1. Manuals
  2. Brands
  3. Winnebago Manuals
  4. Motorhomes
  5. Ultimate Advantage
  6. Owner's manual

Winnebago Ultimate Advantage Owner's Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

Congratulations! We welcome you to the exciting world of motor home travel and camping. You will
find it convenient and enjoyable to have all the comforts of home and still enjoy the great outdoors wher-
ever you choose to go.
Your Ultimate Advantage motor home has been carefully designed, engineered and manufactured to
provide dependability as well as safety. Before sliding into the driver's seat, take a few minutes to become
familiar with operations and features. This manual was prepared to aid you in the proper care and operation
of the vehicle and equipment. We urge you to read it completely. In addition, spend some time with the
dealer when you take delivery, you will want to learn all you can about your new motor home.
Your new Ultimate Advantage motor home is covered by a factory warranty against defects in material
and workmanship. This warranty should be validated at once and returned to the factory by your dealer.
About Safety Messages Used in This Manual
Throughout this manual, certain items are labeled Note, Caution, Warning or Danger. These terms alert
you to precautions that may involved damage to your vehicle or a risk to your personal safety. Read and
follow them carefully.
This SAFETY ALERT SYMBOL is used to draw your attention to issues which could involved
potential personal injury. This symbol is used throughout this manual and/or on labels affixed
on or near various equipment in this motor home.
DANGER
DANGER indicates a directly hazard-
ous situation which, if not avoided,
will result in death or serious personal
injury.
.
WARNING
WARNING indicates a potentially
hazardous situation which, if not
avoided, could result in death or seri-
ous personal injury.
October 2002
TO THE OWNER
132000-11-003

Advertisement

Table of Contents
loading

Related Manuals for Winnebago Ultimate Advantage

Summary of Contents for Winnebago Ultimate Advantage

  • Page 1 Your new Ultimate Advantage motor home is covered by a factory warranty against defects in material and workmanship. This warranty should be validated at once and returned to the factory by your dealer.
  • Page 2 CAUTION CAUTION indicates a potentially hazardous situation which, if not avoided, could result in damage mainly to equipment or property, but in some cases may also result in minor or moderate personal injury. NOTE: A ‘Note’ is not necessarily safety related but indicates a recommendation or special point of information that could assist in understanding the use or care of a feature item.
  • Page 3 OWNER’S NAME STREET ADDRESS CITY AND STATE (OR PROVINCE IN CANADA) MOTOR HOME SERIAL NUMBER VEHICLE CHASSIS IDENTIFICATION NO. (VIN) DATE OF DELIVERY TO FIRST RETAIL PURCHASER VEHICLE MILEAGE AT TIME OF DELIVERY SELLING DEALER NAME AND ADDRESS TANK CAPACITIES Spartan Diesel Chassis Fuel Tank......

  • Page 7: Table Of Contents

    TABLE OF CONTENTS Power Electric Mirrors........ 2- 12 INTRODUCTION About this Manual ........0- 1 Driver Seat ..........2- 15 Spartan Chassis Operating Guide ....0- 1 Seat Belts ............ 2- 16 Cummins Diesel Engine Manual ....0- 1 Child Restraints........... 2- 18 Owner’s InfoCase .........
  • Page 8 TABLE OF CONTENTS SECTION 6: ELECTRICAL SYSTEMS LP Gas Furnace (Suburban)......8- 12 110-Volt AC System........6- 1 Electronic Thermostat......... 8- 13 External Power Cord (Shoreline)....6- 1 TV Antenna..........8- 16 Connecting the Shoreline......6- 2 Antenna Signal Amplifier......8- 17 Powerline Energy Management Digital Satellite Television System.....

  • Page 9: Introduction

    Congratulations on the purchase of your new This manual should be kept in the vehicle at all times for personal reference. The operator’s Ultimate Advantage motor home, which has been manual, I and chassis operating guide carefully designed, engineered and quality built are to be considered permanent components of by Winnebago Industries, Inc.

  • Page 10: Owner's Infocase

    Some equipment described in this manual may not apply to your coach. SERVICE AND ASSISTANCE Your Ultimate Advantage dealer will be glad BEFORE DRIVING to provide any additional information you need, as well as answer any questions you might have Before sitting in the driver’s seat, always...

  • Page 11: Drinking And Driving

    National Highway Traffic Safety Administration (NHTSA) in addition to notifying Winnebago Industries, Inc. If NHTSA receives similar complaints, it may open an investigation, and if it finds that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign.

  • Page 12: Vehicle Certification Label

    MPV meet handling and safety requirements. signifies a Multi-purpose Passenger Vehicle. When replacing any of the tires on your 13. Model: Lists the Winnebago product model vehicle, always replace with a tire that meets number of your vehicle. these specifications.

  • Page 13: Exterior Feature Identification

    INTRODUCTION EXTERIOR FEATURE IDENTIFICATION Composite model shown for illustration purposes only. Actual locations of features depends on coach model and options. NOTE: Some equipment shown may be optional. *Also contains diesel fuel filter/water separator. **Also contains optional freezer unit if equipped. ††Also contains Cable TV and Phone hookups and engine block heater plug-in.

  • Page 15: Section 1: Safety Precautions

    SECTION 1 SAFETY PRECAUTIONS · Make sure all passengers have seat belts fas- Read and understand all instructions and pre- tened in a low and snug position so the force cautions in this manual before operating your exerted by the belt in a collision will be new motor home.

  • Page 16: Fuel And Lp Gas

    SECTION 1 SAFETY PRECAUTIONS · Driving through water deep enough to wet · Never use an open flame to test for LP gas the brakes may affect stopping distance or leaks. Replace all protective covers and caps cause the vehicle to pull to one side. Check on LP system after filling.

  • Page 17: Lp Gas Leaks

    SECTION 1 SAFETY PRECAUTIONS Press to stop alarm LP GAS LEAKS The following label is located in the vehicle near the range area. If you smell gas within the vehicle, quickly and carefully perform the proce- dures listed. IF YOU SMELL GAS 1.

