Jenn-Air 750-0141 Manual
Jenn-Air 750-0141 Manual

Jenn-Air 750-0141 Manual

Stainless steel built-in gas grill

Advertisement

STAINLESS STEEL BUILT-IN GAS GRILL
MODEL #s: 750-0141 / 740-0141
Jenn-Air is a Trademark of the Maytag Corporation and is used under license to Lowe's Companies, Incorporated.
PLEASE CONTACT 1-800-554-5799 FOR ASSISTANCE
DO NOT RETURN TO PLACE OF PURCHASE
LOWE'S ITEM #s: 168932 / 168931
300
400
500
600
200
100
700
800
FOR OUTDOOR USE ONLY
A22Y07-3

Advertisement

Table of Contents
loading

Summary of Contents for Jenn-Air 750-0141

  • Page 1 STAINLESS STEEL BUILT-IN GAS GRILL MODEL #s: 750-0141 / 740-0141 LOWE’S ITEM #s: 168932 / 168931 Jenn-Air is a Trademark of the Maytag Corporation and is used under license to Lowe’s Companies, Incorporated. FOR OUTDOOR USE ONLY A22Y07-3 PLEASE CONTACT 1-800-554-5799 FOR ASSISTANCE...
  • Page 2: Safety Instructions

    SAFETY INSTRUCTIONS RECOGNIZED SAFETY SYMBOLS, WORDS AND LABELS WARNING WARNING Do not try lighting this appliance without first reading the “LIGHTING INSTRUCTIONS” section of this manual. WARNING – Hazards or unsafe practices which COULD result in severe personal injury or death. WARNING Spiders and insects can nest inside the burners of CAUTION...
  • Page 3 24 inches from all sides to combustible materials. Outdoor cooking appliance shall not be used under Model 750-0141 Natural Gas Grill overhead combustible construction. WARNING 1. The outdoor cooking gas appliance and its individual shutoff valve must be disconnected...
  • Page 4 SAFETY INSTRUCTIONS This grill is not intended to be installed in or on WARNING recreational vehicles or boats. Do not try lighting this appliance without first reading the “LIGHTING INSTRUCTIONS” section of this Children should not be left alone or unattended in an manual.
  • Page 5: Placement Of The Grill

    Do not use briquettes of any kind in the grill. Clean the grill with caution. To avoid steam burns, The 750-0141 and 740-0141 grills are designed for do not use a wet sponge or cloth to clean the grill optimum performance without the use of briquettes.
  • Page 6: Model Specifications

    GRILL SPECIFICATIONS Description 750-0141 and 740-0141 Cutout Width 33 in. (83.82 cm) Cutout Depth 21 in. (53.34 cm) Cutout Height 11 in .(27.94 cm) Natural Gas: Standard residential 1/2 in. (1.3 cm) ID gas service line. Natural gas hose/regulator assembly included with quick-connect fitting for attachment to house natural gas line.
  • Page 7: Island Construction

    33 inches (83.82 cm) Depth 21 inches (53.34cm) Height 11 inches (27.94 cm) Tank bolt dimension for Jenn-Air 4 burner LP Tank bolt type: 1/2 inches-12UNC (1.27 cm) Tank bolt length: 9/20 inches (11.5 cm) Non-Combustible material needs to be Never use wood or any combustible used for built-in enclosure.
  • Page 8 1 7/16 in.(3.65cm) Measurements shown are for attaching the LP regulator to the island. 13/16 in.(2.06cm) 2 15/16 in.(7.46cm) 750-0141 1 9/16 in.(3.97cm) Measurements shown are for attaching 2 15/16 in.(7.46cm) the NG regulator to the island. 1 9/16 in.(3.97cm)
  • Page 9: Front View Of Opening

    2 in.(5.08cm) 2 in.(5.08cm) 1 7/8 in.(4.76cm) The following are minimum dimensions necessary to install the Jenn-Air built-in 4 burner grills. Width of grill head: 32 in. Depth for grill control panel: 10 7/8 in. Combustion Gap below control panel: 1 7/8 in.
  • Page 10: Side View Of Opening

    The following are minimum clearances necessary around the Jenn-Air built-in 4 burner grills. Rear Clearance: 24 in. to combustible materials Combustion gap below control panel: 1 3/4 in.
  • Page 11: Battery Installation

