Motorola GM Series Service Manual

Motorola GM Series Service Manual

Gm series professional radio
Hide thumbs Also See for GM Series:

Advertisement

Professional Radio
GM Series
Detailed Service Manual
6864115B62-B

Advertisement

Table of Contents
loading

Summary of Contents for Motorola GM Series

  • Page 1 Professional Radio GM Series Detailed Service Manual 6864115B62-B...
  • Page 3 Professional Radio GM Series Detailed Service Manual 6864115B62-B Contents Section 1 Service Maintainability Section 2 Controlhead Service Information Section 3 Controller Service Information Section 4 VHF Service Information Section 5 UHF Service Information Section 6 Lowband Service Information WLS EMEA Publications Department, Jays Close, Viables Industrial Estate, Basingstoke, Hampshire, RG22 4PD, UK.
  • Page 5 Professional Radio GM Series Service Maintainability Issue: August 2002...
  • Page 6: Computer Software Copyrights

    Accordingly, any copyrighted Motorola computer programs contained in the Motorola products described in this manual may not be copied or reproduced in any manner without the express written permission of Motorola. Furthermore, the purchase of Motorola...
  • Page 7: Table Of Contents

    Table of Contents Chapter 1 INTRODUCTION 1.0 Scope of Manual ....................1-1 2.0 Warranty and Service Support................1-1 2.1 Warranty Period and Return Instructions ............1-1 2.2 After Warranty Period ..................1-1 2.3 European Radio Support Centre (ERSC)............1-2 2.4 Parts Identification and Ordering ..............1-2 2.5 EMEA Test Equipment Support..............1-2 2.6 Technical Support...................1-3 2.7 Related Documents ..................1-3...
  • Page 9: Safety And General Information

    To maintain compliance with FCC RF exposure guidelines, if you wear a radio on your body when transmitting, always place the radio in a Motorola approved clip, holder, holster, case, or body harness for this product. Use of non-Motorola-approved body worn accessories may exceed FCC RF exposure guidelines. If you do not use a...
  • Page 10 ELECTROMAGNETIC INTERFERENCE/COMPATIBILITY NOTE Nearly every electronic device is susceptible to electromagnetic interference (EMI) if inadequately shielded, designed, or alternately configured for electromagnetic compatibility. Facilities To avoid electromagnetic interference and/or compatibility conflicts, turn off your radio in any facility where posted notices instruct you to do so.
  • Page 11: Operational Warnings

    OPERATIONAL WARNINGS For Vehicles With An Air Bag WARNING: Do not place a portable radio in the area over an air bag or in the air bag deployment area. Air bags inflate with great force. If a portable radio is placed in the air bag deployment area and the air bag inflates, the radio product may be propelled with great force and cause serious injury to occupants of vehicle.
  • Page 12: Antenna Installation

    viii Table 1: Table 1 Rated Power and Lateral Distance Radiated Power of Minimum Lateral Vehicle-installed Distance From Mobile Two-way Transmitting 7 to 15 Watts 30 cm (1 Ft) 16 to 50 Watts 60 cm (2 Ft) More than 50 Watts 90 cm (3 Ft) ANTENNA INSTALLATION Mobile Antennas...
  • Page 13: Chapter 1 Introduction

    In instances where the product is covered under a "return for replacement" or "return for repair" warranty, a check of the product should be performed prior to shipping the unit back to Motorola. This is to ensure that the product has been correctly programmed or has not been subjected to damage outside the terms of the warranty.
  • Page 14: European Radio Support Centre (Ersc)

    Online (Extranet). EMEA Test Equipment Support Information related to support and service of Motorola Test Equipment is available via Motorola Online (Extranet), through the Customer Care Organisation of Motorola’s local area representation or by calling the Motorola switchboard in Germany on telephone number: +49 6128 700.
  • Page 15: Technical Support

    Warranty and Service Support Technical Support Motorola Product Services is available to assist the dealer/distributors in resolving any malfunctions which may be encountered. UK/Ireland - Richard Russell France - Lionel Lhermitte Telephone: +44 (0) 1256 488 082 Telephone: +33 1 6929 5722...
  • Page 16: Radio Model Information

