Weber Genesis Silver B Owner's Manual

Hide thumbs Also See for Genesis Silver B:

Advertisement

Owners Guide
DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. Open lid
4. If odor continues, keep away from the
appliance and immediately call your
gas supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death, or damage to property.
WARNING
Do not store or use gasoline or other
flammable liquids or vapors within 25 feet
(8m) of this appliance.
WARNING: Follow all leak-check
procedures carefully in this manual prior
to barbecue operation. Do this even if the
barbecue was dealer-assembled.
NOTICE TO INSTALLER: These
instructions must be left with the owner
and the owner should keep them for future
use.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
WARNING: Do not try to light this
appliance without reading the "Lighting"
Instructions section of this manual
®
®
Y
OU MUST READ THIS
BEFORE OPERATING YOUR GAS GRILL
A039.f
B004.d
C002.c
D001.e
Natural Gas
O
G
WNERS
UIDE
55144
05/03/01

Advertisement

Table of Contents
loading

Summary of Contents for Weber Genesis Silver B

  • Page 1 Owners Guide DANGER If you smell gas: Natural Gas 1. Shut off gas to the appliance. 2. Extinguish any open flames. 3. Open lid 4. If odor continues, keep away from the appliance and immediately call your gas supplier or your fire department. ®...
  • Page 2: Warranty

    Improper assembly may be dangerous. Please carefully follow the assembly instructions in this manual. After a period of storage, and/or nonuse, the Weber Gas Barbecue should be checked for gas leaks and burner obstructions before use. See instructions in this manual for correct procedures.
  • Page 3 If you are required to return defective parts, transportation charges must be prepaid. Weber will return parts to the purchaser, freight or postage prepaid. This Limited Warranty does not cover any failures or...
  • Page 4: Table Of Contents

    Contents Danger & Warnings ........ A-2 Warranty ..........A-3 General Instructions ....... A-5 Exploded View ........A-6 Parts List ..........A-9 Assembly Instructions ......B-1 Installing Features ........C-1 Cast Iron Cooking Grate Care Instructions ........C-D Operating ..........D-1 Lighting ...........
  • Page 5: General Instructions

    • The gas must be turned OFF at the natural gas Your Weber Gas Barbecue is a portable outdoor supply when the Weber Gas Barbecue is not in cooking appliance. With the Weber Gas Barbecue you use. can grill, barbecue, roast and bake with results that are •...
  • Page 6 Genesis Silver-B NG 011901...
  • Page 7 Hinge Pin Hair Pin Cotter Left Endcap Thermometer Shroud Right Endcap Handle Burner Control Knobs Warm-Up Basket Control Panel Warming Rack Ignitor Button Cooking Grates Control Panel Hardware Flavorizer Bars Crossover tube Cooking Box Front and Back Burners 1/4-20 keps nut Center Burner Slide Out Bottom Tray Manifold Hardware...
  • Page 8 ® of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL, 60067-6266, U.S.A. This product is covered by one or more United States patents and patents in other nations globally. Printed in the U.S.A.
  • Page 9 Screwdriver Left Frame - 1 Phillips screwdriver Hammer Right Frame -1 7/16 open-end or an adjustable wrench Wheel Frame - 1 Pliers Caster Frame - 1 Block of wood Lid -1 Frame Connectors - 2 Left Trim Piece - 1 Right Trim Piece - 1 Cooking Box - 1 Work Surface - 1...
  • Page 10 Warming Rack - 1 Burner Control Knobs - 3 Hinge Pins (1/4 x 1 1/2 inch clevis pin) - 2 Warm-Up Basket - 1 2 inch bolts (1/4 x 20 x 2 inch bolts) - 5 Flavorizer Bars - 5 1/2 inch bolts (1/4 x 20 x 1/2 inch bolts) - 8 Wrap-Around Trim Piece - 1 Keps Nut (1/4 x 20 Keps Nut) - 1...
  • Page 11: Assembly Instructions

    Tap one hubcap onto the end Note - Work on carpeted area (on grass or one of the of the axle rod. Slide one wheel onto the axle, WEBER boxes) to protect the finish during frame assembly.
  • Page 12 Continue frame assembly Complete frame assembly You will need: caster frame, wheel frame, four 1/2 inch You will need: partial frame assembly, two frame bolts, four nylon washers and a 7/16 inch or adjustable connectors, four 2 inch bolts, four nylon wrench.
  • Page 13 Insert casters Add Wrap-around Frame Panel You will need: frame assembly and two casters. You will need: wrap around frame panel and a wrench. Push the casters firmly into the inserts in the ends of Place wrap-around frame panel in place: the caster frame.
  • Page 14 Add cooking box (assembly) Your Weber Gas Grill Manifold assembly consisting of You will need: frame assembly, cooking box gas manifold, valves and gas burners has been factory (assembly), 2 inch bolt, nylon washer, keps nut, pliers assembled, pressure- and flame- tested. As a safety and a 7/16 inch or adjustable wrench.
  • Page 15 Install manifold brackets Install igniter The manifold brackets(2) are already in place on the Note - The igniter wires are already attached to the manifold between the valves. Gas Catcher Ignition Chamber and the igniter. This Place your hand underneath the manifold. Lift the was done to factory test the ignition system.
  • Page 16 Install Gas Supply Gas Line Piping I If the length of the line required does not exceed 50 General Specifications for Piping Note - Contact your local municipality for building feet, use a 5/8" O.D. tube. One size larger should be codes regulating outdoor gas barbecue used for lengths greater than 50 feet.
  • Page 17 Check that all burner valves are off Connect flexible hose to manifold You will need: burner control knobs. You will need: the 12 foot natural supply hose and a 3/ Valves are shipped in the OFF position, but you should 4 inch wrench.
  • Page 18 Representative in your region using the contact you should recheck all fittings for leaks before using information sheet provided with your manual. your Weber Gas Barbecue. Shipping and handling may When leak checks are complete, turn gas supply OFF loosen or damage a gas fitting.
  • Page 19 Install the slide out bottom tray Slide the bottom tray onto the mounting rails under the You will need: the slide out bottom tray(1), catch pan cooking box with finger grip toward you(1). holder(2), catch pan and one disposable drip pan. WARNING: Do not line bottom tray with aluminum foil.
  • Page 20 Install Lid Install control panel and burner control knobs You will need: lid, two hair pin cotters(1) and two hinge You will need: control panel, two Phillips screws/ pins(2). washers, a Phillips screwdriver, and burner control Place lid on top of the cooking box. Align the hinges at knobs.
  • Page 21: Installing Features

    Installing Features Install the right trim piece with tool holders 2.) Slide the swing-up work surface rod through the You will need: Right trim piece with tool holders holes at the top of the swing-up work surface. Push the Right trim piece into the frame as shown(1), making sure that the tabs on the underside of the trim piece are snapped into the slots in the frame.(2) 3.) Insert one end of the swing-up work surface rod...
  • Page 22 4.) While holding swing-up work surface in position, To raise swing-up work surface: Lift table all the way insert the other end of the swing-up work surface up and slide it to the right, then lower table until you rod into the left end trim piece. Push the trim piece feel it lock in the up position.
  • Page 23 You will need: Warm-Up Basket You will need: Bottom shelf. Insert one end of the Weber Warm-Up Basket into the Set the bottom shelf in place between the two frame hole at the right side of the inside of the lid, and the connectors underneath the cooking box.
  • Page 24: Cast Iron Cooking Grate Care Instructions

    Cast Iron Cooking Grates Care Instructions WARNING: Follow all safety instructions provided with your barbecue. Do not drop cast iron grates, they will break. First Time Use - Wash thoroughly with a mild dishwashing liquid to remove the wax coating used for protection in shipping.
  • Page 25: Operating

    7) After the FRONT burner is lit you can turn on the the hose is found to be damaged in any way, do other burner or burners. not use the barbecue. Replace using only Weber Note - Always light the FRONT burner first. The other authorized replacement hose. Contact the burner or burners ignite from the FRONT burner.
  • Page 26: Manual Lighting

    WARNING: If the burner does not light, turn the Manual Lighting Front burner control knob to OFF and wait 5 DANGER minutes to let the gas clear before you try again or try to light with a match. Failure to open lid while igniting the 7) After the FRONT burner is lit you can turn on the barbecue’s burners, or not waiting 5 other burner or burners.
  • Page 27: Cooking

    CAUTION: Do not clean your Flavorizer® Bars or desired. The control settings: High (H), Medium (M), cooking grates in a self-cleaning oven. Low (L), or Off (O) are described in your Weber For availability of replacement cooking grates and cookbook. The cookbook uses these notations to...
  • Page 28: Annual Maintenance

    The burners have been flame tested. As a safety precaution however, you should recheck all fittings for leaks before using your Weber Gas Barbecue. Shipping and handling may have loosened or damaged a gas fitting. WARNING: Perform these leak checks even if your barbecue was dealer- or store-assembled.
  • Page 29: General Maintenance

    The Weber Gas Barbecue burners have been factory Weber Spider /Insect screens set for the correct air and gas mixture. The correct Your Weber Gas Barbecue, as well as any outdoor gas flame pattern is shown. appliance, is a target for spiders and other insects.
  • Page 30: Replacing Main Burners

    Replacing Main Burners CAUTION: The burner openings(1) must be positioned properly over the valve orifices(2). 1) Your Weber Gas Barbecue must be OFF and cool. Check proper assembly before fastening manifold in 2) Turn gas OFF at source. place. 3) To remove control panel: take off the burner control knobs.
  • Page 31: Crossover Ignition System Operations

    Crossover® Ignition System Operations If the Crossover Ignition System fails to ignite the Left burner, light the Left burner with a match. If the Left burner lights with a match, then check the Crossover Ignition System. Check that both the white(1) and black(2) ignition wires are attached properly.
  • Page 32: Troubleshooting

    Troubleshooting Problem Check Cure Clean Weber Spider/Insect Screens. Burners burn with a yellow or Inspect Weber Spider/Insect orange flame, in conjunction with Screens for possible obstructions. (See Section “Annual Maintenance”) the smell of gas. (Blockage of holes.) Straighten fuel hose.
  • Page 33 Your Weber Gas Barbecue, as well as any outdoor gas openings. appliance, is a target for spiders and other insects. They can nest in the venturi section (Venturi(1), air shutter(2), venturi fin(3) ) of the burner tubes.
  • Page 34 8) To reinstall the burners, reverse 3) through 7). Replacing Main Burners CAUTION: The burner openings(1) must be 1) Your Weber Gas Barbecue must be OFF and cool. positioned properly over the valve orifices(2). 2) Turn gas OFF at source.

Table of Contents