  • Page 18: Electrical

    SECTION 1 SAFETY PRECAUTIONS work. The LP gas alarm breaker is located on the coach breaker fuse panel shown in Section 6. Because the LP gas alarm is connected direct- ly to the auxiliary battery, it is always drawing a LOADING small amount of current.

  • Page 19: Formaldehyde Information

    SECTION 1 SAFETY PRECAUTIONS · Each time the vehicle is raised for an oil FORMALDEHYDE INFORMATION change. · Whenever a change in the sound of the ex- WARNING haust system is noticed. · Whenever the exhaust system, underbody or rear of the vehicle is damaged. Some components in this vehicle con- tain formaldehyde based adhesives To allow proper operation of the vehicle’s...

  • Page 20: Emergency Exits

    SECTION 1 SAFETY PRECAUTIONS The CO alarm is powered by a 9-volt battery EMERGENCY EXITS and contains a sensor that is designed to detect Emergency Exit Windows toxic carbon monoxide gas fumes resulting from incomplete combustion of fuel. It will detect CO Your motor home is equipped with an emer- gas from any combustion source such as the fur- gency exit window on the left (driver’s) side of...

  • Page 21: Fire Extinguisher

    SECTION 1 SAFETY PRECAUTIONS should the need arise. To use the windows as exits, slide the window open, then slide the SMOKE ALARM screen open. Your motor home is equipped with a smoke alarm located on the ceiling in the galley and SAFETY DEVICES lounge area.
  • Page 22 SECTION 1 SAFETY PRECAUTIONS Install a new battery immediately. Be sure to use only batteries specified in manual or on unit. Test unit after installing a new battery. 3. Clean and vacuum the openings on your smoke alarm once a month.Do not open the smoke alarm or try to repair it.

  • Page 23: Before Entering Your Vehicle

    SECTION 2 DRIVING YOUR MOTORHOME (See also Safety Precautions, Section 1 of this manual.) WARNING NOTE: See your Spartan chassis operator's The engine should be shut off unless manual for information on starting the specifically required for a certain pro- engine, operating the transmission, cedure.

  • Page 24: Fuel Selection

    The key number for your coach is registered in until the tank is full. our factory database, so if you ever lose your keys, any Winnebago Industries dealership can Diesel Fuel Tank Capacity ..100 gal. diesel easily order a new key for you. They are also...

  • Page 25: Engine Block Heater

    SECTION 2 DRIVING YOUR MOTOR HOME See also “Engine Block Heater” elsewhere in this section. Idling Diesel Engine ENGINE BLOCK HEATER CAUTION Your coach is equipped with an engine block heater to assist starting in freezing temperatures. The Cummins diesel engine must be The power cord is located in the rear cargo com- set to 1000 rpm fast idle mode if partment on the driver side of the coach.

  • Page 26: Parking Brakes

    SECTION 2 DRIVING YOUR MOTOR HOME PARKING BRAKES The parking brakes are applied by pulling out- ward on the large yellow knob on the dash to the left of the steering column. Push the knob in to release the brakes. Exhaust Brake Switch ®...

  • Page 27: Signal Lever/Headlight Hi/Lo Beam

    SECTION 2 DRIVING YOUR MOTOR HOME signal/cruise lever. Pull the switch button out- HEADLIGHT BEAM CHANGE ward from the column to activate the flashers. To AND TURN SIGNALS cancel flashers, push the switch button inward to- ward the column. See also Section 3 for further Move multi-function lever upward for right operating information.
  • Page 28 SECTION 2 DRIVING YOUR MOTOR HOME (Truckers often use this signal as a greeting or an expression of thanks for assistance in passing, etc.) SMARTWHEEL STEERING WHEEL CONTROL SYSTEM The Smart Wheel Control System offers convenient and safe control of the horn, headlight and marker light flash, cruise control, and wiper functions all from switch panels mounted at your fingertips on the steering wheel.
  • Page 29 SECTION 2 DRIVING YOUR MOTOR HOME Here’s how it works: WARNING • During a light rain or mist, when your wind- shield needs a clearing wipe, press the button once and the wiper will swipe back and forth Do not operate the cruise control on once a Lo speed.

  • Page 30: Entrance Door Lock And Handle

    SECTION 2 DRIVING YOUR MOTOR HOME To lock the door from inside, rotate the lock levers as indicated. The deadbolt lock is for add- ed security and should be used as a security night lock. RES BUTTON DECREASES HIGH IDLE RPM: •...
  • Page 31 SECTION 2 DRIVING YOUR MOTOR HOME Keyless Remote Unit Unlock: When you return to the coach, press the “Unlock” button on the transmitter and your parking lights will flash twice to tell you that the door has unlocked. The porch light will also Cargo Door Lock Switch Power Lock Switch come on for 20 seconds to light your way to the...

  • Page 32: Electric Entrance Step

    SECTION 2 DRIVING YOUR MOTOR HOME Recommended 12 volt battery: screen door is closed. With the power switch in Gold Peak GP27A or GP23A the Off position the step can be kept in the ex- Bronica B-1 tended or retracted position as described below. Radio Shack #23-144 or #23-279 Stationary Extended Mode To keep the step in the extended position:...

  • Page 33: Stepwell Cover

    SECTION 2 DRIVING YOUR MOTOR HOME WARNING CAUTION Do not use steps unless it is fully Stay clear of entrance step area when extended. stepwell is being extended or retracted. When entering or exiting, Do Not Stand on step when vehicles loose clothing may catch on compo- ignition switch is turned to either the nents of the mechanism.

  • Page 34: Power Electric Mirrors

    SECTION 2 DRIVING YOUR MOTOR HOME the mirror manufacturer’s instructions in your Owner InfoCase. POWER ELECTRIC MIRRORS More Info The electric mirrors are adjusted using a To read more about power mirrors, see the multi-directional switch located on the driver’s mirror manufacturer’s information in your side armrest.
  • Page 35 SECTION 2 DRIVING YOUR MOTOR HOME See the ALPINE Mapping System operation guide in your InfoCase for detailed instructions on using this system ELECTRONIC COMPASS & OUTSIDE THERMOMETER COMPASS OPERATION Power visor switches on driver armrest panel The compass has two (2) buttons - MODE and °F/°C - which are used to change the unit between the various operating modes.
  • Page 36 SECTION 2 DRIVING YOUR MOTOR HOME Camping Mode Operation: ZONE ADJUSTMENT 1. Unit enters CAMPING MODE after the °F/ When you travel outside the zone, the unit is currently set ‘on’, the compass has reduced accu- °C button or MODE is pressed for (three) 3 racy.