    BATTERY INSTALLATION 1. Unscrew the ignition button housing by turning counterclockwise. 2. Insert the battery into the housing with the positive (+) terminal facing outward. 3. Replace the ignition button housing after the battery has been installed.
  • Page 12: Lp Gas Hook Up

    LP GAS HOOK-UP Only the pressure regulator and hose assembly LP GAS HOOK-UP supplied with the grill should be used. Any Make sure the black plastic grommets on the LP replacement pressure regulator and hose assembly cylinder valve are in place, and the hose does not must be specified by the grill manufacturer.
  • Page 13: Propane Tank Assembly

    PROPANE TANK ASSEMBLY Fig. 1 30 0 5 00 2 00 60 0 Make sure the LP regulator is located under the island hole as shown in Fig. Fig. 2 3 00 5 00 2 00 6 00 10 0 8 00 7 00 Use the 4 screws and clamp provided...
  • Page 14: Installation Of Ng Regulator

    INSTALLATION OF NATURAL GAS REGULATOR 1. The Natural Gas regulator has been factory installed. Attach the PVC gas hose to the regulator (see drawing below). 2. Adjust the brass elbow so that it is pointing down. 3. Connect the other end of the PVC gas hose to the house gas line using the quick-connect fitting.
  • Page 15: Natural Gas Hook-Up Xxxxxxxxxxxxxxxxxxxxxxxx

    The installation of this appliance must conform with the local codes or, in the absence of local codes, to the national fuel gas code, ANSI Z223.1. Total gas consumption (per hour) of the 750-0141 grill with all burners on the “IGNITE / HI” setting: Main burners...
  • Page 16: Leak Testing Xxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxx

    LEAK TESTING XXXXXXXXXXXXXXXXXXXXXXXXXXXXXXXXXX GENERAL Although all gas connections on the grill are leak 6. If it is evident there is excessive abrasion or tested at the factory prior to shipment, a complete wear, or the hose is cut, it must be replaced gas tightness check must be performed at the prior to the outdoor cooking gas appliance installation site.
  • Page 17: Installer Final Checklist

    Keep the instruction manual with the grill for future reference. Model 750-0141 WARNING 1. The outdoor cooking gas appliance and its individual shutoff valve must be disconnected from the gas supply piping system during any pressure testing of that system at test pressure in excess of 1/2 psi (3.5 kpa).
  • Page 18: Operating Instructions

    OPERATING INSTRUCTIONS GENERAL USE OF THE GRILL AND ROTISSERIE Each main burner is rated at 12,000 BTU/Hr. The CAUTION main grill burners encompass the entire cooking Do not leave the grill unattended while cooking. area and are side ported to minimize blockage from falling grease and debris.
  • Page 19 LOADING THE ROTISSERIE SKEWER It is normal for the skewer to flex when larger cuts 1. Screw the bushing into the skewer rod at the of meat are being cooked. It may also be necessary opposite end from the point. to remove the cooking grids for larger cuts of meat.
  • Page 20: Lighting Instructions

    LIGHTING INSTRUCTIONS BEFORE LIGHTING… Inspect the gas supply piping prior to turning the gas “ON”. If there is evidence of cuts, wear, or abrasion, it must be replaced prior to use. WARNING Do not use the grill if gas odor is present. Contact Yellow flames indicate insufficient air.
  • Page 21: Lighting Illustrations

    LIGHTING ILLUSTRATIONS MAIN BURNER LIGHTING ROTISSERIE BURNING LIGHTING 1. Open the top cover or lid. 4. Push and turn the Rear Burner knob to the “IGNITE/ON” setting and hold in for 5 seconds while holding, push electronic ignition button, until burner is lit.
  • Page 22: To Match Light The Grill

    MATCH LIGHTING THE GRILL If the burner will not light after several attempts using the control knobs, the burner may be lit with a match. 1. If you have already attempted to light the burner with the igniter, allow 5 minutes for any accumulated gas to dissipate.
  • Page 23: Care And Maintenance

    To reinstall the main burners: 3. Insert the burner over the valve assembly CAUTION (model 750-0141/740-0141 Item # 16 on Before cleaning, make sure the gas supply and pages 24 and 26). control knobs are in the “OFF” position and the Insert the back of the burner into the hole at burners have cooled.
  • Page 24: Troubleshooting

