Sign in today to find solutions:

Forgot your password?

Don't have an account? Sign up

Jenn-Air 720-0163 Care And Use Manual

Jenn-air stainless steel lp gas grill care and use manual.

 
STAINLESS STEEL LP GAS GRILL
MODEL NO.: 720-0163
ITEM NO: 18852
Jenn-Air is a Trademark of the Maytag Corporation and is used under license to Lowe's Companies, Incorporated.
FOR OUTDOOR USE ONLY
PLEASE CONTACT 1-800-554-5799 FOR ASSISTANCE
DO NOT RETURN TO PLACE OF PURCHASE

Summary of Contents

  • Page 1

    STAINLESS STEEL LP GAS GRILL MODEL NO.: 720-0163 ITEM NO: 18852 Jenn-Air is a Trademark of the Maytag Corporation and is used under license to Lowe’s Companies, Incorporated. FOR OUTDOOR USE ONLY PLEASE CONTACT 1-800-554-5799 FOR ASSISTANCE DO NOT RETURN TO PLACE OF PURCHASE...

  • Page 2: Table Of Contents

    TABLE OF CONTENTS SECTION ONE Safety Instructions…………………………… Placement of the Grill ……………………… SECTION TWO Side Burner & Side Shelf Assembly……….. Side Burner Hose Quick-Connect Assembly Side Shelf Handle Assembly & Battery Installation……………………………………... Braking System Operations…………………. Liquid Propane Cylinder Retention System Slide-Out Tray Locking System……………...

  • Page 3: Safety Instructions

    SAFETY INSTRUCTIONS RECOGNIZED SAFETY SYMBOLS, WORDS AND LABELS WARNING WARNING – Hazards or unsafe practices which COULD result in severe personal injury or death. CAUTION CAUTION – Hazards or unsafe practices which COULD result in minor personal injury. WARNING 1. Do not store spare liquid propane cylinders under or near this appliance. 2.

  • Page 4

    SAFETY INSTRUCTIONS WARNING Do not use the grill if the odor of gas is present. Contact customer service at 1-800-554-5799. WARNING When lighting, keep your face and hands as far away from the grill as possible. WARNING If you smell gas: 1.

  • Page 5

    SAFETY INSTRUCTIONS WARNING Do not attempt to light the grill if gas odor is present. Contact customer service at 1-800- 554-5799. When lighting, keep your face and body as far away from the burner as possible. BEFORE LIGHTING Inspect the gas supply hoses prior to turning on the gas.

  • Page 6

    SAFETY INSTRUCTIONS WARNING Do not try lighting this appliance without first reading the “LIGHTING INSTRUCTIONS” section of this manual. TESTED IN ACCORDANCE WITH ANSI Z21.58 LATEST STANDARD and CSA 1.6 LATEST STANDARD FOR OUTDOOR COOKING GAS APPLIANCES. Check your local building codes for the proper method of installation.

  • Page 7: Placement Of The Grill, Safety Instructions

    If the unit is stored indoors, make sure it is cool. Do not use briquettes of any kind in the grill. The 720-0163 liquid propane gas grill is designed for optimum performance without the use of briquettes. Do not place briquettes on the flame tamers, as this will block the vent to the grill burners.

  • Page 8

    SIDE BURNER & SIDE SHELF ASSEMBLY Estimated Assembly Time: Approximately 10 minutes Required Tools: Phillips Screwdriver (not included) 1. Remove both side burner and side shelf from inside grill cart. 2. The screws used to attach the side shelf and side burner are already screwed into the side of the grill cart.

  • Page 9: Side Burner Hose Quick-connect Assembly

    SIDE BURNER HOSE QUICK-CONNECT ASSEMBLY Estimated Assembly Time: Approximately 5 minutes No Tools Required 1. Insert the side burner hose with female sleeve through side panel of cart (Top drawing). 2. Push the sleeve of the female socket back and insert male end of the connector. Release the sleeve.

  • Page 10

    SIDE SHELF HANDLE ASSEMBLY Estimated Assembly Time: Approximately 5-7 minutes Required Tools: Phillips Screwdriver 1. Remove the four side shelf handle screws from the side of the shelf. 2. Align the holes in the side shelf handle with the holes in the side shelf. 3.

  • Page 11: Braking System Operations, Liquid Propane Cylinder Retention System

    BRAKING SYSTEM OPERATIONS LIQUID PROPANE CYLINDER RETENTION SYSTEM 1. Attach the liquid propane gas cylinder to the slide-out tray using the gas cylinder retention screw. Turn the retention screw clockwise to tighten the gas cylinder. Retention Screw Push right to lock. Push left to unlock.

  • Page 12: Slide-out Tray Locking System, Propane Regulator Hook-up

    SLIDE-OUT TRAY LOCKING SYSTEM 1. To lock and unlock the liquid propane gas cylinder tray, press the gas cylinder tray’s top button to lock. Press the side button to unlock. PROPANE REGULATOR HOOK-UP 1. Attach the regulator to the propane cylinder by turning the regulator handle clockwise. 2.

  • Page 13

    This is a liquid propane configured grill. Do not attempt to use a natural gas supply unless the grill has been pre-configured for natural gas use. Total gas consumption (per hour) of the 720-0163 liquid propane gas grill with all burners set on “HI”: Main burners 45,000 BTU/Hr.

  • Page 14: Leak Testing

    LEAK TESTING GENERAL Although gas connections on the grill are leak tested prior to shipment, a complete gas tightness check must be performed at the installation site. Periodically check the whole system for leaks following the procedures listed below. If the smell of gas is detected at anytime, you should immediately check the entire system for leaks.