  • Page 37: Driver Seat

    SECTION 2 DRIVING YOUR MOTOR HOME trolled by a hand-held remote control unit included in your Owner InfoCase. This conve- nient features allow you to operate the spotlight without having to be in the driver seat. You can operate it from anywhere inside that coach, and even while outside the coach for a limited dis- tance.

  • Page 38: Seat Belts

    SECTION 2 DRIVING YOUR MOTOR HOME cations are opposite or ‘mirrored’ to keep aisle- side and door-side positions. WARNING Do not adjust driver’s seat while vehi- cle is in motion. SEAT BELTS After adjusting seat, always use body Seats intended for occupancy while the vehi- pressure to make sure slide and cle is in motion are equipped with seat belts for swivel locking mechanism have...
  • Page 39 SECTION 2 DRIVING YOUR MOTOR HOME WARNING Snug and low belt positions are essential. This will ensure that the force exerted by the lap belt in a colli- sion is spread over the strong hip area and not across the abdomen, which could result in serious injury.

  • Page 40: Child Restraints

    SECTION 2 DRIVING YOUR MOTOR HOME • Keep belts clean and dry. If the belts need stand them fully and can install the restraint cleaning, use only a mild soap and water properly and safely in your vehicle. solution. Do not use hot water. Do not use abrasive cleaners or bleach.
  • Page 41 SECTION 2 DRIVING YOUR MOTOR HOME INSTRUMENT PANEL *See your Spartan chassis operator manual for details. NOTE: Some equipment or controls shown may be optional or unavailable on your model. 2-19...

  • Page 42: Comfort Controls

    SECTION 2 DRIVING YOUR MOTOR HOME B. For reduced defrosting: COMFORT CONTROLS 1. Turn the temperature control knob to the AUTO AIR CONDITIONER/ left to an intermediate setting. HEATER 2. Adjust the fan speed for desired volume. Controls for the air conditioner, heater, de- froster and vent are all combined into one control VENTILATION panel.

  • Page 43: Antenna Check Light

    SECTION 2 DRIVING YOUR MOTOR HOME ANTENNA CHECK LIGHT Please refer to the Visteon radio manufactur- er’s operating guide in your InfoCase for detailed The antenna check light will come on for 20 instructions on programming preset station but- seconds when the ignition switch is turned on to tons and using this full-featured radio/audio sys- remind you to be sure the TV antenna and satel- tem.

  • Page 44: Cb Radio Wiring

    SECTION 2 DRIVING YOUR MOTOR HOME will help optimize transmitting and receiving ca- pabilities of the radio system. CB RADIO CB RADIO WIRING CB POWER PROVISION CB POWER PROVISION LABEL Purple +12 V + 12 V Green Ground BLACK GROUND Coax Antenna COAX...
  • Page 45 SECTION 2 DRIVING YOUR MOTOR HOME AUTOMATIC COACH LEVELING SYSTEM Your coach may be optionally equipped with a 4-point HWH computerized, automatic, hy- draulic leveling system. This leveling system is designed to diminish problems in selecting a parking site, making “set up”...

  • Page 46: Slideout Room Extension

    SECTION 2 DRIVING YOUR MOTOR HOME Turn T-handle out about six turns until fully open. WARNING Keep all people clear of the coach while the leveling system is operat- ing. Do not use leveling jacks to support vehicle for service or tire changing. Further Information See the HWH Operator Manual supplied in your Owner InfoCase.
  • Page 47 SECTION 2 DRIVING YOUR MOTOR HOME Travel Straps (Front Slideout Room) The Travel Straps must be released before attempting to extend the room or damage to the coach will result. The travel straps are designed only to help keep the room extension secured against the coach sidewall to maintain an effective weather seal while the vehicle is in motion.
  • Page 48 SECTION 2 DRIVING YOUR MOTOR HOME · Level the coach. · Set the Parking Brake. An interlock relay system will then provide power to the slide- out control switches. · Release travel straps (galley). · Press slide-out switch and hold until room is fully extended, then release switch.
  • Page 49 SECTION 2 DRIVING YOUR MOTOR HOME · If the batteries and fuses are okay, there may NOTE: The hydraulic pump is equipped with two be a failure in the hydraulic system or electri- types of hydraulic solenoid valves cal system. See “Emergency Crank-In In- shown.
  • Page 50 SECTION 2 DRIVING YOUR MOTOR HOME vided beneath the banquette, which at- Use provided 1/4” nut driver to turn nut taches to the “tail strap” on the winch counterclockwise 3 turns only. assembly. · Insert the winch strap hook into the sewn loop end of the strap beneath the couch.
  • Page 51 SECTION 2 DRIVING YOUR MOTOR HOME NOTE: Check fuses #16-Step Alarm and #24-Ra- dio/Acc. There is also a fuse on the back of the HWH leveling system control pad. Unfasten the control pad from the driver side armrest panel to inspect the fuse. If an apparent cause is not found, follow the crank-in procedure below.
  • Page 52 “creep out” during transit. to a servicing dealership. • See an authorized Winnebago Industries dealer for service of the slideout control sys- Step 4 - Prep For Travel tem. · Before driving off, close solenoid valves on hydraulic pump to prevent “creep out”...
  • Page 53 SECTION 2 DRIVING YOUR MOTOR HOME Further Information See the HWH Hydraulic Room Extension operating guide included in your Owner’s Info- Case for further instructions and troubleshooting information. 2-31...

  • Page 55: Section 3: In Case Of Driving Emergency

    SECTION 3 IN CASE OF DRIVING EMERGENCY number on your Winnebago Industries Premium HAZARD WARNING Roadside Assistance card. A tire center road FLASHER service unit will be quickly dispatched to your location to service your tire on the spot. A quali-...

