Table of Contents
Advertisement
USA
SERVICE OFFICE
Dometic, LLC
2320 Industrial Parkway
Elkhart, IN 46516
574-294-2511
CANADA
Dometic, LLC
46 Zatonski, Unit 3
Brantford, ON N3T 5L8
CANADA
519-720-9578
For Service Center
Assistance Call:
800-544-4881
INSTALLATION
INSTRUCTIONS
3312127.000
Form No. 3312127.000 10/08
(French 3312128.000)
©2008 Dometic, LLC
LaGrange, IN 46761
641515, 641516, 641535
Roof Top Air Conditioners
Roof-Top Heat Pump
3106615 Air Distribution Box
3109228 Comfort Control Center
This Unit Is Designed For OEM Installation. All Initial
Installations Must Be Approved By Dometic, LLC
This manual must be read and
understood before installation,
adjustment, service, or mainte-
nance is performed. This unit must
be installed by a qualifi ed service
technician. Modification of this
product can be extremely hazard-
ous and could result in personal
injury or property damage.
Important:
These Instructions
must stay with unit.
Owner read carefully.
641515, 641516, 641535, 651515 & 651516 Installation Instructions
MODEL
651515, 651516
used with
Lire et comprendre ce manuel avant
de procéder à l'installation, à des ré-
glages, de l'entretien ou des répara-
tions. L'installation de cet appareil doit
être effectuée par un réparateur quali-
fi é. Toute modifi cation de cet appareil
peut être extrêmement dangereuse et
entraîner des blessures ou dommages
matériels.
641515.301
641515.306
641516.301
641516.306
1
RECORD THIS UNIT INFORMATION FOR
FUTURE REFERENCE:
Model Number
Serial Number
Date Purchased
TM
MODELS
641516.331
651515.306
641535.301
651516.301
641535.306
651516.306
651515.301
651516.331
Advertisement
Table of Contents
Related Manuals for Dometic 641515.301
Summary of Contents for Dometic 641515.301
- Page 1 2320 Industrial Parkway Elkhart, IN 46516 574-294-2511 This Unit Is Designed For OEM Installation. All Initial CANADA Dometic, LLC Installations Must Be Approved By Dometic, LLC 46 Zatonski, Unit 3 Brantford, ON N3T 5L8 CANADA 519-720-9578 For Service Center Assistance Call:...
-
Page 2: Features
641515, 641516, 641535, 651515 & 651516 Installation Instructions SAFETY INSTRUCTIONS GENERAL INFORMATION Product features or specifi cations as described or il- This manual has safety information and instruc- lustrated are subject to change without notice. tions to help users eliminate or reduce the risk This "Air Conditionr"... -
Page 3: Installation Instructions
3. After Location Has Been Selected: tion. a. Check for obstructions in the area where unit 2. Dometic, LLC will not be liable for any damages will be installed. See FIG 1. or injury incurred due to failure in following these FIG. -
Page 4: Roof Preparation
641515, 641516, 641535, 651515 & 651516 Installation Instructions c. Check inside the RV for return air kit obstruc- c. The opening created must be framed to provide tions (i.e. door openings, room dividers, cur- adequate support and prevent air from being tains, ceiling fi... - Page 5 AGS system. Follow AGS kit instructions for installation. FIG. 6 Pin 1 E. Dometic Comfort Control Center™ & Cable Installation RJ-11-6C4P Connector 1. Location a. If the system is to be used WITHOUT a Remote Temperature Sensor, the proper location of the Comfort Control Center™...
-
Page 6: Installing The Unit
641515, 641516, 641535, 651515 & 651516 Installation Instructions 3. Comfort Control Center Installation FIG. 8 a. Carefully remove the base plate from the Comfort Control Center . This may be FRONT accomplished by inserting a small screw- driver under the tab on the bottom edge of the front cover and gently prying. - Page 7 641515, 641516, 641535, 651515 & 651516 Installation Instructions Upper Discharge FIG. 10 Air Duct If bolts are left loose there may not be an ad- equate roof seal or if over tightened, damage Step a Step b may occur to the unit base or ceiling template. Remove At Use As Perforation...
-
Page 8: Air Box Installation
641515, 641516, 641535, 651515 & 651516 Installation Instructions 1. Electronic Control Kit Confi guration Depending on the equipment options installed by the recreational vehicle manufacturer, the ap- This product is equipped with a 3-wire propriate dip switches will need to be switched to (grounded) system for protection against the "ON"... - Page 9 641515, 641516, 641535, 651515 & 651516 Installation Instructions Important: 3. System Checkout Dip switch damage will occur if they are Verify that all features of the installed system work. not set in the proper manner. A ball point pen or similar Check fan speeds, cooling mode, heat pump object that will slip in the switch slot, can damage the mode, furnace (if connected) and heat strip.
-
Page 10: Wiring Diagram
641515, 641516, 641535, 651515 & 651516 Installation Instructions FIG. 18 641515, 641516 & 641535 WIRING DIAGRAM... - Page 11 641515, 641516, 641535, 651515 & 651516 Installation Instructions 651515 & 651516 WIRING DIAGRAM AIR BOX WIRING DIAGRAM...