Page 6
Replacing a memory module . . 133 Machine Type 7373 . 488 Replacing an adapter card . . 135 Machine Type 7483 . 505 Replacing the power supply . . 137 Machine Type 7484 . 520 Replacing the heat sink and fan assembly . .
This manual is intended only for trained ® Service Providers who are familiar with Lenovo computer products. Note: Be sure to read and understand the Chapter 2, “Safety information,” on page 3 before using the information in this manual.
FRU part numbers. Lenovo plans to transition to RoHS compliance well before the implementation date and expects its suppliers to be ready to support Lenovo’s requirements and schedule in the EU. Products sold in 2005, will contain some RoHS compliant FRUs.
Page 10
CAUTION: Electrical current from power, telephone, and communication cables can be hazardous. To avoid personal injury or equipment damage, disconnect the attached power cords, telecommunication systems, networks, and modems before you open the server/workstation covers, unless instructed otherwise in the installation and configuration procedures.
v Always look carefully for possible hazards in your work area. Examples of these hazards are moist floors, nongrounded power extension cables, power surges, and missing safety grounds. v Do not touch live electrical circuits with the reflective surface of a plastic dental mirror.
If any unsafe conditions are present, you must determine how serious the apparent hazard could be and whether you can continue without first correcting the problem. Consider these conditions and the safety hazards they present: v Electrical hazards, especially primary power (primary voltage on the frame can cause serious or fatal electrical shock).
v Prevent the part from touching your clothing. Most clothing is insulative and retains a charge even when you are wearing a wrist strap. v Use the black side of a grounded work mat to provide a static-free work surface. The mat is especially useful when handling ESD-sensitive devices.
Page 14
v Connect to properly wired outlets any equipment that will be attached to this product. v When possible, use one hand only to connect or disconnect signal cables. v Never turn on any equipment when there is evidence of fire, water, or structural damage.
Page 15
CAUTION: When replacing the lithium battery, use only Part Number 33F8354 or an equivalent type battery recommended by the manufacturer. If your system has a module containing a lithium battery, replace it only with the same module type made by the same manufacturer. The battery contains lithium and can explode if not properly used, handled, or disposed of.
Page 16
CAUTION: The power control button on the device and the power switch on the power supply do not turn off the electrical current supplied to the device. The device also might have more than one power cord. To remove all electrical current from the device, ensure that all power cords are disconnected from the power source.
Page 19
≥18 kg (37 lbs) ≥32 kg (70.5 lbs) ≥55 kg (121.2 lbs) Chapter 2. Safety information...
Page 20
PERIGO A corrente elétrica proveniente de cabos de alimentação, de telefone e de comunicações é perigosa. Para evitar risco de choque elétrico: v Não conecte nem desconecte nenhum cabo ou execute instalação, manutenção ou reconfiguração deste produto durante uma tempestade com raios. v Conecte todos os cabos de alimentação a tomadas elétricas corretamente instaladas e aterradas.
Page 21
CUIDADO: Ao substituir a bateria de lítio, utilize apenas uma bateria com Número de Peça 33F8354 ou um tipo de bateria equivalente recomendado pelo Se o seu sistema possui um módulo com uma bateria de lítio, substitua-o apenas por um módulo do mesmo tipo e do mesmo fabricante.
Page 22
CUIDADO: O botão de controle de alimentação do dispositivo e o botão para ligar/desligar da fonte de alimentação não desligam a corrente elétrica fornecida ao dispositivo. O dispositivo também pode ter mais de um cabo de alimentação. Para remover toda a corrente elétrica do dispositivo, assegure que todos os cabos de alimentação estejam desconectados da fonte de alimentação.
Page 27
DANGER Le courant électrique provenant de l’alimentation, du téléphone et des câbles de transmission peut présenter un danger. Pour éviter tout risque de choc électrique : v Ne manipulez aucun câble et n’effectuez aucune opération d’installation, d’entretien ou de reconfiguration de ce produit au cours d’un orage. v Branchez tous les cordons d’alimentation sur un socle de prise de courant correctement câblé...
Page 28
ATTENTION: Remplacer la pile au lithium usagée par une pile de référence identique exclusivement, (référence 33F8354), ou suivre les instructions du fabricant qui en définit les équivalences. Si votre système est doté d’un module contenant une pile au lithium, vous devez le remplacer uniquement par un module identique, produit par le même fabricant.
Page 29
≥18 kg (37 lbs) ≥32 kg (70.5 lbs) ≥55 kg (121.2 lbs) ATTENTION: Soulevez la machine avec précaution. ATTENTION: L’interrupteur de contrôle d’alimentation de l’unité et l’interrupteur dubloc d’alimentation ne coupent pas le courant électrique alimentantl’unité. En outre, le système peut être équipé de plusieurs cordonsd’alimentation. Pour mettre l’unité...
Page 30
VORSICHT An Netz-, Telefon- und Datenleitungen können gefährliche Spannungen anliegen. Aus Sicherheitsgründen: v Bei Gewitter an diesem Gerät keine Kabel anschließen oder lösen. Ferner keine Installations-, Wartungs- oder Rekonfigurationsarbeiten durchführen. v Gerät nur an eine Schutzkontaktsteckdose mit ordnungsgemäß geerdetem Schutzkontakt anschließen. v Alle angeschlossenen Geräte ebenfalls an Schutzkontaktsteckdosen mit ordnungsgemäß...
Page 31
CAUTION: Eine verbrauchte Lithiumbatterie nur durch eine Batterie mit der Teilenummer 33F8354 oder eine gleichwertige, vom Hersteller empfohlene Batterie ersetzen. Enthält das System ein Modul mit einer Lithiumbatterie, dieses nur durch ein Modul desselben Typs und von demselben Hersteller ersetzen. Die Batterie enthält Lithium und kann bei unsachgemäßer Verwendung, Handhabung oder Entsorgung explodieren.
Page 32
≥18 kg (37 lbs) ≥32 kg (70.5 lbs) ≥55 kg (121.2 lbs) ACHTUNG: Arbeitsschutzrichtlinien beim Anheben der Maschine beachten. ACHTUNG: Mit dem Netzschalter an der Einheit und am Netzteil wird die Stromversorgung für die Einheit nicht unterbrochen. Die Einheit kann auch mit mehreren Netzkabeln ausgestattet sein.
Page 36
PERICOLO La corrente elettrica proveniente dai cavi di alimentazione, del telefono e di comunicazione può essere pericolosa. Per evitare il rischio di scosse elettriche: v Non collegare o scollegare qualsiasi cavo oppure effettuare l’installazione, la manutenzione o la riconfigurazione del prodotto durante un temporale. v Collegare tutti i fili elettrici a una presa di alimentazione correttamente cablata e dotata di messa a terra.
Page 37
ATTENZIONE: Quando si sostituisce la batteria al litio, utilizzare solo il Numero parte 33F8354 o un tipo di batteria equivalente consigliato dal produttore. Se sul sistema è presente un modulo che contiene una batteria al litio, sostituirlo solo con un tipo di modulo dello stesso tipo della stessa casa di produzione.
Page 38
≥18 kg (37 lbs) ≥32 kg (70.5 lbs) ≥55 kg (121.2 lbs) ATTENZIONE: Prestare attenzione nel sollevare l’apparecchiatura. ATTENZIONE: Il pulsante di controllo dell’alimentazione presente sull’unità e l’interruttore dell’alimentatore non disattivano l’alimentazione corrente fornita all’unità. E’ possibile che l’unità disponga di più cavi di alimentazione. Per disattivare l’alimentazione dall’unità, accertarsi che tutti i cavi di alimentazione siano scollegati dalla fonte di alimentazione.
Page 41
PELIGRO La corriente eléctrica procedente de cables de alimentación, teléfonos y cables de comunicación puede ser peligrosa. Para evitar el riesgo de descarga eléctrica: v No conecte ni desconecte los cables ni realice ninguna tarea de instalación, mantenimiento o reconfiguración de este producto durante una tormenta eléctrica.
Page 42
PRECAUCIÓN: Cuando sustituya una batería de litio, utilice solamente una batería número de pieza 33F8354 u otra de tipo equivalente recomendada por el fabricante. Si su sistema dispone de un módulo que contiene una batería de litio, reemplácelo sólo con el mismo tipo de módulo, del mismo fabricante. La batería contiene litio y puede explotar si no se utiliza, manipula o desecha correctamente.
Page 43
≥18 kg (37 lbs) ≥32 kg (70.5 lbs) ≥55 kg (121.2 lbs) PRECAUCIÓN: Adopte procedimientos seguros al levantar el equipo. PRECAUCIÓN: El botón de control de alimentación del dispositivo y el interruptor de alimentación de la fuente de alimentación no desconectan la corriente eléctrica suministrada al dispositivo.
This chapter provides general information that applies to all machine types supported by this manual. ThinkVantage Productivity Center Note: This section applies only to computer models that have an internal hard disk drive and preinstalled software from Lenovo. ® Use the ThinkVantage Productivity Center program which is preinstalled on most ThinkCentre products for general information about the use, operation, and maintenance of the computer.