  • Page 15: Installer Final Check

    INSTALLER FINAL CHECK Specified clearance maintained 24 inches from combustible materials/construction. All internal packaging has been removed. The hose and regulator are properly connected. WARNING 1. Do not store spare liquid propane cylinders under or near this appliance. 2. Never fill the cylinder beyond 80 percent capacity. 3.

  • Page 16

    OPERATING INSTRUCTIONS GENERAL USE OF THE GRILL AND ROTISSERIE Each main burner is rated at 15,000 BTU/Hr. The main grill burners encompass the entire cooking area and are side ported to minimize blockage from falling grease and debris. Above the burners are stainless steel flame tamers.

  • Page 17: Lighting Instructions

    NOTE It is normal for the skewer to flex when larger cuts of meat are being cooked. If the meat scrapes on the cooking grids during any part of the rotation, the cooking grids must be removed. Test this clearance before lighting the grill as the cooking grids become hot when the grill is lit.

  • Page 18: To Match Light The Grill

    TO MATCH LIGHT THE GRILL If the burner will not light after several attempts using the control knobs, the burner may be lit with a match. 1. If you have already attempted to light the burner with the igniter, allow 5 minutes for any accumulated gas to dissipate.

  • Page 19: Lighting Illustrations

    LIGHTING ILLUSTRATIONS MAIN, SIDE & ROTISSERIE BURNER LIGHTING 1. Open the top cover or lid. 2. Push and turn the main, side, or rotisserie burner control knobs to the “HI” setting. Push the control knob until the burner ignites. The burner should ignite within 4 seconds (if burner does not ignite follow match lighting instructions on Page 16).

  • Page 20: Using The Side Burner, Care & Maintenance Of Side Burner

    USING THE SIDE BURNER Inspect the gas supply hose prior to turning on the gas. If there is evidence of cuts, wear or abrasion, it must be replaced prior to use. Do not use the side burner if gas odor is present. WARNING When lighting, always keep your face and body as far away from the burner as possible.

  • Page 21

    CARE & MAINTENANCE OF THE GRILL STAINLESS STEEL Grease specks can gather and bake onto the surfaces of the stainless steel, giving the appearance of rust. For removal, use an abrasive pad with a stainless steel cleaner. GRILL RACK The easiest way to clean the grill is immediately after cooking is completed, and the flames have been turned off.

  • Page 22: Troubleshooting, Warning

    TROUBLESHOOTING WARNING Spiders and insects can nest inside the burners of the grill and disrupt gas flow. This very dangerous condition could cause a fire behind the valve panel, thereby damaging the grill and making it unsafe for operation. Inspect the grill at least twice a year. BEFORE CALLING FOR SERVICE If the grill does not function properly, use the following checklist before contacting your dealer for service.

  • Page 23

    EXPLODED VIEW...

  • Page 24: Parts List

    PARTS LIST Model No. 720-0163 REF# DESCRIPTION Main Lid Heat Indicator Name Plate Heat Insulating spacer Main Lid Handle Assembly Rotisserie Burner Rotisserie Gas Collector Main Bowl Assembly Rotisserie Gas Valve Front Baffle Main Gas Valve Electronic Ignition Main Manifold...

  • Page 25: Grill Cooking Chart, Grill Cooking Chart

    GRILLING HINTS The preparation of meat, whether rare, medium, or well done, is affected to a large degree by the thickness of the cut. The cooking time is affected by the type of meat, the size and shape of the cut, the temperature of the meat when cooking begins, and the degree of preparation desired.

  • Page 26

    FOOD WEIGHT OR THICKNESS MEATS BEEF Hamburgers 1/2 to 3/4 inch Tenderloin, Porterhouse, Rib eye Rare 1 inch Medium 1-1/2 inch 1 inch 1-1/2 inch Well-done 1 inch 1-1/2 inches Lamb Chops & Steaks Rare 1 inch 1-1/2 inch Medium 1 inch 1-1/2 inch Well-done...

  • Page 27

    FOOD WEIGHT OR THICKNESS Breasts well-done FISH AND SEAFOOD Steaks Halibut 3/4 to 1 inch Salmon Swordfish Whole Catfish 4 to 8 ounces Rainbow trout FLAME APPROXIMATE SIZE TIME Medium 30 to 45 minutes Marinate with Italian dressing Medium to 8 to 15 minutes High Medium to...

  • Page 28

    6 to 8 hours. Wrap tortillas in foil. Remove meat from marinade. Cook on a pre-heated gas grill for 5 to 8 minutes on each side. While meat is cooking, heat tortillas on grill, slice meat across grain...

  • Page 29

    2 tbs. finely chopped onion ½ clove garlic, minced 1 medium tomato, chopped salt and pepper Roast eggplant on gas grill over medium flame, turning occasionally until thoroughly cooked. This may take 30 minutes. Remove from grill and cool for handling.

  • Page 30

    Saturday. Our telephone number is 1-800-554-5799, fax number 1-800-598-8829. Please direct all correspondence to: Nexgrill Industries, Inc. 280 Machlin Court, City of Industry, California, 91789, ATTN: Warranty Service Center. *Jenn-Air is a trademark of the Maytag Corporation and is used under license to Lowe’s Company Inc. Warranty Period: Lifetime...

Comments to this Manuals

Symbols: 0

Latest comments:

  • Kurt Jun 28, 2014 09:56:
    Need to know how to get the knobs off a Jenn Air grill.
×

Select the desired size and copy embed code

Copy your embed code and put on your site: