick hitch. A PTO adapter will increase strain on the tractor’s PTO shaft resulting in possible damage to shaft and driveline. FDR2572 & FDR2584 and Rear Discharge Grooming Mowers 310-262M Table of Contents WARNING... -
Page 13: Check Driveline Collapsible Length
Driveline Maximum Allowable Length 3. Reattach driveline to tractor and gearbox shaft following “Driveline Installation” steps 1 to 8 on page 10. 4. Continue with “Check Driveline Interference” on page 12. FDR2572 & FDR2584 and Rear Discharge Grooming Mowers 310-262M Figure 1-5... -
Page 14: Check Driveline Interference
Driveline does not exceed maximum allowable length recorded in step 2 under “Check Driveline Maximum Length” on page 11. 5/04/12 Table of Contents Maximum PTO Driveline Movement During Operation FDR2572 & FDR2584 and Rear Discharge Grooming Mowers 310-262M 24872 Figure 1-6... -
Page 15: Section 2: Accessories & Set-Up
There are four blade choices to select from based upon soil condition, density of grass, and tractor horsepower. The appearance of the finish cut may vary between low lift and high lift blades. See your Land Pride dealer for blade availability. Low Lift Blades Land Pride’s low lift blades are designed for mowing over... -
Page 16: Section 4: Adjustments
3. Position full length spacers and half spacer as required. All spacers on top of spindle tube allows for approximately 3/4" cutting height. Adjustments FDR2572 & FDR2584 and Rear Discharge Grooming Mowers 310-262M Table of Contents range from 3/4" to a maximum of 5-1/4" in 1/2"... -
Page 17: Section 3: Operating Instructions
7. Once mower is running smoothly, increase tractor PTO speed to the appropriate rpm. Stop PTO Page 23 rotation immediately if vibration occurs. 8. Investigate the cause of vibration. Make necessary Page 28 corrections before continuing. blade FDR2572 & FDR2584 and Rear Discharge Grooming Mowers 310-262M... -
Page 18: Transporting
Always remove mower from service until damaged driveline is repaired or replaced. FDR2572 & FDR2584 and Rear Discharge Grooming Mowers 310-262M Table of Contents DANGER Do not engage tractor PTO while hooking-up and unhooking driveline or while someone is standing near the driveline. -
Page 19: Un-Hooking The Mower
6. Store driveline in driveline hanger to keep driveline up off the ground. 7. See “Storage Instructions” on page 21 if mower is not going to be used for a long time. FDR2572 & FDR2584 and Rear Discharge Grooming Mowers 310-262M Driveline Hanger 19301 Driveline Storage... -
Page 20: General Operating Instructions
Discharge Grooming Mower. Always remember that there is no substitute for proper maintenance and good safe operating practices. See “Features and Benefits” section or “Product Specifications” for additional information and performance enhancing options. FDR2572 & FDR2584 and Rear Discharge Grooming Mowers 310-262M 5/04/12... -
Page 21: Section 5: Maintenance & Lubrication
Never weld a broken or cracked blade. DO NOT attempt to straighten to reuse such blades. ALWAYS replace with a new Land Pride blade to assure safety. WARNING DO NOT attempt to modify blade, such as hard surfacing, heat or cold treating, or by any other method. -
Page 22: Blade Sharpening Or Replacement
NAIL OR SHAFT 19046 Blade Balancing Figure 5-3 FDR2572 & FDR2584 and Rear Discharge Grooming Mowers 310-262M Table of Contents IMPORTANT: Always install blade with the cutting edge facing direction of rotation. 4. Mount blade with wing tips pointing up towards bottom of deck. -
Page 23: Storage Instructions
7. Store mower on a level surface in a clean, dry place. Inside storage will reduce maintenance and make for a longer mower life. 8. Follow all unhooking instructions on page 17 when disconnecting tractor from mower. 5/04/12 Table of Contents FDR2572 & FDR2584 and Rear Discharge Grooming Mowers 310-262M... -
Page 24: Lubrication
Lubrication Multi-purpose Legend spray lube 24871 24871 24873 17358 FDR2572 & FDR2584 and Rear Discharge Grooming Mowers 310-262M Table of Contents Multi-purpose Multi-purpose grease lube oil lube Driveline Shaft U-Joints Type of Lubrication: Multi-purpose Grease Quantity - 4 to 8 Pumps... -
Page 25: Gearbox
Quantity = Fill until oil reaches top mark on dipstick or begins to flows out side plug hole in gearbox. Bearing in Blade Spindle Hubs Type of Lubrication: Multi-purpose Grease FDR2572 & FDR2584 and Rear Discharge Grooming Mowers 310-262M Required Hours... -
Page 26: Section 6: Specifications & Capacities
Castered Gauge Wheels Caster Wheel Spindle Drive Train Gearbox Oil Capacity & Type Driveline Front Roller Quick Hitch Compatible FDR2572 & FDR2584 and Rear Discharge Grooming Mowers 310-262M Table of Contents FDR2572 50 HP 72" 74 3/4" 35 1/2" 69"... - Page 27 Table of Contents Section 6: Specifications & Capacities 26761 5/04/12 FDR2572 & FDR2584 and Rear Discharge Grooming Mowers 310-262M...
-
Page 28: Section 7: Features & Benefits
Roller bearings allow for a long life. FDR2584 Only - Semi solid Semi solid tires on the FDR2584 offer premium flotation. Roller bearings allow for a long tires with roller bearings life. Semi solid tires offer shock absorption. -
Page 29: Section 8: Troubleshooting
Change mowing pattern. Reduce speed turns. Shift to a lower gear. Level mower. Sharpen blades & balance or replace. Mow at full throttle (540 PTO rpm). Shift to a lower gear. Clean mower. FDR2572 & FDR2584 and Rear Discharge Grooming Mowers 310-262M... -
Page 30: Section 9: Torque Values Chart
2640 1-1/2" - 12 1330 2970 Torque tolerance + 0%, -15% of torquing values. Unless otherwise specified use torque values listed above. FDR2572 & FDR2584 and Rear Discharge Grooming Mowers 310-262M Table of Contents Bolt Size (Metric) Grade 8 ft-lb N·m... -
Page 31: Section 10: Warranty
This Warranty does not apply to any part or product which in Land Pride’s judgment shall have been misused or damaged by accident or lack of normal... - Page 32 Corporate Office: P.O. Box 5060 Salina, Kansas 67402-5060 USA www.landpride.com...