Nexgrill 720-0433 Assembly & Operating Instructions
  1. Manuals
  2. Brands
  3. Nexgrill Manuals
  4. Grill
  5. 720-0433
  6. Assembly & operating instructions
Nexgrill 720-0433 Assembly & Operating Instructions

Nexgrill 720-0433 Assembly & Operating Instructions

For propane gas use only
Hide thumbs
Table of Contents

Advertisement

Quick Links

ASSEMBLY & OPERATING INSTRUCTIONS
Model: 720-0433
FOR PROPANE GAS USE ONLY
FOR OUTDOOR USE ONLY
A25Y08_P
This instructions manual contains important information necessary for the proper assembly and safe use of the appliance.
Read and follow all warnings and instructions before assembling and using the appliance
1
Follow all warnings and instructions when using the appliance
Keep this manual for future reference

Advertisement

Table of Contents
loading

Related Manuals for Nexgrill 720-0433

Summary of Contents for Nexgrill 720-0433

  • Page 1 ASSEMBLY & OPERATING INSTRUCTIONS Model: 720-0433 FOR PROPANE GAS USE ONLY FOR OUTDOOR USE ONLY A25Y08_P This instructions manual contains important information necessary for the proper assembly and safe use of the appliance. Read and follow all warnings and instructions before assembling and using the appliance...

  • Page 2: Table Of Contents

    Table of Contents Safety Instruction ..... Care and Maintenance ....22-23 Assembly Instruction .

  • Page 3: Safety Instruction

    Safety Instruction continued WARNING CAUTION: Beware of Flashback CAUTION: Spiders and small insects occasionally Do not try lighting this appliance without reading the spin webs or make nest in the grill “LIGHTING INSTRUCTIONS” section of this manual. burner tubes during transit and warehousing.
  • Page 4 Safety Instruction continued LP-Gas Supply System PROPER PLACEMENT AND CLEARANCE OF If the information is not followed exactly, a fire resulting in death or GRILL serious injury could occur. A 20lb tank of approximately 12 inches in diameter by 18-1/4 inches •Never use your gas grill in a garage, porch, shed, high is the maximum size LP gas tank to use.
  • Page 5 Safety Instruction continued SAFETY PRACTICES TO AVOID PERSONAL WARNING INJURY Your grill will get very hot. Never lean over the cooking area while using your grill. Do not touch When properly cared for, your grill will provide safe, cooking surfaces, grill housing, lid or any other grill reliable service for many years.
  • Page 6 Safety Instruction continued Do not heat unopened food containers. A build-up of Do not use the grill to cook excessively fatty meats or pressure may cause the containers to burst. other products which promote flare – ups. Use a covered hand when opening the grill lid. Do not operate the grill under unprotected combustible constructions.

  • Page 7: Assembly Instruction

    Assembly Instruction Secure the two locking swivel casters and two big wheels with attached ten screws into the cart frame. B. Put the cart legs up as below and lock the four latches on the four legs. Then use the screws which attached on the transom to install the gas tank support as below (both sides are the same):...
  • Page 8 Assembly Instruction continued C. Put the fire box onto the cart legs, put the fire box support insert the legs. And lock the four latches as below: D. Remove the three screws attached on the right front trim panel and remove the panel, locate 1 screw which attached will connect the handle with the fire box support , then reassemble the right front trim panel.
  • Page 9 Assembly Instruction continued E. Open the latch which on the side shelf, as below: F. Open the side shelf , wind plate and the warming rack bracket, then put on the warming rack. As below:...
  • Page 10 Assembly Instruction continued Open the wind plate and the warming rack bracket : Put on the warming rack:...
  • Page 11 Assembly Instruction G: To install the battery, turn the ignition button cap counterclockwise and remove it. Insert the battery into the housing with the positive(+) terminal facing outward. Screw the ignition button housing back into place. (one battery include in the hardware packing)

  • Page 12: Assembly Instruction

    Assembly Instruction continued H: Place gas tank up to the gas tank hook. Raise the gas tank retention ring located inside the cart on the firebox right panel. Release the gas tank retention ring and place the ring over the gas tank ensuring the gas tank is secured. Just like the photo below: I : Raise the gas tank retention ring located inside the cart on the firebox panel.