  • Page 56: Jump Starting

    SECTION 3 IN CASE OF DRIVING EMERGENCY NOTE: Know and obey all state and local towing CONNECTING JUMPER regulations. Tow at reduced speed. CABLES 1. Make sure that the other vehicle has a 12- JUMP STARTING volt battery and negative ground compatible If your coach will not start from the automo- with your vehicle’s electrical system.

  • Page 57: Connecting A Battery Charger

    SECTION 3 IN CASE OF DRIVING EMERGENCY 9. Reverse the above sequence EXACTLY when removing the jumper cables. Start by WARNING removing the cable from the ground location on the engine first, then continue in reverse Operating a vehicle under a severe sequence.
  • Page 58 SECTION 3 IN CASE OF DRIVING EMERGENCY When no trace of escaping steam is heard or seen, open the hood to check for the cause of the overheat. Check hose connections and tighten if necessary. Make sure there are no broken belts, pulleys or hoses before adding any coolant to the coolant reservoir.

  • Page 59: Loading The Vehicle

    SECTION 4 TRAVELING WITH YOUR MOTORHOME (See also SAFETY PRECAUTIONS, Section 1 of this manual.) CAUTION LOADING THE The weight of the loaded vehicle VEHICLE (including options, attachments, pas- sengers, water, fuel, luggage and all NOTE: Your motor home’s load capacity is other cargo) must not exceed the designated by weight, not by volume, so you cannot necessarily use all available...

  • Page 60: Maximum Occupancy

    Cargo Carrying Capacity (CCC). To calculate the CCC, Winnebago uses vehicle sleeping capacity, however your coach may be equipped with more belted seating posi- tions than sleeping positions to give passengers a choice of seating arrangements.

  • Page 61: Pre-Travel Check List

    SECTION 4 TRAVELING WITH YOUR MOTOR HOME WARNING CAR OR TRAILER TOWING For safety towing and vehicle hand- Spartan Chassis ling, maintain proper trailer weight Hitch pulling cap.: 10,000 lbs. max distribution. Tongue weight: 500 lbs. max. The total weight of the motor home The factory installed towing hitch on this and the vehicle towed must not coach is rated to pull a 10,000 lb.

  • Page 62: Travel Tips

    SECTION 4 TRAVELING WITH YOUR MOTOR HOME - Drive Belts - Check for proper condition and may contain an undesirable taste. Do not use tension (not cracked, frayed, or loose, etc.) a new hose to fill the water tank. It can leave - 110-Volt Generator (Optional) - Check oil a distinct rubber or vinyl taste.

  • Page 63: Severe Weather Information

    SECTION 4 TRAVELING WITH YOUR MOTOR HOME good parking spot once you have arrived at mediately (at least 30-40 feet above the can- your destination. yon floor or bottom of dry wash). 16. When you sit over the front wheels while ·...

  • Page 64: Nighttime Driving

    SECTION 4 TRAVELING WITH YOUR MOTOR HOME vice will interrupt with storm watches and warn- DESCENDING A HILL ings and live reports when the situation demands. When going down a long grade, you may need to manually shift to a lower gear, rather than keeping your foot on the brake pedal.

  • Page 65: Effects Of Prolonged Occupancy

    SECTION 4 TRAVELING WITH YOUR MOTOR HOME ly. Also, water and holding tank level indicators Ventilate with outside air: Partially open one or may give false readings because water level is more windows and a roof vent to circulate out- greater at one side of the tank than the other.

  • Page 67: Section 5: Lp Gas System

    SECTION 5 LP GAS SYSTEM (See also Safety Precautions, Section 1 of this at each tank filling. Also inspect before and manual.) after each trip, and any time trouble is sus- pected. · Turn the LP supply valve off when not using the LP gas system.

  • Page 68: Selecting Lp Fuel Types

    SECTION 5 LP GAS SYSTEM SELECTING LP FUEL TYPES LP TANK SYSTEM We recommend using straight propane in your The storage reservoir for the LP gas system is LP tank. Propane gas is commonly available at a horizontally mounted tank which is permanent- all LP gas outlets in the U.S.

  • Page 69: Air In The Lp Gas Tank

    SECTION 5 LP GAS SYSTEM NOTE: The LP tank is equipped with an auto- matic 80% stop-fill device. TRAVEL WITH LP GAS It is illegal for vehicles equipped with LP tanks to travel on certain roadways or through LP Gas Tank Capacity: certain tunnels in the U.S.

  • Page 70: Regulator

    SECTION 5 LP GAS SYSTEM REGULATOR Be sure vent hole is not blocked The pressure regulator is protected from the elements by a plastic cover which should be left in place at all times. Only your dealer or a quali- fied LP gas service should remove the regulator cover for adjustments.

  • Page 71: Winter Use Of Lp Gas

    SECTION 5 LP GAS SYSTEM BTU’s Available at 0° F. DANGER Tank Level BTU’s 64,000 IF YOU SMELL GAS 50,400 EXTINGUISH ANY OPEN FLAME, PILOT LIGHTS AND 33,000 ALL SMOKING MATERIALS. DO NOT TOUCH ELECTRICAL SWITCHES. SHUT OFF THE GAS SUPPLY AT THE TANK VALVE(S) The following LP Gas Vaporization and Tem- OR GAS SUPPLY CONNECTIONS.

  • Page 73: Section 6: Electrical Systems

    SECTION 6 ELECTRICAL SYSTEMS (See also Safety Precautions, Section 1 of this manual.) Your coach is equipped with an electrical sys- tem consisting of two separate voltages; a 12-volt DC system and a 110-volt AC system. The 12- volt system consists of two internal power sources, while the 110-volt system is operated from an outside power source, or from the optional 110-volt generator or 110-volt inverter...

  • Page 74: Connecting The Shoreline

    SECTION 6 ELECTRICAL SYSTEMS CONNECTING THE SHORELINE To connect to an external source, remove the cord from the storage compartment and plug the coach end of the cord into the coach input recep- tacle. (The coach end is the large, yellow plug.) 1.