    TROUBLE SHOOTING WHEN TO LOOK FOR SPIDERS INSECT WARNING You should inspect the burners twice a year or Spiders and insects can nest in the burners of immediately after any of the following conditions this and other grills, which could disrupt gas occur: flow.
  • Page 25: Exploded View Model 750-0141

    EXPLODED VIEW MODEL 750-0141 40 0 2 00 1 00 80 0 70 0...
  • Page 26: Parts List Model 750-0141

    PARTS LIST MODEL 750-0141 REF# DESCRIPTION REF# DESCRIPTION Main Lid Grease Tray Temperature Gauge Lighting Rod Cover Logo Lighting Rod Main Lid Handle Heat Insulating Spacer Gas Valve Clamp Main Lid Handle Main Manifold Rear Baffle Rotisserie Gas Valve Rotisserie Burner lgniter wire...
  • Page 27: Exploded View Model 740-0141

    EXPLODED VIEW MODEL 740-0141 4 00 7 00 8 00...
  • Page 28: Parts List Model 740-0141

    PARTS LIST MODEL 740-0141 REF# DESCRIPTION Q’TY REF# DESCRIPTION Main Lid Grease Tray Temperature Gauge Lighting Rod Cover Logo Lighting Rod Main Lid Handle Heat Insulating Spacer Gas Valve Clamp Main Lid Handle Main Manifold Rear Baffle Rotisserie Gas Valve Rotisserie Burner lgniter Wire Main Burner Flex Gas Rotisserie Burner Gas Collector...
  • Page 29: Grilling Hints

    GRILLING HINTS The preparation of meat, whether rare, medium, or To get the juiciest meat, add seasoning or salt after well done, is affected to a large degree by the the cooking is finished and turn the meat only once thickness of the cut.
  • Page 30 WEIGHT OR FLAME APPROXIMATE SPEICAL INSTRUCTIONS FOOD THICKNESS SIZE TIME AND TIPS Place in aluminum foil pan. French Fries Medium 15 to 30 minutes Grill, stirring occasionally. MEATS Grill, turning once when juices rise to the surface. Do not leave hamburgers unattended since a flare-up Hamburgers 1/2 to 3/4 inch...
  • Page 31 WEIGHT OR FLAME APPROXIMATE SPEICAL INSTRUCTIONS FOOD THICKNESS SIZE TIME AND TIPS Grill, turning occasionally. Ribs During last few minutes brush with barbecue sauce, turn Medium 30 to 40 minutes several times. Ham steaks Remove excess fat from edge. Slash remaining fat at 2-inch (precooked) 1/2 inch slices High...
  • Page 32: Grill Recipe Suggestions

    GRILL RECIPES BBQ SALMON Half-hour before cooking, turn the 1tsp. Worcestershire sauce 2 large salmon steaks burner to the grill on high. Drain 1tsp. Dry mustard 2 tbs. oil seafood-reserving marinade. On each ¼ tsp. Thyme, crushed Salt & pepper of twelve 10 in.
  • Page 33 heat tortillas on grill. Slice meat across CHICKEN TANDOORI STYLE 2 oz. lemon juice grain in thin slices. Place on hot platter. 8 large chicken thighs or drumsticks 10 lbs. pork roast Squeeze lemon juice over. Wrap meat and 1 c. plain nonfat yogurt any of the following toppings in tortillas: ½...
  • Page 34: Limited Warranty

    1-800-554-5799, FAX number 1-800-598-8829. Please direct all correspondence to: Nexgrill Industries, Inc. 280 Machlin Court, City of Industry, CA 91789, ATTN: Warranty Service Center. *Jenn-Air is a trademark of the Maytag Corporation and is used under license to Lowe’s Company Inc. Printed In China...
  • Page 35: Table Of Contents

    TABLE OF CONTENTS SECTION ONE SECTION FIVE Safety Instructions Exploded View Model 750-0141 Placement of the Grill Parts List Model 750-0141 Exploded View Model 740-0141 SECTION TWO Parts List Model 740-0141 Model Specifications Island Construction SECTION SIX Front View of Opening...

This manual is also suitable for:

740-0141

Table of Contents