Specifications This section lists the physical specifications for your computer. For machine types: 3063, 3231, 3285, 6138, 6209, 6239, 6302, 7188, 7244, 7347, 7355, 7358, 7373, 7484, 7571, 7628, 7635, 7639, 8494, 8854, 9728, 9960, and 9965. Dimensions Width: 175mm (6.89 inches) Height: 402 mm (15.83 inches) Depth: 440 mm (17.32 inches) Weight...
Page 47
For all machine types Environment Air temperature: Operating: 10° to 35°C (50° to 95°F) Non-operating: -40° to 60°C (-40° to 140°F) Humidity: Operating: 10% to 80% (10% per hour, non condensing) Non-operating: 10% to 90% (10% per hour) Maximum altitude: Operating: -50 to 10,000 ft (-15.2 to 3048 m) Non-operating: -50 to 35,000 ft (-15.2 to 10,668 m) Electrical input...
Problem determination tips Due to the variety of hardware and software combinations that can be encountered, use the following information to assist you in problem determination. If possible, have this information available when requesting assistance from Service Support and Engineering functions. v Machine type and model v Processor or hard disk upgrades v Failure symptom...
Lenovo troubleshooting center, update system drivers, and review system information. To run the Lenovo System Toolbox, click Start → All Programs → Lenovo Services → Lenovo System Toolbox. Follow the instructions on the screen. The Lenovo System Toolbox also has problem determination aids that determine software and usage problems.
Recovery workspace on each Lenovo computer. Use the PC-Doctor for Windows PE if you are unable to start the Windows operating system or if the Lenovo System Toolbox has not been successful in isolating a possible problem. Running diagnostics from the Rescue and Recovery...
Note: When the program finishes, be sure to remove the disc from the optical drive. 4. Select the diagnostic test you want to run. Press the F1 key for additional help. Navigating through the diagnostics programs Use the cursor movement keys to navigate within the menus. v The Enter key is used to select a menu item.
v Date: Contains the date when the diagnostic test was run. The date is retrieved from CMOS and displayed using the YYYYMMDD format. v ChkDigits: Contains a 2-digit check-digit value to ensure the following: – Diagnostics were run on the specified date. –...
Password considerations A password can be any combination of up to 64 (1 to 64) alphabetic and numeric characters. For security reasons, it is recommended to use a strong password that cannot be easily compromised. A strong password should adhere to the following rules: v Have at least eight characters in length and contain at least one alphabetic character and one numeric character...
Enabling or disabling a device This section provides information on how to enable or disable user access to the following devices: Serial ATA When this feature is set to Disabled, all devices connected to the SATA connectors (such as hard disk drives or the optical drive) are disabled and will not be displayed in the system configuration.
Selecting or changing the startup device sequence To view or permanently change the configured startup device sequence, do the following: 1. Start the Setup Utility program. See “Starting the Setup Utility program” on page 49. 2. Select Startup → Startup Sequence. See the information displayed on the right side of the screen.
Power Supply Problems If you suspect a power problem, use the following procedures. Check/Verify FRU/Action Check the following for proper installation. Reseat connectors v Power Cord v On/Off Switch connector v On/Off Switch Power Supply connector v System Board Power Supply connectors v Microprocessor(s) connection Check the power cord for continuity.
Page 61
Diagnostic Error Code FRU/Action 000-034-XXX 1. Reboot the system BIOS Buffer Allocation failure 2. Flash the system. See “Updating (flashing) BIOS from a disc” on page 746 3. Run memory test 4. System board 000-035-XXX 1. Flash the system. See “Updating BIOS Reset Condition detected (flashing) BIOS from a disc”...
Page 62
Diagnostic Error Code FRU/Action 000-250-XXX 1. Flash the system. See “Updating BIOS APM failure (flashing) BIOS from a disc” on page 2. System board 000-270-XXX 1. Flash the system. See “Updating BIOS ACPI failure (flashing) BIOS from a disc” on page 2.
Page 63
Diagnostic Error Code FRU/Action 001-040-XXX 1. Power-off/on system and re-test System IRQ failure 2. System board 001-041-XXX 1. Power-off/on system and re-test System DMA failure 2. System board 001-195-XXX Information only System Test aborted by user Re-start the test, if necessary 001-196-XXX 1.
Page 64
Diagnostic Error Code FRU/Action 001-271-XXX 1. Device on IRQ4 System IRQ4 failure 2. System board 001-272-XXX 1. Device on IRQ5 System IRQ5 failure 2. System board 001-273-XXX 1. Diskette Cable System IRQ6 2. Diskette drive (diskette drive) failure 3. System board 001-274-XXX 1.
Page 65
Diagnostic Error Code FRU/Action 001-301-XXX 1. Flash the system. See “Updating System RTC Century byte error (flashing) BIOS from a disc” on page 2. System board 005-000-XXX No action Video Test Passed 005-00X-XXX 1. Video card, if installed Video error 2.
Page 66
Diagnostic Error Code FRU/Action 005-197-XXX 1. Make sure the component that is called Video test warning out is connected and/or enabled. See Chapter 6, “Using the Setup Utility,” on page 49 2. Re-run test 3. Replace the component called out in warning statement 4.
Page 67
Diagnostic Error Code FRU/Action 006-199-XXX 1. Go to “Undetermined problems” on page Diskette interface test failed, cause unknown 2. Flash the system and re-test 3. Replace component under function test 006-25X-XXX 1. Diskette drive cable Diskette interface Error 2. Diskette drive 3.
Page 68
Diagnostic Error Code FRU/Action 011-198-XXX 1. If a component is called out, make sure Serial port test aborted it is connected and/or enabled. See Chapter 6, “Using the Setup Utility,” on page 49 2. Flash the system and re-test. See “Updating (flashing) BIOS from a disc”...
Page 69
Diagnostic Error Code FRU/Action 014-197-XXX 1. Make sure the component that is called Parallel port test warning out is connected and/or enabled. See Chapter 6, “Using the Setup Utility,” on page 49 2. Re-run test 3. Replace the component that is called out in warning statement 4.
Page 70
Diagnostic Error Code FRU/Action 015-036-XXX System board USB port Register error 015-040-XXX 1. Run setup and check for conflicts USB port IRQ failure 2. Flash the system. See “Updating (flashing) BIOS from a disc” on page 746 3. System board 015-195-XXX Information only USB port Test aborted by user...
Page 71
Diagnostic Error Code FRU/Action 018-197-XXX 1. Make sure the component that is called PCI Card test warning out is connected and/or enabled. See Chapter 6, “Using the Setup Utility,” on page 49 2. Re-run test 3. Replace the component that is called out in warning statement 4.
Page 72
Diagnostic Error Code FRU/Action 020-198-XXX 1. If a component is called out, make sure PCI test aborted it is connected and/or enabled. See Chapter 6, “Using the Setup Utility,” on page 49 2. Flash the system and re-test. See “Updating (flashing) BIOS from a disc” on page 746 3.
Page 73
Diagnostic Error Code FRU/Action 025-197-XXX 1. Make sure the component that is called IDE interface test warning out is connected and/or enabled. See Chapter 6, “Using the Setup Utility,” on page 49 2. Re-run test 3. Replace the component that is called out in warning statement 4.
Page 74
Diagnostic Error Code FRU/Action 030-197-XXX 1. Make sure the component that is called SCSI interface test warning out is connected and/or enabled. See Chapter 6, “Using the Setup Utility,” on page 49 2. Re-run test 3. Replace the component that is called out in warning statement 4.
Page 75
Diagnostic Error Code FRU/Action 035-198-XXX 1. If a component is called out, make sure RAID interface test aborted it is connected and/or enabled. See Chapter 6, “Using the Setup Utility,” on page 49 2. Flash the system and re-test. See “Updating (flashing) BIOS from a disc”...
Page 76
Diagnostic Error Code FRU/Action 071-198-XXX 1. If a component is called out, make sure Audio port test aborted it is connected and/or enabled. See Chapter 6, “Using the Setup Utility,” on page 49 2. Flash the system and re-test. See “Updating (flashing) BIOS from a disc”...
Page 77
Diagnostic Error Code FRU/Action 080-199-XXX 1. See “Undetermined problems” on page Game Port interface test failed, cause unknown 2. Flash the system and re-test. See “Updating (flashing) BIOS from a disc” on page 746 3. Replace component under function test 086-000-XXX No action Mouse Port interface Test Passed...
Page 78
Diagnostic Error Code FRU/Action 089-XXX-XXX 1. Microprocessor(s) Microprocessor failure 2. System board 089-195-XXX Information only Microprocessor Test aborted by user Re-start the test, if necessary 089-196-XXX 1. Press F3 to review the log file Microprocessor test halt, error threshold 2. Re-start the test to reset the log file exceeded 089-197-XXX 1.
Page 79
Diagnostic Error Code FRU/Action 170-198-XXX 1. If a component is called out, make sure Voltage Sensor(s) test aborted it is connected and/or enabled. See Chapter 6, “Using the Setup Utility,” on page 49 2. Flash the system and re-test. See “Updating (flashing) BIOS from a disc”...
Page 80
Diagnostic Error Code FRU/Action 175-199-XXX 1. See “Undetermined problems” on page Thermal Sensor(s) test failed, cause unknown 2. Flash the system and re-test. See “Updating (flashing) BIOS from a disc” on page 746 3. Replace component under function test 175-250-XXX 1.