  • Page 75: Powerline Energy Management System (Ems)

    SECTION 6 ELECTRICAL SYSTEMS EMS Panel WARNING Do not plug the power cord into an outlet which is not grounded, or adapt the plug to connect to a receptacle for which it is not designed. Be sure that all four prongs of the sup- ply cord are properly plugged into the receptacle.

  • Page 76: Inverter/Charger And Circuit Breaker Locations

    SECTION 6 ELECTRICAL SYSTEMS Certain circuits, however, remain unchanged See the Xantrex/Heart Interface remote panel instructions in your Owners InfoCase for for use by items which require 110-volt current, complete information and specific configura- such as the air conditioner(s), the refrigerator in tion directions.
  • Page 77 SECTION 6 ELECTRICAL SYSTEMS short develops, the breaker will open preventing any further flow of electricity and, therefore, damage to the system. Shut off the equipment (example: air condi- tioner) and allow a brief cooling period. Then reset the breaker by moving the switch to “Off” and back to “On”.

  • Page 78: Thermal Overload Protector

    SECTION 6 ELECTRICAL SYSTEMS discharged, they will charge at a lower amperage rate. The rate of charge will decrease as the 110-VOLT RECEPTACLES batteries reach “full charge”, then will remain “trickle” charging at a very low amperage rate. If (OUTLETS) your storage battery does not charge as described A number of standard AC electrical outlets are above, it is possible the battery is defective.

  • Page 79: Auxiliary 110-Volt Generator

    SECTION 6 ELECTRICAL SYSTEMS WARNING Careless handling of the generator RESET and electrical components can be fa- TEST tal. Never touch electrical leads or appli- ances when your hands are wet, or when standing in water or on wet ground. WARNING Do not attempt to repair the generator yourself.
  • Page 80 SECTION 6 ELECTRICAL SYSTEMS Approximate Power Requirements of Common Appliances Appliance or Tool Approximate Power Consumption (Watts/Amps) Vacuum cleaner 200-500W/1.7-4.3A Coffee Maker 550-700W/4.8-6.1A Hair dryer 800-1500W/7.0-13.0A Electric clothes iron 500-1200W/4.3-10.4A Electric blanket 50-200W/0.4-1.7A Television 80-100W/0.7A Electric drill 250-750W/2.2-6.5A Air conditioner 1400-2000W/13-19A Microwave Oven 700-1500W/6.0-13.0A...

  • Page 81: Operation Warnings And Cautions

    SECTION 6 ELECTRICAL SYSTEMS OPERATION WARNINGS AND GENERATOR PULL OUT SERVICE TRAY RETAINERS: The generator service tray is CAUTIONS held in place by a latch mechanism and a travel- locking pin at the left front side of the slide rails. WARNING To slide generator out for service: The exhaust of all internal combus-...

  • Page 82: 12-Volt Dc System

    SECTION 6 ELECTRICAL SYSTEMS 3. When returning the generator to the travel *Typical view of breaker panel. Actual breaker labels may vary according to appliance and equipment options. position, be sure the latch mechanism locks Fuses and breakers are labeled on panel. properly and be sure to reinsert the travel pin into the slide rail frame.

  • Page 83: Battery Information

    SECTION 6 ELECTRICAL SYSTEMS The indicator light will glow when the solar panel is charging the coach batteries. The greater the rate of charge, the brighter the light. When the batteries reach full charge, the light will gradually dim, then darken. NOTE: The solar battery charger is not intended to make the coach battery system “main- tenance free.”...

  • Page 84: Battery Storage And Maintenance

    SECTION 6 ELECTRICAL SYSTEMS NOTE: Make sure vent caps are on securely to prevent baking soda solution from enter- ing the battery and contaminating the BATTERY STORAGE AND electrolyte fluid. MAINTENANCE WARNING Lead -acid type batteries are electro-chemical devices for storing and releasing electrical charge.

  • Page 85: Trailer Wiring Connector

    SECTION 6 ELECTRICAL SYSTEMS package provided to you by your dealer when you took delivery of the vehicle. WARNING The diagram below shows proper connection of trailer or tow vehicle wiring to the coach light To prevent wiring damage, it is system.

  • Page 87: Section 7: Plumbing Systems

    SECTION 7 PLUMBING SYSTEMS FRESH WATER SYSTEM Fresh Water Tank..99 gal. The fresh water system provides water to the galley sink, shower, bathroom lavatory, toilet and water heater. Water may be supplied by either of two sources: - a water tank located within the motor home, - any external water source to which the motor home may be connected, known as “city water”.

  • Page 88: Water Pump

    SECTION 7 PLUMBING SYSTEMS Press cover in firmly and twist WATER PUMP counter-clockwise to remove Pressure for the water system is supplied by a water system demand pump which is fully auto- matic after initial priming. When a faucet is opened, the pump begins operation to provide a constant flow from the tank.

  • Page 89: Accumulator Tank

    SECTION 7 PLUMBING SYSTEMS Initial Start-Up 1. Make sure that all water drain valves are closed, including water heater valve. (Refer to Section 10.) 2. Turn water pump switch to “OFF” position. 3. Fill water tank. 4. Open all faucets, hot and cold. 5.

  • Page 90: External Water Supply

    SECTION 7 PLUMBING SYSTEMS INSTRUCTIONS FOR DISINFECTION OF FRESH WATER SYSTEMS ON RECREATION EXTERNAL WATER VEHICLES SUPPLY (“City Water”) (As approved by the U.S. Public Health Service) To connect to an external source: To assure complete disinfection of your fresh 1.

  • Page 91: Water Purifier (Filter) System

    SECTION 7 PLUMBING SYSTEMS To disconnect from the external source: Replacing the water filter cartridge: 1. Turn the external source off. Replace the filter cartridge when water flow from 2. Open a faucet inside the vehicle to relieve the purifier faucet is too slow for convenience. line pressure.

  • Page 92: Exterior Shower

    SECTION 7 PLUMBING SYSTEMS CAUTION If items are placed into the shower tub before shower valve vacuum WASTE WATER SYSTEM release is complete, they may become (HOLDING TANKS) wet. The label shown below is attached on or near The drainage system is self-contained and the faucet to explain the operation of the vacuum uses two separate holding tanks to contain the breaker assembly.

