Related Manuals for Ice-O-Matic Counter Top Dispenser IOD22030
Summary of Contents for Ice-O-Matic Counter Top Dispenser IOD22030
- Page 1 PRODUCT MANUAL FOR MODEL IOD16022 AND IOD22030 COUNTER TOP DISPENSER Part Number 9081286-01 Print Date 7/01P...
-
Page 2: Table Of Contents
The IOD16022 and IOD22030 are ice only counter top dispensers designed to use 22 inch wide and 30 inch wide respectfully Ice-O-Matic cubed ice machines as the source of ice. Ice from the cuber falls into the insulated bin where it is stored until needed. When a user pushes the dispense button, a rotating wheel scoops the ice up to the top front of the bin where there is an outlet to the ice chute. -
Page 3: Specification/Limitations
Specifications Limitations: Must meet the same limitations as the cuber installed on top of it: 50° F. air minimum 100° F. air maximum Must be installed indoors. Must allow at least 6 inch clearance at the rear and both sides when using an air cooled ice machine. -
Page 4: Specifications
Machine requires voltage indicated on rating nameplate. Failures caused by improper voltage are not considered factory defects. Extended periods of operation at temperatures exceeding limitations constitutes misuse under the terms of the Ice-O-Matic Manufacture’s Limited Warranty, resulting in a loss of warranty coverage. Specifications and design are subject to change without notice. -
Page 5: Installation
These dispensers are designed to dispense cubed ice only. Do not use flaked, crushed or compressed ice forms. If an Ice-O-Matic ice machine is to be placed on top of the dispenser, an adapter will be required. Ice Machine Adapter... - Page 6 IOD16022 Installation: General IOD22030 Drain Line Installation (Dispenser) Connect a ¾” ID flexible drain hose to the drain nipple located under the ice storage bin. Clamp the hose in place and insulate the hose to prevent condensation. Connect a ¾” ID flexible drain hose to the drain tube at the back of the drain pan.
- Page 7 IOD16022 Installation: General IOD22030 Final Preparation Install the drain pan on the dispenser by engaging the slots in the metal backplate of the drain pan onto the brackets protruding from the lower left and right hand corners of the dispenser front. Push down on the drain pan to lock it into place.
-
Page 8: Installation
Installation: General Ice Machine Installation Make sure the counter the dispenser is place on is structurally able to hold the combined weight of the dispenser, ice and ice machine. Remove the dispenser cover. (Retain for future use) Place the appropriate stainless steel KBT adapter onto the top of the dispenser. 22 inch wide ice machine on a 22-inch wide dispenser. -
Page 9: Cleaning
The dispenser must be cleaned and sanitized periodically as prescribed by local health authority or the product supplier, which ever has jurisdiction. Ice-O-Matic recommends the dispenser be cleaned and sanitized at least monthly if not specified by local code requirement. -
Page 10: Cleaning
IOD16022 Cleaning and Sanitizing IOD22030 Monthly And Initial Start-Up: Sanitize the ice storage system Disconnect power to the dispenser and ice machine. Remove the dispenser front cover plate in front of the ice machine and discard all remaining ice, Mix a solution of 1 ounce of household bleach to 2 gallons of potable water, or: mix a solution of any approved sanitizer, following the directions for mixing and applying that sanitizer. -
Page 11: Service Diagnosis
Service Diagnosis/Electrical Sequence Service Diagnosis PROBLEM PROBABLE CAUSE Will not dispense No ice in hopper Vend switch does not close Drive motor not working Door solenoid will not open door Rotor will not turn Relay for vend switch does not close during operation Electrical Sequence Reference Wiring Diagram, Page 20-21... -
Page 12: Parts List
IOD16022 and IOD2230 Service Parts This parts list contains the service parts available for the IOD16022 and IOS22030 ice only dispenser. Check the model number on the data plate and refer to the correct column listing for the specific dispenser. These two models share many common components but also have components that are model specific. - Page 13 IOD16022 IOD16022 and IOD2230 Service Parts IOD22030 Cabinet Page 12...
- Page 14 IOD16022 and IOD2230 Service Parts Cabinet IOD16022 Item Number Part Number 30064502 30074312 3012236901 2066110000 30074311 1117390000 3002304001 3A34760001 3A34810001 3A34817001 3002310305 IOD22030 Part Number Description 30064512 Black Lid 30074312 Side Panel Extension 3012236901 Gearmotor Assembly Drain Hose 2066110000 Leg Kit 30074311 Side Panel Extension 1117390000...
- Page 15 IOD16022 IOD16022 and IOD2230 Service Parts IOD22030 Cabinet Front Page 14...
- Page 16 IOD16022 and IOD2230 Service Parts Cabinet Front IOD16022 Item Number Part Number 30064206 30064218 30069901 3015075218 3002307101 3002307200 30072700 30073000 3012157001 3002306801 30072800 3000570132 30061102 3A34794005 3034794006 30061810 30073200 3012237201 3A34806001 3003072706 IOD22030 Part Number Description 30064226 Cover, Merch. Black-Lever 30064238 Cover, Merch.
- Page 17 IOD16022 IOD16022 and IOD2230 Service Parts IOD22030 Control Box Page 16...
- Page 18 IOD16022 and IOD2230 Service Parts Control Box IOD16022 Item Number Part Number 3000480001 1193210500 2021610000 3012238501 30073510 3012237701 3002306701 3013088201 3A32683003 3013059500 3012237101 3000522001 3000477000 3012238601 3012238002 IOD22030 Part Number Description 3000480001 Relay 1193210500 Transformer 2021610000 Starter Socket 3012238501 Bulb Holder 30073530 Control Box Cover 3012237702...
- Page 19 IOD16022 IOD16022 and IOD2230 Service Parts IOD22030 Ice Door and Solenoid Assembly Page 18...
- Page 20 IOD16022 and IOD2230 Service Parts Ice Door And Solenoid Assembly IOD16022 Item Number Part Number 3A34801001 1061400000 3002308902 3000463000 3002308801 1034580000 3A32685001 2066990000 3A32690002 3A34802001 1061400000 3000463000 3000482000 IOD22030 Part Number Description 3A34801001 Ice Door 1061400000 Cotter Pin (6 Req.) 3002308902 Solenoid Link 3000463000...
-
Page 21: Wiring Diagram
IOD16022 IOD16022 and IOD2230 Wiring Diagrams IOD22030 Page 20... -
Page 22: Wiring Diagram
IOD16022 IOD16022 and IOD2230 Wiring Diagrams IOD22030 Page 21...