Page 81
Diagnostic Error Code FRU/Action 217-25X-XXX 1. Hard Disk Drive Cable 217-26X-XXX 2. Check power supply voltages Hard Disk Drive (IDE) error 3. Reseat the hard disk drive cable 4. Hard Disk drive (IDE) 5. System board 217-28X-XXX 1. Hard Disk Drive Cable 217-29X-XXX 2.
Beep symptoms Beep symptoms are tones or a series of tones separated by pauses (intervals without sound) during POST. The following tables describes beep symptoms. Beep Symptom FRU/Action 2 short beeps Perform the following actions in order. CMOS setting error 1.
POST error codes Each time you power-on the system, it performs a series of tests that check the operation of the system and some options. This series of tests is called the Power-On Self-Test, or POST. POST does the following operations. v Checks some basic system-board operations v Checks the memory operation v Starts the video operation...
Page 84
POST Error Message Description/Action Press TAB to show POST screen Pressing the TAB key permits the user to toggle between the default POST display screen and a custom POST display screen. Error: Non-System disk or disk error The BIOS was unable to find a suitable boot Replace and press any key when ready device.
Miscellaneous error messages Message/Symptom FRU/Action Changing display colors Display/Monitor Computer will not power-off. See “Power 1. Power Switch Supply Problems” on page 54. 2. System Board 3. Riser card, if installed Computer will not RPL from server 1. Ensure that network is in startup sequence as first device or first device after diskette 2.
Message/Symptom FRU/Action Non-system disk or disk error-type message 1. Diskette Drive with a known-good diagnostic diskette. 2. System Board 3. Diskette Drive Cable Other display symptoms not listed above 1. Display (including blank or illegible display) 2. System Board Power-on indicator or hard disk drive in-use 1.
Page 87
d. Extended video memory e. External Cache f. External Cache RAM g. Hard disk drive h. Diskette drive 3. Turn on the power and the computer to re-test the system. 4. Repeat steps 1 through 3 until you find the failing device or adapter cards. If all devices and adapter cards have been removed, and the problem continues, replace the system board.
Locating connectors on the front of the computer The following illustration shows the location of the connectors on the front of your computer. Note: Not all computer models will have the following connectors. Figure 1. Front connector locations 1 USB connector 3 Microphone connector 2 Headphone connector 4 USB connector...
Locating connectors on the rear of the computer The following illustration shows the locations of the connectors on the rear of the computer. Figure 2. Rear connector locations 1 Voltage-selection switch (some 10 USB connectors (2) models) 2 Power cord connector 11 Microphone connector 3 Standard mouse connector 12 Audio line-out connector...
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to remove the computer cover.
Page 93
6. Press the cover-release button on the side of the computer cover and slide the computer cover to the rear to remove. Figure 3. Removing the computer cover Chapter 8. Replacing FRUs - Tower computers...
Locating parts on the system board Figure 5 shows the location of parts on the system board. Figure 5. System board parts locations 1 Microprocessor 15 Front USB connector 1 2 Microprocessor fan connector 16 Front USB connector 2 3 Memory slot 1 17 Clear CMOS/Recovery jumper 4 Memory slot 2 18 Serial (COM2) connector...
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to remove and reinstall the front bezel.
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to replace a memory module.
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to replace the power supply.
Page 99
7. Install the four screws to secure the power supply. Note: Use only screws provided by Lenovo. 8. Reconnect the power supply connectors to the system board. 9. Reconnect a power supply connector to each of the drives.
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to replace the heat sink and fan assembly.
Page 101
5. Remove the four screws 1 that secure the heat sink and fan assembly to the system board. Figure 10. Removing the heat sink and fan assembly 6. Lift the failing heat sink and fan assembly off the system board. Note: You might have to gently twist the heat sink and fan assembly to free it from the microprocessor.
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to replace the microprocessor. CAUTION: The heat sink and microprocessor might be very hot.
Page 103
7. Lift the small handle 3 and open the retainer 1 to access the microprocessor 2 . Figure 11. Accessing the microprocessor 8. Lift the microprocessor straight up and out of the socket. Notes: a. Your microprocessor and socket might look different from the one illustrated.
Page 104
Figure 12. Removing the microprocessor 9. Make sure that the small handle is in the raised position and the microprocessor retainer is fully open. 10. Remove the protective cover 2 that protects the gold contacts on the new microprocessor 1 . 11.
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to replace the system board.
Page 106
5. Press the release tab 1 down, slide the hard drive cage 2 back, and pivot the hard disk drive outward as shown. 6. Carefully take note of the location of all cable connections on the system board and disconnect all cables. See “Locating parts on the system board” on page 89.
Page 107
The failing system board must be returned with a microprocessor socket cover to protect the pins during shipping and handling. To install the microprocessor socket cover: 1. Remove the microprocessor from the microprocessor socket. See “Replacing the microprocessor” on page 96. 2.
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to replace the battery. Your computer has a special type of memory that maintains the date, time, and settings for built-in features, such as parallel-port assignments (configuration).
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to replace an adapter card.
Page 110
2. At the rear of the computer, press the release button 1 to open the adapter latch 2 and remove the adapter card by pulling it straight out of the adapter card slot. Figure 17. Removing the adapter card Notes: a.
Page 111
b. If the adapter card is held in place by a retaining latch, press the adapter card retaining latch 1 downwards to disengage the latch. Grasp the adapter card and then gently pull the adapter card out of the slot. 3.
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to replace the primary hard disk drive if your computer has one.
Page 113
4. Press the blue release tab 1 down, slide the hard disk drive cage 2 back, and pivot it outward. Figure 19. Removing the primary hard disk drive 5. Remove the hard disk drive cage from the chassis by simply sliding it outward.
Page 114
7. Remove the hard disk drive from the blue plastic bracket by flexing the sides of the bracket enough to slide it free of the hard disk drive. 8. To install the new hard disk drive into the blue bracket, flex the bracket and align pin 1 , pin 2 , pin 3 , and pin 4 on the bracket with the holes in the hard disk drive.
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support Note: Depending on your model type, your computer might come with a secondary hard disk drive bay for installing or replacing a secondary hard disk drive.
Page 116
Important When you receive a new hard disk drive, you also receive a set of Product Recovery discs. The set of Product Recovery discs enables you to restore the contents of the hard disk drive to the factory-installed state. For more information on recovering factory-installed software, refer to “Recovering software”...
Page 117
8. To install the new hard disk drive into the blue bracket, flex the bracket and align pin 1 , pin 2 , pin 3 , and pin 4 on the bracket with the holes in the hard disk drive. Do not touch the circuit board 5 on the bottom of the hard disk drive.
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to replace the optical drive.
Page 119
3. Press the blue release button and remove the optical drive out the front of the computer. Note: There is a spare retainer bracket 1 attached to the side of the upper drive cage. Figure 25. Removing the optical drive 4.
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to replace the diskette drive.
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to replace the front fan assembly.
Page 122
4. The front fan assembly is attached to the chassis by four rubber mounts. Remove the front fan assembly by breaking or cutting the rubber mounts and gently pulling the front fan assembly out of the chassis. Figure 29. Removing the front fan assembly 5.
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to replace the rear fan assembly.
Page 124
4. The rear fan assembly is attached to the chassis by four rubber mounts. Remove the rear fan assembly by breaking or cutting the rubber mounts and gently pulling the rear fan assembly out of the chassis. Figure 31. Removing the rear fan assembly 5.
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to replace the front audio and USB assembly.
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to replace the internal speaker.
Page 127
4. Push the metal tab on the top of the internal speaker outward and slide the internal speaker upward to completely remove it from the chassis. Figure 34. Removing the internal speaker Chapter 8. Replacing FRUs - Tower computers...
5. Position the new internal speaker into the metal clips and push downward on the new internal speaker until it snaps into position. Figure 35. Replacing the internal speaker 6. Connect the cable of the new internal speaker to the system board. See “Locating parts on the system board”...
Page 129
2. Position the computer cover on the chassis so that the rail guides on the bottom of the computer cover engage the rails. Then, push the computer cover closed until it snaps into position. Figure 36. Replacing the computer cover 3.
Locating connectors on the front of the computer Figure 37 shows the location of the connectors on the front of the computer. Note: Not all computer models have the following connectors. Figure 37. Front connector locations 1 USB connector 3 Headphone connector 2 Microphone connector 4 USB connector Hardware Maintenance Manual...
Locating connectors on the rear of the computer Figure 38 shows the location of connectors on the rear of the computer. Some connectors on the rear of the computer are color-coded to help you determine where to connect the cables on your computer. Figure 38.
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to open the computer cover.
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to access the system board components and drives.
Locating components To open the computer cover, see “Opening the computer cover” on page 128. Figure 41 shows the location of the various components in your computer. Figure 41. Component locations 1 Hard disk drive 4 Optical drive 2 Microprocessor, heat sink and fan 5 Memory slots (4) assembly 3 Internal speaker...
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to replace the battery. Your computer has a special type of memory that maintains the date, time, and settings for built-in features, such as parallel-port assignments (configuration).