  • Page 93: Using On-Site Sewer Hook-Ups

    SECTION 7 PLUMBING SYSTEMS 2. Leave black water dump valve open while 1. Pull to drain black tank flushing tank. 2. Pull to drain grey tank 3. Attach a garden hose from a city water hydrant to the Flushing System inlet fitting in the water system compartment.

  • Page 94: Utility Light

    SECTION 7 PLUMBING SYSTEMS in suspension, allowing them to be carried out To Drain Tanks and Water Lines: with the liquids when the dump valve is opened. The water line drain valves are located in the If the valve is left open, the liquids will drain off, water pump compartment on the passenger side leaving solids in the tank.

  • Page 95: Tank Capacities

    SECTION 7 PLUMBING SYSTEMS Water Heater Drain Plug: The water heater drain plug is located on the outside of the coach behind the water heater service panel. Use a socket to remove the plug. Drain Plug Water Tank Drain Valve (pull to open) Shower Line Drain Valve: Water Heater...

  • Page 97: Refrigerator

    SECTION 8 APPLIANCES & INTERIOR FEATURES (See also Safety Precautions, Section 1 of Leveling this manual.) Before operating the refrigerator when the motor home is stationary, place a small level on NOTE: Some items described in this section may the freezer plate and make certain the unit is be optional and, therefore, may not be in level.
  • Page 98 SECTION 8 APPLIANCES & INTERIOR FEATURES contains pressure sensitive touch switches and a indicating the refrigerator is operating on AC digital display. A backlight illuminates the dis- electric. play for 10 seconds whenever any of the control • If 120 volts AC is not available, the refriger- buttons is pressed.
  • Page 99 SECTION 8 APPLIANCES & INTERIOR FEATURES during high humidity conditions. The switch AUTO and MANUAL Modes - Gas Opera- tion Only should be left in the NORMAL OPERATION If the gas does not ignite within 30 seconds, position unless moisture collects around the door. which may occur on initial start-up, the refriger- When storing your RV for the winter, place ator’s gas valve will automatically close and the...
  • Page 100 SECTION 8 APPLIANCES & INTERIOR FEATURES 2. Connect the coach to an external (city water) Shut-Down of Ice Maker To turn the ice maker off, simply raise the source or leave water pump switch on con- shutoff arm (wire). tinuously to provide a constant water supply. 3.
  • Page 101 SECTION 8 APPLIANCES & INTERIOR FEATURES Troubleshooting the Ice Maker 10. Water not freezing: 1. Is 110-Volt AC reaching the refrigerator? A. Refrigerator problem. A. Ice maker motor needs 110VAC to oper- 11. Ice not ejecting: ate. A. 110VAC power not connected. B.

  • Page 102: Lp Gas Cooktop

    SECTION 8 APPLIANCES & INTERIOR FEATURES ventilation when using the gas cooktop. It is especially important not to use the gas cooktop for comfort heating. Danger of asphyxiation is greater when these appliances are used for long periods of time. WARNING Refrigerator Access Compartment Portable fuel-burning equipment...

  • Page 103: Microwave/Convection Oven

    SECTION 8 APPLIANCES & INTERIOR FEATURES At the touch of a button this panel can display the fresh water and holding tank levels, LP gas MICROWAVE/CONVECTION tank level, plus the engine battery and coach bat- tery condition. You can start the auxiliary gener- OVEN ator or turn on the water pump and water heater.
  • Page 104 SECTION 8 APPLIANCES & INTERIOR FEATURES Generator Hourmeter Water Pump Switch See Section 6, Electrical Systems for genera- When you want to use the self-contained tor hourmeter information. water system, turn on the “Water Pump” switch on the monitor panel. The “Pump On” light will illuminate when the pump switch is turned on.

  • Page 105: Dishwasher

    SECTION 8 APPLIANCES & INTERIOR FEATURES DISHWASHER (Optional) For complete operating instructions, see the The washing machine water supply faucets manufacturer’s information provided in your are located inside the lavatory cabinet. Always Owners InfoCase. turn supply faucets off when not using washing machine to avoid possible water leaks if a hose or hose gasket should fail.
  • Page 106 Do not use a phone in your coach. Follow the dealer’s or gas sup- plier’s instructions. • If you cannot reach a Winnebago Industries dealer or a local gas supplier, call the fire department. • Have the source of the leak corrected before using the LP gas system again.
  • Page 107 SECTION 8 APPLIANCES & INTERIOR FEATURES 5. Turn on LP gas main tank valve. 6. Turn on the water heater switch on the moni- tor panel. You may hear a clicking noise as the ignition element begins working. If the burner does not light on first try, the system will stop trying to light burner and go to lockout mode.

  • Page 108: Water Heater By-Pass Valve

    SECTION 8 APPLIANCES & INTERIOR FEATURES To Replace the Air Pocket: 1. Turn off the water heater switch and incom- ing water supply (city water and/or demand pump). 2. Open a faucet in the motor home to relieve water pressure. 3.

  • Page 109: Electronic Thermostat

    SECTION 8 APPLIANCES & INTERIOR FEATURES To Shut Down: 1. Slide thermostat/system switch OFF. 2. Close LP tank valve. For Further Information Please see the Suburban furnace operating instructions provided in your Owners InfoCase for further information, including operating pre- cautions, and periodic maintenance.
  • Page 110 SECTION 8 APPLIANCES & INTERIOR FEATURES ously at high speed. To Operate the Heat Pump: Auto/Low: Fan runs at low speed and cycles • Slide the thermostat switch to electric heat on and off with the A/C compressor as con- mode.
  • Page 111 SECTION 8 APPLIANCES & INTERIOR FEATURES Have you checked your air filter lately? Closed or blocked vents and a dirty air filter can hinder the efficiency of a heat pump. See Air Conditioner Filter for location and instructions. • Be sure ceiling vents are open to distribute heat pump output air.

  • Page 112: Tv Antenna

    SECTION 8 APPLIANCES & INTERIOR FEATURES Air Conditioner Filter (Coach models 38K & Further Information See the air conditioner manufacturer’s operat- 40J) ing instructions supplied in your Owners Info- A disposable furnace type filter is located in Case. They contain detailed operating the floor beneath the passenger side bedroom instructions, special precautions and basic trou- night stand.