  • Page 13: Gas Hook -Up

    Gas Hook - Up NEVER CONNECT AN UNREGULATED GAS SUPPLY QCC1 in the standard for compressed gas cylinder LINE TO THE APPLIANCE. USE THE valve outlet and inlet connection ANSI/CGA-V-1. REGULATOR/HOSE ASSEMBLY SUPPLIED. Manifold pressure: 11”(27.94cm) water column (W.C.). This is a liquid propane configured grill. Do not attempt L.P.

  • Page 14: Installer Final Check List

    Gas Hook – Up continued 5. When connecting regulator assembly to the valve, 7. If you have a gas connection leak you cannot repair, hand tighten the quick coupling nut clockwise to a turn gas OFF at supply tank, disconnect fuel line complete stop.

  • Page 15: Leak Testing

    Leak Testing GENERAL Only those parts recommended by the manufacturer should be used on the grill. Although all gas connections on the grill are leak tested at the factory prior to shipment, a complete gas Substitution will void the warranty. Do not use the grill tightness check must be performed at the installation until all connections have been checked and do not site due to possible mishandling in shipment, or...
  • Page 16 Leak Testing continued CAUTIONS Place dust cap on cylinder valve outlet when the cylinder is not in use. Only install the type of dust cap on the cylinder valve outlet that is provided with the cylinder valve. Other types of caps or plugs may result in leakage of propane. The gas must be turned off at the supply cylinder when the unit is not in use.

  • Page 17: Operating Instruction

    Operating Instruction GENERAL USE OF THE GRILL AND ROTISSERIE WARNING: IMPORTANT! Each main burner is rated at 14,500 Btu/hr. The main USING THE SIDE BURNER: grill burners encompass the entire cooking area and Inspect the gas supply hose prior to turning the gas are side ported to minimize blockage from falling “ON”.

  • Page 18: Grill Lighting Instruction

    Grill Lighting Instruction WARNING: IMPORTANT! TO LIGHT THE MAIN BURNER: BEFORE LIGHTING… Never substitute regulators and hose assembly for those supplied with the grill. If a replacement is Inspect the gas supply hose prior to turning the gas necessary, contact the manufacturer for proper “ON”.

  • Page 19: Grill Lighting Instruction

    Grill Lighting Instruction continued FLAME CHARACTERISTICS Check for proper burner flame characteristics. Burner flames should be blue and stable with no yellow tips, excessive noise, or lifting. If any of these conditions exist call our customer service line. If the flame is yellow, it indicates insufficient air. If the flame is noisy and tends to lift away from the burner, it indicates to much air Each burner is adjusted prior to shipment;...

  • Page 20: Lighting Illustration

    Lighting Illustration Sear Burner Lighting Illustration: Main & Side Burner Lighting Illustration: Push and turn the Sear Burner knob slowly to IGNITE/ON. If burner does not light up, Step 1. turn the knob to OFF and repeat lighting Make sure the Lid is open procedure.

  • Page 21: To Match The Light Grill

    To Match the Light Grill If the burner will not light after several attempts then the burner can be match lit. If you have attempted to light the main burners with the igniter, allow 5 minutes for any accumulated gas to dissipate. Insert a match into the lighting rod.

  • Page 22: Care And Maintenance

    Care and Maintenance MAIN GRILL BURNER CLEANING STAINLESS STEEL Ensure the gas supply is off and the knobs are in the There are many different stainless steel cleaners “OFF” position. Make sure the grill is cool. Clean the available. Always use the mildest cleaning procedure exterior of the burner with a wire brush.

  • Page 23: Care And Maintenance

    Care and Maintenance continued STAINLESS STEEL : HOW TO REPLACE MAIN BURNER There are many different stainless steel cleaners Step 1. Insert the burner onto the orifice. available. Always use the mildest cleaning procedure first, scrubbing in the direction of the grain. Do not use steel wool as it will scratch the surface.