Page 138
The battery normally requires no charging or maintenance throughout its life; however, no battery lasts forever. If the battery fails, the date, time, and configuration information (including passwords) are lost. An error message is displayed when you turn on the computer. Refer to the “Lithium battery notice”...
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to replace a memory module. Your computer can support a maximum of four memory modules.
Page 140
4. Remove the memory module being replaced by opening the retaining clips as shown. Figure 45. Removing the memory module 5. Position the replacement memory module over the memory slot. Make sure the notch 1 on the memory module aligns correctly with the slot key 2 on the system board.
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to replace an adapter card.
Page 142
Figure 47. Removing the old adapter card 3. Remove the new adapter card from its static-protective package. 4. Install the new adapter card into the adapter card slot and ensure the adapter card is fully seated into the adapter card slot. Figure 48.
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to replace the power supply.
Page 144
2. Open the computer cover. See “Opening the computer cover” on page 128. 3. Pivot the drive bay assembly upward to gain access to the power supply. 4. Locate the power supply. See “Locating components” on page 130. 5. Disconnect the power supply cables from the power connectors 1 and 2 and from all drives.
Page 145
8. Install the new power supply into the chassis so that the screw holes in the power supply align with those in the chassis. Note: Use only the screws provided by Lenovo. 9. Install and tighten the four screws at the rear of the chassis to secure the power supply.
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to replace the heat sink and fan assembly.
Page 147
4. Remove the heat sink and fan assembly from the system board by pivoting the lever 1 securing the heat sink and fan assembly until it is fully in the up position. Carefully lift the heat sink and fan assembly off the system board. Note: It helps to remove the hard disk drive before this step.
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to replace the microprocessor. CAUTION: The heat sink and microprocessor might be very hot.
Page 149
7. Lift the small handle 3 and open the retainer 1 to access the microprocessor 2 . Figure 53. Accessing the microprocessor 8. Lift the microprocessor straight up and out of the socket. Notes: a. Your microprocessor and socket might look different from the one illustrated.
Page 150
Figure 54. Removing the microprocessor 9. Make sure that the small handle is in the raised position and the microprocessor retainer is fully open. 10. Remove the protective cover 2 that protects the gold contacts on the new microprocessor 1 . Hardware Maintenance Manual...
Page 151
11. Hold the new microprocessor and align the notches on it with the tabs in the microprocessor socket, or align the small triangle on one corner with the corresponding beveled corner of the microprocessor socket. 12. Lower the new microprocessor straight down into the microprocessor socket on the system board.
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to replace the system board.
Page 153
The failing system board must be returned with a microprocessor socket cover to protect the pins during shipping and handling. To install the microprocessor socket cover: 1. Remove the microprocessor from the microprocessor socket. See “Replacing the microprocessor” on page 142. 2.
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to replace the hard disk drive if your computer has one.
Page 155
4. Push the blue handle of the hard disk drive bracket inwards to release the two clips 1 that secure the hard disk drive to the chassis. Rotate the hard disk drive upwards and lift up to remove the hard disk drive from the computer. Figure 57.
Page 156
7. To install the new drive into the bracket, flex the bracket and align pin 1 , pin 2 , pin 3 , and pin 4 on the bracket with the holes in the hard disk drive. Important Do not touch the circuit board on the bottom of the hard disk drive. Figure 58.
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to replace the optical drive.
Page 158
5. Remove the optical drive retainer from the old optical drive and then install it on the left side of the new optical drive. Figure 60. Installing the retainer 6. Install the new optical drive into the bay until it snaps into position. Figure 61.
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to replace the card reader.
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to replace the internal speaker.
Page 161
6. Push the four tabs 1 on the bottom of the internal speaker 2 one by one as shown to release the internal speaker, and then lift the internal speaker straight up to completely remove it from the chassis. Figure 64. Removing the internal speaker 7.
Page 162
8. Align the four tabs on the bottom of the new internal speaker with the corresponding holes in the chassis, and push the new internal speaker straight down until it snaps into position. Note: Carefully place the thermal sensor cable so that it will not impede installing the new internal speaker.
“Important safety information” in the ThinkCentre Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkCentre Safety and Warranty Guide, go to: http://www.lenovo.com/support This section provides instructions on how to replace the front audio and USB assembly.
6. Remove the screw that secures the front audio and USB assembly to the chassis. Figure 66. Removing the securing screw of the front audio and USB assembly 7. Remove the front audio and USB assembly from the chassis. 8. Install a new front audio and USB assembly into the chassis and align the screw hole in the new front audio and USB assembly with the hole in the chassis.
Page 165
Note: When the power cord is first plugged in, the computer might appear to turn on for a few seconds and then turn off. This is a normal sequence to enable the computer to initialize. To complete the FRUs replacement: 1.
Page 192
Chassis Mech Kit Asm (all models) 45J9520 Air Deflector, recycle resin (all models) 43N9610 6137 Keyboards (Lenovo Preferred Pro USB -- without hub) FRU # USB FULL--US English (models A1U A1L A1G A1M A1A A1Q A1H A1R A1E A2U A2L 41A5289...
Page 193
6137 Keyboards (Lenovo Preferred Pro USB -- without hub) FRU # USB FULL--Romanian (models A1G A2GA3G) 41A5316 USB FULL--Romanian (models A1G A2GA3G) 41A5317 USB FULL--Russian/Cyrillic (models A1G A2GA3G) 41A5318 USB FULL--Serbian/Cyrillic (models A1G A2GA3G) 41A5319 USB FULL--Slovak (models A1G A2GA3G)
Page 194
Turkish (models) 41R0075 UK English (models) 41R0076 US Euro (models) 41R0077 Slovenian (models) 41R0078 6137 Keyboards (Lenovo Preferred Pro PS/2 Full Size) FRU # PS/2 Full--US English (models) 41A5039 PS/2 Full--Arabic (models) 41A5040 PS/2 Full--Arabic/French (models) 41A5041 PS/2 Full--Belgium French (models)
Page 196
6137 Adapters and miscellaneous FRUs FRU # Speaker Power brick - Japanese (models A1J A2JA3J) 89P8577 Speaker Power brick - Brazil (models) 89P8583 Speaker Power brick - Argentina (models) 41A4901 Speaker Power brick - ANZ (models A1M A2MA3M) 89P8579 Speaker Power brick - Korea (models) 41A4903 Speaker Power brick - Hong Kong, EMEA (models A1G A2GA3G) 89P8573...
Page 197
6137 Power Cords (Secondary) FRU # Power cord - China (models A1C A2CA3C) 41R3257 Power cord - Japan (models A1E A1J A2E A2JA3E A3J) 41R3249 Power cord - Brazil (models) 41R3271 Power cord - LA High Volt (APU) (models) 41R3177 Power cord - ANZ (models A1U A1F A1S A1L A1Y A1A A1T A2U A2F A2S A2L A2Y A2A 41R3197 A2T A3U A3F A3S A3L A3Y A3A A3T)
Page 198
6137 Windows XP Home Recovery CDs FRU # Simplified Chinese (models) Taiwan-TC (models) Hong Kong-TC (models) Korean (models) 6137 Windows XP Pro Recovery CDs FRU # US English (models) 53Y7073 French (models) 53Y7074 German (models) 53Y7075 Italian (models) 53Y7078 Brazilian Portuguese (models) 53Y7077 Spanish (models) 53Y7076...
Page 199
6137 Vista Home Basic 32 Recovery DVDs FRU # Brazilian (models) 53Y7217 Italian (models) 53Y9470 Japanese (models) 53Y7225 Norwegian (models) Swedish (models) Danish (models) Dutch (models) 53Y7232 Czech (models) 53Y7219 Finnish (models) Polish (models) 53Y7220 Russian (models) 53Y7221 Turkish (models) 53Y7222 Hungarian (models) 53Y7223...
Page 201
6137 Vista Home Premium 32 Recovery DVDs FRU # Finnish (models) Polish (models) Russian (models) Turkish (models) Hungarian (models) Greek (models) Simplified Chinese (models) Traditional Chinese (models) Hong Kong - Traditional Chinese (models) Korean (models) Slovenian (models) Hebrew (models) Romanian (models) Bulgarian (models) Croatian (models) Portuguese (models)
Page 202
6137 Vista Business 64 Recovery DVDs FRU # Hong Kong - Traditional Chinese (models) Korean (models) Slovenian (models) Portuguese (models) Arabic Localized (models) Hebrew (models) Slovakian (models) 6137 Vista Ultimate 32 Recovery DVDs FRU # US English (models) 53Y7241 Japanese (models) 53Y7246 Simplified Chinese (models) French (models)
Page 205
Item # 6138 FRUs FRU # Hard disk drive, SATA 150GB 10KRPM/3GB/16M (models) 46R6400 System board, GA Level (PCB 1.1) Intel Q45 (models A1U A1F A1S A1P A1L A1D 64Y4486 A1Y A1G A1M A1A A1Q A1T A1C A1B A1H A1V A1K A1R A1E A1J) System board, Russian only Intel Q45 (GIGA) TPM Disable (models) 64Y5546 4 Pin System Fan (all models)
Page 206
Temp Sense Cable (6pin 460 mm) kit w/ bracket (all models) 45J9495 1.8 SSD to 3.5 HDD Conversion Kit, no bezel, with PCB (all models) 43N9593 6138 Keyboards (Lenovo Preferred Pro USB - without hub) FRU # US English (models A1U A1L A1G A1M A1A A1Q A1H A1R A1E) 41A5289...
Page 207
6138 Keyboards (Lenovo Preferred Pro USB - without hub) FRU # Turkish (models A1G) 41A5326 UK English (models A1G) 41A5327 US Euro (models A1G) 41A5328 Slovenian (models A1G) 41A5329 Arabic (New) (models A1G) 45J4880 Lithuanian (models A1G) 45J4896 6138 Keyboards (Lenovo Fingerprint Reader USB)
Page 208
Turkish (models) 41R0075 UK English (models) 41R0076 US Euro (models) 41R0077 Slovenian (models) 41R0078 6138 Keyboards (Lenovo Preferred Pro PS/2 Full Size) FRU # PS/2 Full--US English (models) 41A5039 PS/2 Full--Arabic (models) 41A5040 PS/2 Full--Arabic/French (models) 41A5041 PS/2 Full--Belgium French (models)
Page 210
6138 Adapters and miscellaneous FRUs FRU # Dongle DMS-59 to dual VGA cable (models) 42Y8181 Dongle DMS-59 to dual DVI - I cable (models) 41X6398 New Casper DVI-D card low profile support HDCP (models) 43C0258 Display port to VGA dongle (models) 45J9524 6138 Power Cords (Primary) FRU #...
Page 211
6138 Power Cords (Secondary) FRU # Power cord - Thailand (models A1T) 43N9030 6138 Windows XP Home Recovery CDs FRU # US English/UK/Asia Pacific (models) French/French Canadian (models) Greek (models) Italy (models) Brazilian (models) Spanish/LA (models) Danish (models) Dutch (models) Arabic (models) SV (Swedish) (models) Hebrew (models)
Page 212
6138 Windows XP Pro Recovery CDs FRU # Hebrew (models) 53Y7086 Finnish (models) 53Y7085 Norwegian (models) 53Y7080 Polish (models) 53Y7087 Portuguese (models) 53Y7094 Russian (models) 53Y7089 Russian English (models) 63Y8271 Hungarian (models) 53Y7092 Czech (models) 53Y7084 Turkish (models) 53Y7091 Greek (models) 53Y7093 Slovakian (models) 53Y7095...
Page 213
6138 Vista Home Basic 32 Recovery DVDs FRU # Simplified Chinese (models) 53Y7226 Traditional Chinese (models) 53Y7227 Korean (models) 53Y7229 Slovenian (models) 53Y7230 Russian English (models) 53Y7213 Hebrew (models) 53Y7233 Arabic Localized (models) 53Y7231 Slovakian (models) 53Y7237 Romanian (models) 53Y7234 Serbian-Latin (models) 53Y7236 C&L 1 Nordics (EN DK FI NO SV) (models)
Page 214
6138 Vista Business 32 Recovery DVDs FRU # Croatian (models A1G ) Serbian-Latin (models A1G ) 53Y7178 Ukrainian (models A1G ) Slovakian (models A1G ) 53Y7179 Arabic Localized (models A1G ) 53Y7173 Hebrew (models A1G ) 53Y7175 C&L 1 Nordics (EN DK FI NO SV) (models A1G ) 53Y7180 C&L 2 Switzerland (EN FR GR IT) (models A1F A1G ) 53Y7181...
Page 215
6138 Vista Home Premium 32 Recovery DVDs FRU # Ukrainian (models) Slovakian (models) 6138 Vista Business 64 Recovery DVDs FRU # Russian English (models) 53Y7250 Russian French (models) 53Y7251 German (models) 53Y7252 Spanish (models) Brazilian Portuguese (models) Italian (models) Japanese (models) 53Y7253 Norwegian (models) Swedish (models)
Page 216
6138 Vista Ultimate 32 Recovery DVDs FRU # Danish (models) Swedish (models) Finland (models) Dutch (models) Traditional Chinese (models) Hong Kong - Traditional Chinese (models) 53Y7247 Norwegian (models) Korean (models) Slovenian (models) Greek (models) Russian (models) Portuguese (models) Turkish (models) Czech (models) Polish (models) Russian English (models)
Page 219
Item # 6209 FRUs FRU # Hard disk drive, SATA 150GB 10KRPM/3GB/16M (models) 46R6400 System board, GA Level (PCB 1.1) Intel Q45 (models A1U A1F A1S A1P A1L A1D 64Y4486 A1Y A1G A1M A1A A1Q A1T A1C A1B A1H A1V A1K A1R A1E A1J) System board, Russian only Intel Q45 (GIGA) TPM Disable (models) 64Y5546 4 Pin System Fan (all models)
Page 220
Temp Sense Cable (6pin 460 mm) kit w/ bracket (all models) 45J9495 1.8 SSD to 3.5 HDD Conversion Kit, no bezel, with PCB (all models) 43N9593 6209 Keyboards (Lenovo Preferred Pro USB - without hub) FRU # US English (models A1U A1L A1G A1M A1A A1Q A1H A1R A1E) 41A5289...
Page 221
6209 Keyboards (Lenovo Preferred Pro USB - without hub) FRU # Turkish (models A1G) 41A5326 UK English (models A1G) 41A5327 US Euro (models A1G) 41A5328 Slovenian (models A1G) 41A5329 Arabic (New) (models A1G) 45J4880 Lithuanian (models A1G) 45J4896 6209 Keyboards (Lenovo Fingerprint Reader USB)
Page 222
Turkish (models) 41R0075 UK English (models) 41R0076 US Euro (models) 41R0077 Slovenian (models) 41R0078 6209 Keyboards (Lenovo Preferred Pro PS/2 Full Size) FRU # PS/2 Full--US English (models) 41A5039 PS/2 Full--Arabic (models) 41A5040 PS/2 Full--Arabic/French (models) 41A5041 PS/2 Full--Belgium French (models)
Page 224
6209 Adapters and miscellaneous FRUs FRU # Dongle DMS-59 to dual VGA cable (models) 42Y8181 Dongle DMS-59 to dual DVI - I cable (models) 41X6398 New Casper DVI-D card low profile support HDCP (models) 43C0258 Display port to VGA dongle (models) 45J9524 6209 Power Cords (Primary) FRU #...
Page 225
6209 Power Cords (Secondary) FRU # Power cord - Thailand (models A1T) 43N9030 6209 Windows XP Home Recovery CDs FRU # US English/UK/Asia Pacific (models) French/French Canadian (models) Greek (models) Italy (models) Brazilian (models) Spanish/LA (models) Danish (models) Dutch (models) Arabic (models) SV (Swedish) (models) Hebrew (models)
Page 226
6209 Windows XP Pro Recovery CDs FRU # Hebrew (models) 53Y7086 Finnish (models) 53Y7085 Norwegian (models) 53Y7080 Polish (models) 53Y7087 Portuguese (models) 53Y7094 Russian (models) 53Y7089 Russian English (models) 63Y8271 Hungarian (models) 53Y7092 Czech (models) 53Y7084 Turkish (models) 53Y7091 Greek (models) 53Y7093 Slovakian (models) 53Y7095...
Page 227
6209 Vista Home Basic 32 Recovery DVDs FRU # Simplified Chinese (models) 53Y7226 Traditional Chinese (models) 53Y7227 Korean (models) 53Y7229 Slovenian (models) 53Y7230 Russian English (models) 53Y7213 Hebrew (models) 53Y7233 Arabic Localized (models) 53Y7231 Slovakian (models) 53Y7237 Romanian (models) 53Y7234 Serbian-Latin (models) 53Y7236 C&L 1 Nordics (EN DK FI NO SV) (models)
Page 228
6209 Vista Business 32 Recovery DVDs FRU # Croatian (models A1G ) Serbian-Latin (models A1G ) 53Y7178 Ukrainian (models A1G ) Slovakian (models A1G ) 53Y7179 Arabic Localized (models A1G ) 53Y7173 Hebrew (models A1G ) 53Y7175 C&L 1 Nordics (EN DK FI NO SV) (models A1G ) 53Y7180 C&L 2 Switzerland (EN FR GR IT) (models A1F A1G ) 53Y7181...
Page 229
6209 Vista Home Premium 32 Recovery DVDs FRU # Ukrainian (models) Slovakian (models) 6209 Vista Business 64 Recovery DVDs FRU # Russian English (models) 53Y7250 Russian French (models) 53Y7251 German (models) 53Y7252 Spanish (models) Brazilian Portuguese (models) Italian (models) Japanese (models) 53Y7253 Norwegian (models) Swedish (models)
Page 230
6209 Vista Ultimate 32 Recovery DVDs FRU # Danish (models) Swedish (models) Finland (models) Dutch (models) Traditional Chinese (models) Hong Kong - Traditional Chinese (models) 53Y7247 Norwegian (models) Korean (models) Slovenian (models) Greek (models) Russian (models) Portuguese (models) Turkish (models) Czech (models) Polish (models) Russian English (models)
Page 233
Chassis Mech Kit Asm (all models) 45J9520 Air Deflector, recycle resin (all models) 43N9610 6234 Keyboards (Lenovo Preferred Pro USB -- without hub) FRU # USB FULL--US English (models A1U A1L A1G A1M A1A A1Q A1H A1R A1E) 41A5289 USB FULL--Arabic (models A1G) 41A5290 Chapter 10.
