Related Manuals for Jøtul F 500 USA
Summary of Contents for Jøtul F 500 USA
- Page 1 Jøtul F 500 USA USA/CAN - Installation and Operating Instructions Kindly save these instructions for future reference.
- Page 3 USA/cAnAdA Installation and Operating Instructions for the USA Installation et fonctionnement pour Canada Safety notice: If this solid fuel room heater is not properly installed, a house fire may result. For your safety, follow the installation directions. Contact local building or fire officials about restrictions and installation inspection requirements in your area.
-
Page 4: Table Of Contents
USA/cAnAdA Safety notices: Table of contents: Safety Notices ..................4 • Be sure to read this entire manual before you install or use your new Jøtul F 500 woodstove. 1.0 Installation • If this room heater is not properly installed, a house fire 1.1 Assembly before Installation ............ 5 may result. To reduce the risk of fire, follow the installation instructions. -
Page 5: Installation
USA/cAnAdA 1.0 Installation 2.0 Chimney and Chimney Connector If this solid fuel room heater is not properly installed a house fire may result. For your safety, follow the installation directions. Contact the local building or fire officials about restrictions and The chimney connector is a single walled pipe used installation inspection requirements in your area. -
Page 6: Masonry Chimney
USA/cAnAdA The following guidelines give the necessary chimney requirements The manufacturer’s installation instructions must be followed based on the national code (ANSI-NFPA 211for the US. And CSA precisely. Always maintain the proper clearance to combustibles CAN-B365 for Canada). However, many local codes differ from as established by the pipe manufacturer. -
Page 7: Connecting To The Chimney
USA/cAnAdA 3.0 Connecting to the In Canada In Canada the standard has been established by the Canadian chimney Standard Association. The installation must conform to CAN/ CSA-B365, Installation Code for Solid Fuel Burning Appliances and Equipment. Before proceeding be sure to consult your local building inspector. -
Page 8: Clearances To Combustibles
USA/cAnAdA 4.0 Clearances to Using Shields to Reduce Clearances Pipe shields: When using listed pipe shields to reduce the Combustibles connector clearance to combustibles, it must start 1”(25,4mm) above the lowest exposed point of the connect pipe and extend vertically a minimum of 25” (635mm) above the top surface of the stove. -
Page 9: Mobile Home Installations
USA/cAnAdA 5.0 Operation 4.4 Mobile Home Installations The Jøtul F 500 has been approved for use in mobile homes in Before building a fire in your new Jøtul F 500, please read the the U.S. and Canada, provided: following section carefully and completely. 1. -
Page 10: Starting And Maintaining A Fire
USA/cAnAdA 5.5 The Formation of Creosote Never allow the stove to exceed a 400° surface temperature during any “break-in fire” with the exception of the last “break- in” fire. Creosote and Soot Formation and the Need for Removal Note: It is normal for a new painted stove to emit an odor and even smoke during its first several fires. -
Page 11: Maintenance
USA/cAnAdA 6.0 Maintenance Glass removal: Always operate the doors slowly and cautiously to avoid cracking or breaking the glass. Never use the door to push wood into For your protection always wear safety gloves when handling the firebox. If the glass becomes cracked or broken follow this the ash pan. -
Page 12: General Maintenance
USA/cAnAdA 7.0 General Maintenance 8.0 Accessories As with your car, regular maintenance will prolong the life of your Only use accessories that are specifically designed for the Jøtul stove. The following procedures do not take long and are generally F 500. inexpensive, but when performed consistently, will help ensure 8.1 Firescreen 129172 many years of reliable performance. -
Page 13: Floor Bracket Kit
USA/cAnAdA 8.4 Rear Heatshield 154332 A stove rear heatshield has been specifically designed for the Jøtul F 500 to reduce clearances off the rear of the stove to combustible materials. Use of the heatshield does not affect the clearance off the sides of the appliance. -
Page 14: Figures -Drawings
USA/cAnAdA Fig. 1 a Fig.1 Fig. 1 b Fig. 3 Fig. 4 Fig. 1 c... - Page 15 USA/cAnAdA Fig. 8 Fig. 5 2" (50 mm) 8" (200 mm) Min. width 50,5" 18" 8" ( 1283mm) (460 mm) (200 mm) 18" (460 mm) Min. width 56" (1422 mm) Fig. 6 Fig. 9 18" (460 mm) 14" 48" (1220 mm) 14"...
- Page 16 USA/cAnAdA Fig.11 Fig.12 Fig.13...
- Page 17 USA/cAnAdA Jøtul F 500 Woodstove Clearances Minimum clearance from Left Side Load Door to combustible surfaces is 36”. The side door must be locked in alcove and corner installations. Unprotected Surface Protected Surface PER NFPA 211 or Parallel to the Wall Parallel to the Wall CAN/CSA-B365 Important...
-
Page 18: Clearances
USA/cAnAdA Jøtul F 500 Woodstove Clearances Stove clearances Unprotected surface Protected surface NFPA 211 Parallel installation Parallel installation Side Rear Corner* Side Rear Corner* Stove- no heatshields 14” A 18” B 13” C 6” D 12” E 9” F Single wall pipe 355mm 460mm 330mm... -
Page 19: Exploded View
USA/cAnAdA... -
Page 20: Appendix A (Alternate Floor Protection)
USA/cAnAdA Appendix A Pos. No. Description Latch (Side Door) Alternate Floor Protection Ash House Complete Ash Door All floor protection materials must be non-combustible ie. metal, Smoke Outlet Fire Grate brick, stone, mineral fiber boards). Any combustible material may Air Valve not be used. -
Page 21: Jøtul N. A. Wood-Burning Product Limited Warranty
USA/cAnAdA 9.0 JØTUL N.A. WOOD- retail purchaser of the Jøtul or Scan Stove or Fireplace Insert. This paragraph sets forth the sole remedy available under this BURNING PRODUCT warranty in the event of any defect in the Jøtul Scan Stove or Fireplace Insert. - Page 22 USA/cAnAdA OF LAW WHATSOEVER. ALL IMPLIED WARRANTIES, INCLUDING THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE, OR OTHERWISE, ARE LIMITED IN DURATION TO THE LENGTH OF THIS WRITTEN WARRANTY. EXCEPT AS EXPRESSLY SET FORTH HEREIN, JØTUL MAKES NO ORAL, WRITTEN OR OTHER WARRANTY WITH RESPECT TO JØTUL OR SCAN STOVES OR FIREPLACES.
- Page 24 Jøtul pursue a policy of constant product development. Products supplied may therefore differ in specification, colour and type of accessories from those illustrated and described in the brochure. Quality Jøtul AS has a quality system that conforms to NS-EN ISO 9001 for product development, manufacturing, and distribution of stoves and fireplaces.