    INTRODUCTION Radio Model Information The model number and serial number are located on a label attached to the back of your radio. You can determine the RF output power, frequency band, protocols, and physical packages. The example below shows one mobile radio model number and its specific characteristics. Table 1-1 Radio Model Number (Example: MDM25KHC9AN1AE) Type of Model...
  • Page 17: Chapter 2 Maintenance

    Chapter 2 MAINTENANCE Introduction This chapter of the manual describes: preventive maintenance safe handling of CMOS devices repair procedures and techniques Preventive Maintenance The radios do not require a scheduled preventive maintenance program; however, periodic visual inspection and cleaning is recommended. Inspection Check that the external surfaces of the radio are clean, and that all external controls and switches are functional.
  • Page 18: Safe Handling Of Cmos And Ldmos

    When damaged parts are replaced, identical parts should be used. If the identical replacement component is not locally available, check the parts list for the proper Motorola part number and order the component from the nearest Motorola Communications parts center listed in the “Piece Parts”...
  • Page 19 General Repair Procedures and Techniques Chip Components Use either the RLN4062 Hot-Air Repair Station or the Motorola 0180381B45 Repair Station for chip component replacement. When using the 0180381B45 Repair Station, select the TJ-65 mini- thermojet hand piece. On either unit, adjust the temperature control to 370 °C (700 °F), and adjust the airflow to a minimum setting.
  • Page 20 MAINTENANCE Shields Removing and replacing shields will be done with the R1070 station with the temperature control set to approximately 215°C (415°F) [230°C (445°F) maximum]. To remove the shield: Place the circuit board in the R1070 circuit board holder. Select the proper heat focus head and attach it to the heater chimney. Add solder paste flux around the base of the shield.
  • Page 21: Notes For All Schematics And Circuit Boards

    1. Unless otherwise stated, resistances are in Ohms (k = 1000), and capacitances are in picofarads (pF) or microfarads (µF). 2. DC voltages are measured from point indicated to chassis ground using a Motorola DC multimeter or equivalent. Transmitter measurements should be made with a 1.2 µH choke in series with the voltage probe to prevent circuit loading.
  • Page 22 MAINTENANCE CH ACT Channel Activity Indicator Signal (Fast Squelch) CH KP ID Control Head Keypad ID (Data) Lines CH REQUEST Control Head Request from Control Head *P Clock Signal CNTLVLTG PA Power Control Voltage CNTR AUDIO Audio Lines of the Controller COL x Keypad Matrix Column x Chip Select Line PCIC / FRACN...
  • Page 23 Notes For All Schematics and Circuit Boards IN 5V RF REG Supply Voltage for 5V Regulator in RF Section INT KP COL Internal Keypad Matrix Column Signal INT KP ROW Internal Keypad Matrix Row Signal INT MIC Internal (from Control Head) Microphone Input INT SWB Internal Switched 13.2V Supply Voltage INT SWB+...
  • Page 24 MAINTENANCE RAM CS RAM Ship Select Service Request Line from Option Board REF CS Reference Chip Select (not used) RESET Reset Line ROW x Keypad Matrix Row x RSSI Received Signal Strength Indicator RX ADAPT Flat TX Path Disable during Transmitter Key-up RX AUD RTN Option Board Input / Output of Receiver Audio Path RX FLAT FILTERED AUDIO...
  • Page 25 Notes For All Schematics and Circuit Boards VS MIC Voice Storage Audio Signal into Microphone Path VS RAC Voice Storage Row Address Clock Signal Voltage Super Filtered (5V) VSTBY 5V Supply for *P when the Radio is switched off 4-LAYER CIRCUIT BOARD DETAIL VIEWING COPPER STEPS IN PROPER LAYER SEQUENCE SIDE 1 LAYER 1 (L1)
  • Page 26 2-10 MAINTENANCE...
  • Page 27: Chapter 3 Service Aids

    Table 3-1 lists the service aids recommended for working on the radio. While all of these items are available from Motorola, most are standard workshop equipment items, and any equivalent item capable of the same performance may be substituted for the item listed.
  • Page 28: Test Equipment

    SERVICE AIDS Test Equipment Table 3-2 lists test equipment required to service the radio and other two-way radios. Table 3-2 Recommended Test Equipment Motorola Part Description Characteristics Application Number R2600_NT Comms System Analyzer This monitor will Frequency/deviation (non MPT) substitute for items...

This manual is also suitable for:

Gm100Gm300Gm600Gm1200

Table of Contents