Page 234
6234 Keyboards (Lenovo Preferred Pro USB -- without hub) FRU # USB FULL--Arabic/French (models A1G) 41A5291 USB FULL--Belgian/French (models A1G) 41A5292 USB FULL--Belgium English (models A1G) 41A5293 USB FULL--Brazilian Portuguese (models A1P) 41A5294 USB FULL--Bulgarian (models A1G) 41A5295 USB FULL--Chinese/US (models A1B A1V)
Page 235
6234 Keyboards (Lenovo Fingerprint Reader USB) FRU # US English (models) 41R0038 Arabic (models) 41R0039 Arabic/French (models) 41R0040 Belgium French (models) 41R0041 Belgium English (models) 41R0042 Brazilian Portuguese (models) 41R0043 Bulgarian (models) 41R0044 Chinese/US (models) 41R0045 Czech (ABB) (models) 41R0046...
Page 236
6234 Keyboards (Lenovo Fingerprint Reader USB) FRU # Slovenian (models) 41R0078 6234 Keyboards (Lenovo Preferred Pro PS/2 Full Size) FRU # PS/2 Full--US English (models) 41A5039 PS/2 Full--Arabic (models) 41A5040 PS/2 Full--Arabic/French (models) 41A5041 PS/2 Full--Belgium French (models) 41A5042 PS/2 Full--Belgium English (models)
Page 238
6234 Power Cords (Primary) FRU # Power cord - Japan (models A1E A1J) 41R3248 Power cord - Brazil (models) 41R3270 Power cord - LA High Volt (APU) (models) 41R3176 Power cord - ANZ (models A1U A1F A1S A1L A1Y A1A A1T) 41R3196 Power cord - Korea (models) 41R3260...
Page 239
6234 Windows XP Home Recovery CDs FRU # Spanish/LA (models) Danish (models) Dutch (models) Arabic (models) SV (Swedish) (models) Hebrew (models) Finnish (models) Norwegian (models) Polish (models) Portuguese (models) Russian (models) Russian English (models) Hungarian (models) Czech (models) Turkish native (models) Greek (models) Japanese (models) Simplified Chinese (models)
Page 240
6234 Windows XP Pro Recovery CDs FRU # Czech (models) 53Y7084 Turkish (models) 53Y7091 Greek (models) 53Y7093 Slovakian (models) 53Y7095 Japanese (models) 53Y7079 Simplified Chinese (models) 53Y7096 Taiwan-TC (models) 53Y7097 Hong Kong-TC (models) 53Y7098 Korean (models) 53Y7099 Multilingual 1 XP Pro -- English, Dutch, French, German, Italian (models) Multilingual 2 XP Pro -- English, Danish, Finland, Norwegian, Swedish (models) 6234 Vista Home Basic 32 Recovery DVDs FRU #...
Page 241
6234 Vista Home Basic 32 Recovery DVDs FRU # Romanian (models) 53Y7234 Serbian-Latin (models) 53Y7236 C&L 1 Nordics (EN DK FI NO SV) (models) 53Y7238 C&L 2 Switzerland (EN FR GR IT) (models) 53Y7239 C&L 3 Bel Lux (EN FR GR NL) (models) 53Y7240 6234 Vista Business 32 Recovery DVDs FRU #...
Page 242
6234 Vista Business 32 Recovery DVDs FRU # C&L 3 Bel Lux (EN FR GR NL) (models A1F A1G) 53Y7182 6234 Vista Home Premium 32 Recovery DVDs FRU # US English (models) Russian English (models) French (models) German (models) Spanish (models) Brazilian Portuguese (models) Italian (models) Japanese (models)
Page 243
6234 Vista Business 64 Recovery DVDs FRU # Brazilian Portuguese (models) Italian (models) Japanese (models) 53Y7253 Norwegian (models) Swedish (models) Danish (models) Dutch (models) Czech (models) Finnish (models) Polish (models) Russian (models) Turkish (models) Hungarian (models) Greek (models) Simplified Chinese (models) 53Y7254 Traditional Chinese (models) Hong Kong - Traditional Chinese (models)
Page 244
6234 Vista Ultimate 32 Recovery DVDs FRU # Slovenian (models) Greek (models) Russian (models) Portuguese (models) Turkish (models) Czech (models) Polish (models) Russian English (models) Arabic Localized (models) 53Y7248 Hebrew (models) Hungarian (models) Slovakian (models) C&L 1 Nordics (EN DK FI NO SV) (models) 53Y7249 6234 Vista Starter 32 Recovery DVDs FRU #...
Page 247
Item # 6239 FRUs FRU # Optical drive, DVD-ROM 16X Max SATA (models ACU ACF ACS ACP A1G A5C 41N3325 A6C A7C A8C A9C ABC 91S 91P 91L 91D 91Y 91V) Optical drive, DVD Recordable SATA/CD-RW Rambo 8 - SATA Vista & non-Vista 43C1042 (models A4H AHM AHA AHQ AHT AHK AHJ AJM AJA AJQ AJT AJK AJJ ADU ADF ADS ADP AEU AEF AES AEP AFU AFF AFS AFP A2G A3G 91S 91P 91L 91D...
Page 248
Item # 6239 FRUs FRU # Power supply, 450 Watt ATX Power Supply (80plus) - WW, Robust, JP (models 41A9721 A4H AHM AHA AHQ AHT AHK AHJ AJM AJA AJQ AJT AJK AJJ ACU ACF ACS ACP ADU ADF ADS ADP AEU AEF AES AEP AFU AFF AFS AFP A1G A2G A3G A5C A6C A7C A8C A9C ABC 91S 91P 91L 91D 91Y 91VAKG ALU ALF AMU AMF ANU ANF APU APF APS APP APL APD APY APG APM APA APQ APT APC APB APH APV APK APR APE APJ AQU AQF ARU ARF)
Page 249
1.8 SSD to 3.5 HDD Conversion Kit, no bezel, with PCB (all models) 43N9593 6239 Keyboards (Lenovo Preferred Pro USB - without hub) FRU # US English (models A4H AHM AHA AHQ AJM AJA AJQ ACU ADU AEU AFU A1G A2G...
Page 256
6239 Windows XP Pro Recovery CDs FRU # Multilingual 2 XP Pro -- English, Danish, Finland, Norwegian, Swedish (models 91S 91P 91L 91D 91Y 91V) 6239 Vista Home Basic 32 Recovery DVDs FRU # US English (models 91S 91P 91L 91D 91Y 91V) 53Y7212 French (models 91S 91P 91L 91D 91Y 91V) 53Y7214...
Machine Type 6258 Item # 6258 FRUs FRU # Hard disk drive, SATA 160GB 7200RPM/3Gb/8MB (models AFM AFA AFQ AFT 40Y9035 AFK AFJ A7U A7F A7S A7P A8U A8F A8S A8P A9U A9F A9S A9P ABU ABF ABS ABP ACU ACF ACS ACP A5C 91S 91P 91L 91D 91Y 91V AJU AJF AKU AKF ALU ALF AMU AMF ANU ANF ARU ARF ARS ARP ARL ARD ARY ARG ARM ARA ARQ ART ARC ARB ARH ARV ARK ARR ARE ARJ ASU ASF AUU AUF) Hard disk drive, SATA 250GB 7200RPM/3Gb/8MB (models A4H ADU ADF ADS...
Page 269
6258 Adapters and miscellaneous FRUs FRU # Nvidia FX370 256MB 64BIT DMS59 LP Video card (models) 64Y4565 Dongle DMS-59 to single VGA & single DVI cable (models) 42Y8183 Dongle DMS-59 to dual VGA cable (models) 42Y8181 Dongle DMS-59 to dual DVI - I cable (models) 41X6398 New Casper DVI-D card low profile support HDCP (models) 43C0258...
Page 270
6258 Power Cords (Secondary) FRU # Power cord - ANZ (models AFA AFT AGA A7U A7F A7S A8U A8F A8S A9U A9F A9S 41R3197 ABU ABF ABS ACU ACF ACS ADU ADF ADS AEU AEF AES91S 91P 91L 91D 91Y 91V AJU AJF AKU AKF ALU ALF AMU AMF ANU ANF APU APF AQU AQF ARU ARF ARS ARL ARY ARA ART ASU ASF) Power cord - Korea (models91S 91P 91L 91D 91Y 91V)
Page 271
6258 Windows XP Home Recovery CDs FRU # Taiwan-TC (models 91S 91P 91L 91D 91Y 91V) Hong Kong-TC (models91S 91P 91L 91D 91Y 91V) Korean (models 91S 91P 91L 91D 91Y 91V) 6258 Windows XP Pro Recovery CDs FRU # US English (models 91S 91P 91L 91D 91Y 91V) 53Y7073 French (models 91S 91P 91L 91D 91Y 91V)
Page 339
Item # 7188 FRUs FRU # Optical drive, DVD Recordable SATA/CD-RW Rambo 8 - SATA Vista & non-Vista 43C1042 (models A3H A7J AFM AFA AFQ AFT AFK AFJ AGM AGA AGJ ABU ABF ABS ABP AEU AEF AES AEP A1G A2G A6C 91S 91P 91L 91D 91Y 91V AHU AHF AJU AJF) Optical drive, Blu-Ray DVD Burner (SATA) (models 91S 91P 91L 91D 91Y 91V) 43C9584...