  • Page 113: Antenna Signal Amplifier

    SECTION 8 APPLIANCES & INTERIOR FEATURES Rotating Antenna - Make sure antenna is in the “UP” position. Pull down on rotating knob until it disengages ceiling plate and rotate for best ANTENNA SIGNAL AMPLIFIER picture and sound on TV set. The TV Signal Amplifier switch is located on the left end of the Video Selector System panel as shown.

  • Page 114: Digital Satellite Television System

    SECTION 8 APPLIANCES & INTERIOR FEATURES DIGITAL SATELLITE TELEVISION SYSTEM - Optional The Digital Satellite Television System allows you to receive TV programs directly from satellite to your coach. The programs are trans- mitted in digital format so the quality is equal to laser disc or CD.

  • Page 115: Exterior Entertainment Center

    SECTION 8 APPLIANCES & INTERIOR FEATURES Signal Inputs: ANT - Press to connect selected TV or VCR to the roof antenna. AUX - Press to connect selected TV or VCR to cable TV input or Satellite TV system. VCR - Press to connect selected TV to the video- cassette recorder/player.

  • Page 116: Central Vacuum Cleaner

    SECTION 8 APPLIANCES & INTERIOR FEATURES Storage Compartment Vacuum: For conve- Rear Phone Jack: In the bedroom, near the nient cleaning of exterior storage compartments radio on the nightstand. an additional vacuum hose outlet is located in a middle compartment on the passenger side of the coach.

  • Page 117: Bedroom Radio

    SECTION 8 APPLIANCES & INTERIOR FEATURES If The Vacuum Will Not Start: Check for a tripped circuit breaker. Also be sure that the vac- uum unit is plugged into the electrical outlet. BEDROOM RADIO The bedroom is equipped with a built-in stereo radio system in the left rear nightstand cab- inet.

  • Page 118: Sleeping Facilities

    SECTION 8 APPLIANCES & INTERIOR FEATURES WARNING Be sure all loose items are secured or stored properly while the vehicle is in motion. Possible overlooked items such as canned goods or small appli- ances on the countertop, cooking pans on the range, or free-standing furniture items can become danger- ous projectiles during a sudden stop.
  • Page 119 SECTION 8 APPLIANCES & INTERIOR FEATURES evaluate your comfort level after each If You Already Know Your Sleep Number If you know what your Sleep Number is, change. Once you have found a Sleep Number setting where you feel comfort- enter it on the remote by pressing the firmer or able, log this number into your Sleep softer buttons until your sleep number is dis-...
  • Page 120 SECTION 8 APPLIANCES & INTERIOR FEATURES Evaluate Your Comfort Level on the bed, change in sleeping position, heat from an electric blanket, change in room temper- Right ature, or weather. • Neck and back are aligned in the same posi- However, if you notice that your bed is get- tion as when you are upright ting softer night after night and your Sleep num-...

  • Page 121: Rest Easy Multi-Position Lounge

    SECTION 8 APPLIANCES & INTERIOR FEATURES CAUTION Do not recline the lounge completely flat unless the footrest trundle section is extended. Do not occupy the Rest Easy Multi-Position Lounge lounge when elevating the seatback from the flat position to upright lounge position.

  • Page 122: Banquette Sofa

    SECTION 8 APPLIANCES & INTERIOR FEATURES WARNING To avoid injury to young children, do not allow them to operate the lounge, or to play within the lounge or near the operating mechanism. BANQUETTE SOFA (if equipped) Tip for “power uses”: If you have the footrest section positioned against the seat cushion, it will move out with the lounge when you press the recline switch.

  • Page 123: Fresh Water Toilet

    SECTION 8 APPLIANCES & INTERIOR FEATURES 2. To flush the toilet, push the lever all the way down until sewage leaves the toilet and bowl is rinsed clean. 3. Release the flush lever. A small amount of water should remain in the bowl. Please refer to the manufacturer’s informa- tion supplied with the toilet for further operating and maintenance instructions.

  • Page 124: Power Roof Vent

    SECTION 8 APPLIANCES & INTERIOR FEATURES See instructions in Section 10 to prepare the toilet for storage in freezing conditions. POWER ROOF VENT - Bath Area The power vent in the bathroom ceiling is controlled by a switch on the bathroom wall. The switch raises (open) or lowers (close) the pow- ered dome.

  • Page 125: Slider Windows

    SECTION 8 APPLIANCES & INTERIOR FEATURES CRANK-OUT SIDE WINDOWS Turn the crank-out knob clockwise to open window; counterclockwise to close. Do not use excessive force on the knob to open or lock into closed position. This could cause permanent damage to the crank mechanism. When closing the window, crank the window in snugly, then back off 1/4 turn to help avoid glass warping which can result in wind noise.

  • Page 127: Roof

    Appropri- to-roof seams, etc., should also receive immedi- ate compounds are sold at Winnebago and Itasca ate attention. Delaying these repairs may allow dealers, and the materials are quickly and easily water leakage and result in damage to interior applied.

  • Page 128: Care Of Stripes And Decals

    Apply powdered graphite lubricant to com- gelcoat’s gloss and color and prevent stains. It is partment door latches periodically as necessary best to let your Winnebago Industries RV dealer to keep latches operating smoothly. evaluate the situation before using an automotive If rubber door seals should become sticky, polishing compound.
  • Page 129 SECTION 9 CARE & MAINTENANCE Some stains or soils, such as lipstick, ink, Carpets See the carpet manufacturer’s Carpet Care grease or mustard, are extremely difficult or im- Guide in your Owners InfoCase. It includes possible to remove completely and should re- detailed information on cleaning soils and ceive immediate attention.
  • Page 130 SECTION 9 CARE & MAINTENANCE Most commercially available carpet and up- NOTE: In many cases listed above, repeated steps may be required to fully extract the holstery cleaners will do an excellent job remov- contaminant from the material. Use sol- ing stains.
  • Page 131 SECTION 9 CARE & MAINTENANCE NOTE: In many cases listed above, repeated NOTE: Cabinetry and furniture items through- steps may be required to fully extract out this motor home are constructed ei- contaminant from material. Items listed ther partially or completely of real above with (*) may also be removed hardwoods.