  • Page 24: Trouble Shooting

    Trouble Shooting SPIDER AND INSECT WARNING WHEN TO LOOK FOR SPIDERS You should inspect the burners at least once a year or immediately after any of the following conditions occur: Checking and cleaning burner/ venturi tubes for insects and insect nests. A clogged tube can lead to a 1.

  • Page 25: Cooking Temperatures

    Trouble Shooting continued PREHEATING: The grill lid should be in a closed position during the preheat time period. It is necessary to preheat the grill before cooking certain foods, depending on the type of food and the cooking temperature. Food that requires a high cooking temperature needs a pre-heat period of five minutes;...
  • Page 26 Trouble Shooting continued PROBLEM SOLUTION When attempting to light my grill, it will not • Make sure you have a spark while you are trying to light light immediately. the burner (if no spark) • Ensure that the wire is connected to the electrode assembly.
  • Page 27 Trouble Shooting continued Grill only heats to 200-300 degrees. • Check to see if the fuel hose is bent or kinked. • Make sure the grill area is clear of dust. • Make sure the burner and orifices are clean. •...

  • Page 28: Exploded View

    Explode View...

  • Page 29: Part List

    Part List Part (Description) Part (Description) Side Shelf Support Swivel Caster With Brake Side Shelf ， Left Bottom Panel, LP Side Shelf Support Foot Brake Trim Piece Side Shelf Handle Gas Tank Support Front Trim Panel, Left Main Manifold B Regulator, LP Sear Gas Valve Lighting Rod...

  • Page 30: Ordering Parts

    If dealer service is grill dealer before making the conversion. not available, contact: Nexgrill Industries, Inc. customer service Different orifices must be installed when converting from one type of gas to another.

  • Page 31: Grill Cooking Chart

    Grill Cooking Chart WEIGHT OR HEAT APPROXIMATE SPECIAL INSTRUCTIONS FOOD THICKNESS SETTING TIME AND TIPS Slice. Dot with butter or margarine. Wrap in VEGETABLES heavy -duty foil. Grill, turning occasionally Medium 12 to 20 minutes Grill, turning once. Brush occasionally with Fresh melted butter or margarine.

  • Page 32: Grill Cooking Chart

    Grill Cooking Chart continued WEIGHT OR HEAT APPROXIMATE SPECIAL INSTRUCTIONS FOOD THICKNESS SETTING TIME AND TIPS PORK Trim edges. Grill, turning once. Cook to Chops 1 inch Medium 20 to 30 minutes desired doneness. 1 -1/2 Well -done inches Medium 30 to 40 minutes Grill, turning occasionally.

  • Page 33: Grill Recipe Suggestion

    Grill Recipe Suggestion continued BBQ SALMON TANGY SEAFOOD KABOBS BBQ the chops brushing with the marinade occasionally. Serve with 1 lb. Large shrimp, shelled & 2 large salmon steaks deveined mixed salad, dressed with 2 tbs. Oil vinaigrette flavored with fresh dill. ¾...
  • Page 34 Grill Recipe Suggestion continued Preheat grill. Combine cheese, Pound flank steak to ¼ inch In blender, process 1/3 c. water, condensed soup, milk, BBQ sauce, thickness or flatten chicken breasts. onion, soy sauce, 2 tsp. oil and the oregano, salt and pepper in a large Mix oil, lime juice and seasonings next 8 ingredients until smooth.

  • Page 35: Grill Recipe Suggestion

    Grill Recipe Suggestion continued CHICKEN TANDOORI STYLE Marinade ribs for 3 hours. Use TURKEY marinade for basting by adding 8 large chicken thighs or 12 lb. turkey drumsticks beer to it. Place pan under the ribs Beer basting sauce: and baste frequently. To cook ribs 1 c.

  • Page 36: Limited Warranty

    Limited Warranty 720-0433)

Table of Contents