Page 340
1.8 SSD to 3.5 HDD Conversion Kit, no bezel, with PCB (all models) 43N9593 7188 Keyboards (Lenovo Preferred Pro USB - without hub) FRU # US English (models A3H AFM AFA AFQ AGM AGA A8U A9U ABU ACU ADU AEU...
Page 341
7188 Keyboards (Lenovo Preferred Pro USB - without hub) FRU # Dutch (models A1G A2G 91S 91P 91L 91D 91Y 91V) 41A5299 French (models A1G A2G 91S 91P 91L 91D 91Y 91V) 41A5300 French Canadian (models A8F A9F ABF ACF ADF AEF A1G A2G 91S 91P 91L 91D 91Y...
Page 342
US Euro (models 91S 91P 91L 91D 91Y 91V) 41R0077 Slovenian (models 91S 91P 91L 91D 91Y 91V) 41R0078 7188 Keyboards (Lenovo Preferred Pro PS/2 Full Size) FRU # PS/2 Full--US English (models 91S 91P 91L 91D 91Y 91V) 41A5039...
Page 485
DP to DVI dongle 200mm (models 91C) 43N9160 IEEE 1394 Firewire Adapter (LP) (models 91C) 41D2781 Speakers (2-piece) Lenovo Logo (Primary) (models 91C) 41A5331 Speakers (2-piece) Lenovo Logo (Secondary) (models 91C) 41A5334 Speaker Power brick - US, Canada, LA low voltage, ASEAN (models AJU AKU ALU APU...
Page 486
7360 Adapters and miscellaneous FRUs FRU # Thermal Grease Syringe (models 91C) 91P8835 NVIDIA FX370 256MB 64BIT DMS59 LP Video card (models) 64Y4565 Dongle DMS-59 to single VGA & single DVI cable (models) 42Y8183 Dongle DMS-59 to dual VGA cable (models) 42Y8181 Dongle DMS-59 to dual DVI - I cable (models) 41X6398...
Page 487
7360 Power Cords (Secondary) FRU # Power cord - US (models A6S A6Y BCA BCT BDA BDT ABA ABT ACA ACT AVA AVT 41R3185 AWA AWT B1A B1T B2A B2T B3A B3T B4A B4T B5A B5T B6A B6T B7A B7T BAA BAT AJU AJF AKU AKF ALU ALF APU APF AQU AQF ARU ARF A8S A8Y ADU ADF BES BEY BFS BFY BGS BGY BHS BHY 91C BRS BRY BSS BSY BTS BTY BPA BQA BQT BMA BNA BNT BJA BJT BKA BKT BLA BLT BVU BVF BWU BWF D1U D1F D2U D2F D3U D3F...
Page 488
7360 Windows XP Home Recovery CDs FRU # Finnish (models 91C) Norwegian (models 91C) Polish (models 91C) Portuguese (models 91C) Russian (models 91C) Russian English (models 91C) Hungarian (models 91C) Czech (models 91C) Turkish native (models 91C) Greek (models 91C) Japanese (models 91C) Simplified Chinese (models 91C) Taiwan-TC (models 91C)
Page 489
7360 Windows XP Pro Recovery CDs FRU # Simplified Chinese (models 91C) 53Y7096 Taiwan-TC (models 91C) 53Y7097 Hong Kong-TC (models 91C) 53Y7098 Korean (models 91C) 53Y7099 Multilingual 1 XP Pro -- English, Dutch, French, German, Italian (models 91C BVF BWF D1F D2F D3F D4F D5F D6F D8F) Multilingual 2 XP Pro -- English, Danish, Finland, Norwegian, Swedish (models 91C) 7360 Vista Home Basic 32 Recovery DVDs...
Page 490
7360 Vista Home Basic 32 Recovery DVDs FRU # C&L 3 Bel Lux (EN FR GR NL) (models 91C) 53Y7240 7360 Vista Business 32 Recovery DVDs FRU # US English (models A6H A7H AHH AGH BDM BDA BDQ ABM ABA ABQ ACM ACA 53Y7154 ACQ B2M B2A B2Q B3M B3A B3Q B6M B6A B6Q BAM BAA BAQ AJU AKU ALU APU AQU ARU AEG AFG A1G A2G A3G A4G A5G ADU 91C BQM BQA BQQ BNM BNA...
Page 491
7360 Vista Home Premium 32 Recovery DVDs FRU # US English (models 91C) Russian English (models 91C) French (models 91C) German (models 91C) Spanish (models 91C) Brazilian Portuguese (models 91C) Italian (models 91C) Japanese (models 91C) Norwegian (models 91C) Swedish (models 91C) Danish (models 91C) Dutch (models 91C) Czech (models 91C)
Page 496
Item # 7373 FRUs FRU # Memory module, 2GB PC3-8500 1066MHz DDR3 UDIMM (models 91C BLA BLQ 46R3323 BLT BMM BMA BMQ BMT BMK BNM BNA BNQ BNT BNK BPA BPQ BPT BQM BQA BQQ BQT BQK BSG BTU BTF BWU BWF D1U D1F D4U D4F D5U D5F) Optical drive, DVD-ROM 16X Max SATA (models ABU ABF ABH ABV ACU ACF 41N3325 ACS ACP ACY ACH BCA BCQ BCT AUA AUQ AUT AWM AWA AWQ AWT B1A...
Page 497
Item # 7373 FRUs FRU # 4 Pin System Fan (all models) 41R6269 Power supply, 280 Watt ATX Power Supply - WW, Robust (models ABU ABF ABH 41A9684 ABV ACU ACF ACS ACP ACY ACH AKS AKP AKY AKH ALH BCA BCQ BCT BDM BDA BDQ BDT AEM AEA AEQ AET AEK AUA AUQ AUT AVM AVA AVQ AVT AWM AWA AWQ AWT B1A B1Q B1T B2M B2A B2Q B2T B2K B3M B3A B3Q B3T B3K B4M B4A B4Q B4T B4K B5A B5Q B5T B6M B6A B6Q B6T B7M B7A B7Q...
Page 498
1.8 SSD to 3.5 HDD Conversion Kit, no bezel, with PCB (all models) 43N9593 7373 Keyboards (Lenovo Preferred Pro USB - without hub) FRU # US English (models ABU ABH ACU ACH AKH ALH BCA BCQ BDM BDA BDQ AEM...
Page 499
7373 Keyboards (Lenovo Preferred Pro USB - without hub) FRU # Dutch (models A1G A2G A3G A4G A5G AJG AHG 91CBSG D2G) 41A5299 French (models A1G A2G A3G A4G A5G AJG AHG 91CBSG D2G) 41A5300 French Canadian (models ABF ACF AMF ANF APF AGF A1G A2G A3G A4G A5G AJG...
Page 500
Turkish (models 91C) 41R0074 Turkish (models 91C) 41R0075 UK English (models 91C) 41R0076 US Euro (models 91C) 41R0077 Slovenian (models 91C) 41R0078 7373 Keyboards (Lenovo Preferred Pro PS/2 Full Size) FRU # PS/2 Full--US English (models 91C) 41A5039 Hardware Maintenance Manual...
Page 504
7373 Power Cords (Secondary) FRU # Power cord - US (models ABU ABF ACU ACF ACS ACY AKS AKY BCA BCT BDA BDT 41R3185 AEA AET AUA AUT AVA AVT AWA AWT B1A B1T B2A B2T B3A B3T B4A B4T B5A B5T B6A B6T B7A B7T B8A B9A B9T BAA BAT AMU AMF ANU ANF APU APF AGU AGF A7A A7T BES BEY BFS BFY BGS BGY AGU AGF 91C BRS BRY BHA BHT BJA BJT BKA BKT BLA BLT BMA BMT BNA BNT BPA BPT BQA BQT BTU BTF BUU BUF BVU BVF...