  • Page 132: Vinyl Wallboard

    SECTION 9 CARE & MAINTENANCE removing ice from the mirrors to protect the re- VINYL WALLBOARD flective surfaces. Decorative vinyl covered wallboards may be Door locks and hinges should be lubricated cleaned with a mild soap and water solution. Do periodically with powdered graphite to ensure not use solvents or abrasive cleaning products.
  • Page 133 SECTION 9 CARE & MAINTENANCE Transmission Fluid Engine Oil Dipstick Dipstick Hydraulic Fluid Tank FUEL FILTER/WATER SEPARATOR Diesel fuel often contains small quantities of water which can damage the engine if not filtered out. The fuel filter traps this water and prevents it from reaching the engine.

  • Page 134: Engine Cooling System

    SECTION 9 CARE & MAINTENANCE canister until clean diesel fuel flows from the valve. Close valve by hand. Do not over tighten. Engine Coolant Tank Fuel/Water Drain Valve Dispose of the drained liquid in an environ- mentally responsible manner, such as taking to a CAUTION waste oil disposal center.

  • Page 135: Suspension Alignment And Tire Balance

    SECTION 9 CARE & MAINTENANCE mendations, precautions and replacement infor- SUSPENSION ALIGNMENT mation on washers and wipers. AND TIRE BALANCE The windshield washer fluid reservoir is locat- ed in the front of the coach at the right hand side The front suspension and steering system of behind the ‘hood’...

  • Page 136: Automotive 12-Volt Fuses And Circuit Breakers

    SECTION 9 CARE & MAINTENANCE dition is apparent. Refer to your chassis operating guide for further information. AUTOMOTIVE 12-VOLT FUSES AND CIRCUIT BREAKERS The automotive fuses and breaker are conve- niently located on the automotive fuse/breaker panel in the driver side front cargo compartment as shown below.

  • Page 137: Section 10: Storing Your Motor Home

    SECTION 10 STORING YOUR MOTOR HOME 2. Level the motor home and drain the entire PREPARING VEHICLE FOR plumbing system as described in the follow- STORAGE ing steps. 3. Then turn on Wash Station Shower Head and Properly preparing your vehicle for storage lay shower head on ground to drain any will lessen the possibility of damage to your water left in shower line.
  • Page 138 SECTION 10 STORING YOUR MOTOR HOME NOTE: If your coach is equipped with the refrig- NOTE: Before using again the following erator ice maker option, the ice maker spring: water lines must also be drained. See “Winterizing the Ice Maker” on page •...
  • Page 139 (A “blow-out” plug can sink drain and shower drain. This prevents be purchased at any Winnebago or Itasca any holding tank odors from entering the dealer. P/N 701705-01-000.) coach during storage.

  • Page 140: Rv Antifreeze Water Line Winterization Systems

    SECTION 10 STORING YOUR MOTOR HOME stores. Follow directions on the con- 24. Wash and wax the coach. tainer to determine the correct 25. Inspect all seams and seals around doors, amount to use for your coach. windows, vents, and any other joints. Replace or repair any that are damaged.

  • Page 141: Washer/Dryer Winterizing

    SECTION 10 STORING YOUR MOTOR HOME When Done Adding RV Antifreeze: • Turn water pump switch off. • Turn the diverter valve handle so it points toward the water line to the pump as shown in the photo. This will to stop the flow from the siphon tube and revert the tank line flow to the pump.

  • Page 142: Removal From Storage

    SECTION 10 STORING YOUR MOTOR HOME 2-6 above) to remove and rinse the RV 13. Replace batteries if necessary and check out antifreeze from the machine. electrical system to make sure all lights and electrical components operate. To Winterize the Fresh Water Hose 14.
  • Page 143 INDEX 110-Volt AC System........6- 1 Compartment Doors........9- 2 110-Volt Circuit Breakers......6- 4 Condenser Coils.......... 8- 16 110-Volt Receptacles ........6- 6 Connecting a Battery Charger....... 3- 3 12-Volt Chassis Circuit Breakers ....6- 10 Connecting Jumper Cables ......3- 2 12-Volt DC System........

  • Page 144: Preparing Vehicle For Storage

    INDEX Fuel Filter/Water Separator......9- 7 Maximum Occupancy........4- 2 Fuel Selection ..........2- 2 Microwave Convection Oven ....... 8- 7 Mountain Driving ......... 4- 6 Gas/Electric Water Heater ......8- 9 Gelcoat Fiberglass Finish, Care of....9- 1 Nighttime Driving......... 4- 6 General Warnings .........
  • Page 145 INDEX Shower Hose Vacuum Breaker..... 7- 5 Water Pump Switch ........8- 8 Signal Lever/Headlight Hi/Lo Beam .... 2- 5 Water Pump ..........7- 2 Sleep Number Bed ........8- 22 Water Purifier (Filter) System ...... 7- 5 Sleeping Facilities........8- 22 Water Stains..........
  • Page 147 IMPORTANT SERIAL NUMBERS Motor Home (Coach): Year _________ Model ___________________ Serial _____________ Chassis: Make ___________________ Serial (VIN) ______________ Roof Air Conditioner: Brand ___________ Model ____________ Serial _ ___________ Furnace: Brand ___________ Model ____________ Serial _ ___________ Water Heater: Brand ___________ Model ____________ Serial _ ___________ Power Converter: Brand ___________ Model ____________ Serial _ ___________ 110-Volt Generator:...
  • Page 148 MAINTENANCE RECORD Odometer Date Mileage Description of Service Cost...
  • Page 149 FUEL & OIL RECORD Odometer Fuel Odometer Fuel Date Mileage Gal. Qts. Cost Date Mileage Gals. Qts. Cost...
  • Page 150 FUEL & OIL RECORD Odometer Fuel Odometer Fuel Date Mileage Gal. Qts. Cost Date Mileage Gals. Qts. Cost...

Table of Contents