Toro 20371 Operator's Manual

22in recycler lawn mower
Hide thumbs Also See for 20371:

Advertisement

22in Recycler
Model No. 20370—Serial No. 313000001 and Up
Model No. 20371—Serial No. 313000001 and Up
Model No. 20377—Serial No. 313000001 and Up
Model No. 20378—Serial No. 313000001 and Up
Replacement parts are available from an Authorized Service Dealer or at www.shoptoro.com.

Introduction

Read this information carefully to learn how to operate and
maintain your product properly and to avoid injury and
product damage. You are responsible for operating the
product properly and safely.
You may contact Toro directly at www.Toro.com for product
and accessory information, help finding a dealer, or to register
your product.
Whenever you need service, genuine Toro parts, or additional
information, contact an Authorized Service Dealer or Toro
Customer Service and have the model and serial numbers of
your product ready. Figure 1 identifies the location of the
model and serial numbers on the product.
1. Model and serial number plate
Write the product model and serial numbers in the space
below:
Model No.
Serial No.
This manual identifies potential hazards and has safety
messages identified by the safety alert symbol (Figure 2),
which signals a hazard that may cause serious injury or death
if you do not follow the recommended precautions.
© 2012—The Toro® Company
8111 Lyndale Avenue South
Bloomington, MN 55420
®
G017301
Figure 1
Register at www.Toro.com.
Lawn Mower
1. Safety alert symbol
This manual uses 2 words to highlight information.
Important calls attention to special mechanical information
and Note emphasizes general information worthy of special
attention.
The engine exhaust from this product
contains chemicals known to the State of
California to cause cancer, birth defects,
or other reproductive harm.
Important: This engine is not equipped with a spark
arrester muffler. It is a violation of California Public
Resource Code Section 4442 to use or operate the engine
on any forest-covered, brush-covered, or grass-covered
land. Other states or federal areas may have similar laws.
This spark ignition system complies with Canadian ICES-002.
The enclosed Engine Owner's Manual is supplied for
information regarding the US Environmental Protection
Agency (EPA) and the California Emission Control
Regulation of emission systems, maintenance, and
warranty. Replacements may be ordered through the
engine manufacturer.
For models with stated engine horsepower, the gross
horsepower of the engine was laboratory rated by the engine
manufacturer in accordance with SAE J1940. As configured
to meet safety, emission, and operating requirements, the
actual engine horsepower on this class of lawn mower will
be significantly lower.
Form No. 3375-431 Rev A
Operator's Manual
Figure 2
WARNING
CALIFORNIA
Proposition 65 Warning
Original Instructions (EN)
All Rights Reserved *3375-431* A
Printed in the USA

Advertisement

Table of Contents
loading

Summary of Contents for Toro 20371

  • Page 1: Introduction

    You are responsible for operating the product properly and safely. This manual uses 2 words to highlight information. You may contact Toro directly at www.Toro.com for product Important calls attention to special mechanical information and accessory information, help finding a dealer, or to register and Note emphasizes general information worthy of special your product.
  • Page 2: Table Of Contents

    Contents This cutting machine can amputate hands and feet and throw objects. Failure to observe the following safety instructions could result in serious injury or death. Introduction ..............1 General Operation ..........2 General Operation Slope Operation ............2 Children..............3 •...
  • Page 3: Children

    • • Mow across the face of slopes; never up and down. If fuel is spilled on clothing, change clothing immediately. Exercise extreme caution when changing direction on • Never overfill fuel tank. Replace gas cap and tighten slopes. securely. •...
  • Page 4: Safety And Instructional Decals

    Safety and Instructional Decals Important: Safety and instruction decals are located near areas of potential danger. Replace damaged decals. Setup Important: Remove and discard the protective plastic sheet that covers the engine. Manufacturer's Mark 1. Indicates the blade is identified as a part from the original machine manufacturer.
  • Page 5: Installing The Recoil-Starter Rope In The Rope Guide

    Installing the Recoil-starter Filling the Engine with Oil Rope in the Rope Guide No Parts Required No Parts Required Procedure Procedure Your machine does not come with oil in the engine. 1. Remove the dipstick (Figure 5). Important: To start the engine safely and easily whenever you use the machine, install the recoil-starter rope in the rope guide.
  • Page 6: Product Overview

    Product Overview Operation Filling the Fuel Tank DANGER Gasoline is extremely flammable and explosive. A fire or explosion from gasoline can burn you and others. • To prevent a static charge from igniting the gasoline, place the container and/or machine directly on the ground before filling, not in a vehicle or on an object.
  • Page 7: Checking The Engine Oil Level

    Checking the Engine Oil Level Service Interval: Before each use or daily 1. Remove the dipstick, wipe it clean, and insert it into the oil filler neck, but do not screw it in (Figure 9). G017319 Figure 10 1. Raise the machine 2.
  • Page 8: Using The Self-Propel Drive

    Check the grass bag frequently. If it is damaged, install a new Toro replacement bag.
  • Page 9: Side-Discharging The Clippings

    Side-discharging the Clippings Use the side discharge for cutting very tall grass. If the bag is on the machine, remove it before side-discharging the clippings. WARNING The blade is sharp; contacting the blade can result in serious personal injury. Stop the engine and wait for all moving parts to stop before leaving the operating position.
  • Page 10: Operating Tips

    For best performance, install a new blade before the cut the leaves finely enough. cutting season begins. • Replace the blade when necessary with a Toro replacement blade. Cutting Grass • Cut only about a third of the grass blade at a time. Do not...
  • Page 11: Maintenance

    • Refer to your engine operator's manual for any additional yearly maintenance procedures. Important: Refer to your engine operator's manual for additional maintenance procedures. Note: Replacement parts are available from an Authorized Service Dealer (go to www.toro.com to find the nearest dealer) or at www.shoptoro.com. Preparing for Maintenance the machine prior to running out of fuel, use a hand fuel pump to remove the fuel.
  • Page 12: Servicing The Air Cleaner

    Servicing the Air Cleaner 2. Tip the machine onto its side, with the air filter up, then remove the dipstick to drain the used oil out through Service Interval: Every 25 hours/Yearly (whichever comes the oil-fill tube (Figure 17). first)—Check the air cleaner for dirty, loose, or damaged parts, and clean or replace them if necessary.
  • Page 13: Replacing The Blade

    Replacing the Blade Service Interval: Yearly Important: You will need a torque wrench to install the blade properly . If you do not have a torque wrench or are uncomfortable performing this procedure, contact an Authorized Service Dealer. Examine the blade whenever you run out of gasoline. If the blade is damaged or cracked, replace it immediately.
  • Page 14: Cleaning Under The Machine

    3. Wash out the area under the rear deflector where the clippings go from the housing to the grass bag. Note: Wash out the area with the bag-on-demand in both the fully forward and fully rearward positions. 4. Attach a garden hose that is connected to a water supply to the washout port on the machine housing (Figure 23).
  • Page 15: Storage

    Storage 2. Fold the upper handle forward as shown in Figure 24. Important: Route the cables to the outside of the Store the machine in a cool, clean, dry place. handle knobs as you fold the handle. Preparing the Machine for Storage WARNING Gasoline vapors can explode.
  • Page 16: The Toro Total Coverage Guarantee

    Countries Other than the United States or Canada Customers who have purchased Toro products exported from the United States or Canada should contact their Toro Distributor (Dealer) to obtain guarantee policies for your country, province, or state. If for any reason you are dissatisfied with your Distributor's service or have difficulty obtaining guarantee information, contact the Toro importer.

This manual is also suitable for:

203702037820377

Table of Contents