Page 505
7373 Windows XP Home Recovery CDs FRU # Finnish (models 91C) Norwegian (models 91C) Polish (models 91C) Portuguese (models 91C) Russian (models 91C) Russian English (models 91C) Hungarian (models 91C) Czech (models 91C) Turkish native (models 91C) Greek (models 91C) Japanese (models 91C) Simplified Chinese (models 91C) Taiwan-TC (models 91C)
Page 506
7373 Windows XP Pro Recovery CDs FRU # Taiwan-TC (models 91C) 53Y7097 Hong Kong-TC (models 91C) 53Y7098 Korean (models 91C) 53Y7099 Multilingual 1 XP Pro -- English, Dutch, French, German, Italian (models BTF BUF BVF BWF D1F D3F) Multilingual 2 XP Pro -- English, Danish, Finland, Norwegian, Swedish (models 91C) 7373 Vista Home Basic 32 Recovery DVDs FRU # US English (models 91C)
Page 507
7373 Vista Business 32 Recovery DVDs FRU # US English (models ABU ABH ACU ACH AKH ALH BDM BDA BDQ AEM AEA AEQ 53Y7154 AWM AWA AWQ B2M B2A B2Q B3M B3A B3Q B6M B6A B6Q B9M B9A B9Q BAM BAA BAQ AMU ANU APU AGU A7A A7Q A1G A2G A3G A4G A5G AJG AHG AGU 91C BKM BKA BKQ BNM BNA BNQ BQM BQA BQQ BSG D2U D2L D2G D2M D2A D2Q D2H D2R D2E D4U D5U)
Page 508
7373 Vista Home Premium 32 Recovery DVDs FRU # US English (models 91C) Russian English (models 91C) French (models 91C) German (models 91C) Spanish (models 91C) Brazilian Portuguese (models 91C) Italian (models 91C) Japanese (models 91C) Norwegian (models 91C) Swedish (models 91C) Danish (models 91C) Dutch (models 91C) Czech (models 91C)
Page 509
7373 Vista Business 64 Recovery DVDs FRU # Norwegian (models 91C) Swedish (models 91C) Danish (models 91C) Dutch (models 91C) Czech (models 91C) Finland (models 91C) Polish (models 91C) Russian (models 91C) Turkish (models 91C) Hungarian (models 91C) Greek (models 91C) Simplified Chinese (models 91C) 53Y7254 Traditional Chinese (models 91C)
Page 510
7373 Vista Ultimate 32 Recovery DVDs FRU # Portuguese (models 91C) Turkish (models 91C) Czech (models 91C) Polish (models 91C) Russian English (models 91C) Arabic Localized (models 91C) 53Y7248 Hebrew (models 91C) Hungarian (models 91C) Slovakian (models 91C) C&L 1 Nordics (EN DK FI NO SV) (models 91C) 53Y7249 7373 Vista Starter 32 Recovery DVDs FRU #...
Machine Type 7483 Item # 7483 FRUs FRU # Hard disk drive, SATA 160GB 7200RPM/3Gb/8MB (models APM APA APQ APT 40Y9035 APK AQM AQA AQQ AQT AQK ARM ARA ARQ ART ARK ABM ABA ABQ ABT ABK AEU AEF AEV AFU AFF AGU AGF AKU AKF ALU ALF ANU ANF A5V A8S A8P A8Y ATS ATP ATY AUS AUP AUY AWS AWP AWY ACU ACF 91CB2U B2F B1U B1F B3U B3F) Hard disk drive, SATA 250GB 7200RPM/3Gb/8MB (models A7U A7F A7S A7P...
Page 512
Item # 7483 FRUs FRU # Microprocessor, Core 2 Duo E8400 Processor 3.00GHz 1333MHz FSB 6M L2 65W 45C7736 C-0 (models A7U A7F A7S A7P A7L A7D A7Y A7H APM APA APQ APT APK ADM ADA ADQ ADT ADK ABM ABA ABQ ABT ABK AEU AEF AEV AFU AFF AGU AGF AHU AHF A5V A1G A8S A8P A8Y ATS ATP ATY ACU ACF 91C B1U B1F) Microprocessor, Core 2 Duo E8300 Processor 2.83GHz 1333MHz FSB 6M L2 65W...
Page 513
Item # 7483 FRUs FRU # Optical drive, DVD-ROM 16X Max SATA (models AEU AEF AEV AJU AJF AKU 41N3325 AKF A8S A8P A8Y AVS AVP AVY AWS AWP AWY 91C) Optical drive, DVD Recordable SATA/CD-RW Rambo 8 - SATA Vista & non-Vista 43C1042 (models A7U A7F A7S A7P A7L A7D A7Y A7H APM APA APQ APT APK AQM AQA AQQ AQT AQK ARM ARA ARQ ART ARK ASM ASA ASQ AST ASK ADM...
Page 514
Chassis Mech Kit Asm (all models) 45J9520 Air Deflector, recycle resin (all models) 43N9610 7483 Keyboards (Lenovo Preferred Pro USB -- without hub) FRU # USB FULL--US English (models A7U A7L A7H APM APA APQ AQM AQA AQQ ARM 41A5289...
Page 515
7483 Keyboards (Lenovo Preferred Pro USB -- without hub) FRU # USB FULL--Dutch (models A1G A2G A3G 91C) 41A5299 USB FULL--French (models A1G A2G A3G 91C) 41A5300 USB FULL--French Canadian (models A7F AEF AFF AGF AHF AJF AKF ALF AMF ANF...
Page 516
Turkish (models 91C) 41R0075 UK English (models 91C) 41R0076 US Euro (models 91C) 41R0077 Slovenian (models 91C) 41R0078 7483 Keyboards (Lenovo Preferred Pro PS/2 Full Size) FRU # PS/2 Full--US English (models 91C) 41A5039 PS/2 Full--Arabic (models 91C) 41A5040 Hardware Maintenance Manual...
Page 518
DP to DVI dongle 200mm (models 91C) 43N9160 IEEE 1394 Firewire Adapter (LP) (models 91C) 41D2781 Speakers (2-piece) Lenovo Logo (Primary) (models 91C) 41A5331 Speakers (2-piece) Lenovo Logo (Secondary) (models 91C) 41A5334 Speaker Power brick - US, Canada, LA low voltage, ASEAN (models A7U ACU 91C B2U...
Page 519
7483 Power Cords (Primary) FRU # Power cord - US (models A7U A7F A7S A7L A7Y APA APT AQA AQT ARA ART ASA 41R3184 AST ADA ADT ABA ABT AEU AEF AFU AFF AGU AGF AHU AHF AJU AJF AKU AKF ALU ALF AMU AMF ANU ANF A8S A8Y A9S A9Y ATS ATY AUS AUY AVS AVY AWS AWY ACU ACF 91C B2U B2F B1U B1F B3U B3F) Power cord - China (models 91C)
Page 520
7483 Power Cords (Secondary) FRU # Power cord - Israel (models A1G A2G A3G 91C) 41R3237 Power cord - South Africa (models APM APA AQM AQA ARM ARA ASM ASA ADM 41R3221 ADA ABM ABA A1G A2G A3G 91C) Power cord - India (models APQ AQQ ARQ ASQ ADQ ABQ 91C) 41R3175 Power cord - Thailand (models APT AQT ART AST ADT ABT 91C) 43N9030...
Page 521
7483 Windows XP Pro Recovery CDs FRU # Danish (models 91C) 53Y7082 Dutch (models 91C) 53Y7083 Arabic English (models 91C) 53Y7088 SV (Swedish) (models 91C) 53Y7081 Hebrew (models 91C) 53Y7086 Finland (models 91C) 53Y7085 Norwegian (models 91C) 53Y7080 Polish (models 91C) 53Y7087 Portuguese (models 91C) 53Y7094...
Page 522
7483 Vista Home Basic 32 Recovery DVDs FRU # Hungarian (models 91C) 53Y7223 Greek (models 91C) 53Y7224 Portuguese (models 91C) 53Y7235 Hong Kong (models 91C) 53Y7228 Simplified Chinese (models 91C) 53Y7226 Traditional Chinese (models 91C) 53Y7227 Korean (models 91C) 53Y7229 Slovenian (models 91C) 53Y7230 Russian English (models 91C)
Page 523
7483 Vista Business 32 Recovery DVDs FRU # Traditional Chinese (models 91C) 53Y7169 Hong Kong (models 91C) 53Y7170 Korean (models ARK ASK ADK ABK 91C) 53Y7171 Slovenian (models A1G A2G A3G 91C) 53Y7172 Russian English (models A1G A2G A3G 91C) 53Y7155 Romanian (models A1G A2G A3G 91C) 53Y7176...
Page 524
7483 Vista Home Premium 32 Recovery DVDs FRU # Hebrew (models 91C) Romanian (models 91C) Bulgarian (models 91C) Croatian (models 91C) Portuguese (models 91C) Serbian-Latin (models 91C) Ukrainian (models 91C) Slovakian (models 91C) 7483 Vista Business 64 Recovery DVDs FRU # Russian English (models 91C) 53Y7250 Russian French (models 91C)
Page 525
7483 Vista Ultimate 32 Recovery DVDs FRU # Simplified Chinese (models 91C) French (models 91C) 53Y7242 German (models 91C) 53Y7243 Spanish (models 91C) 53Y7244 Italian (models 91C) 53Y9471 Brazilian Portuguese (models 91C) Danish (models 91C) Swedish (models 91C) Finnish (models 91C) Dutch (models 91C) Traditional Chinese (models 91C) Hong Kong (models 91C)
Page 528
Item # 7484 FRUs FRU # Optical drive, DVD Recordable SATA/CD-RW Rambo 8 - SATA Vista & non-Vista 43C1042 (modes A7H ACM ACA ACQ ACT ACK ADM ADA ADT ADK AFM AFA AFQ AFT AFK AQM AQA AQQ AQT AQK ARM ARA ARQ ART ARK ASM ASA ASQ AST ASK ANU ANF AMU AMF AHU AHF A8U A8F A8S A8P A8L A8D A8Y A4V A1G A2G A3G ABS ABP ABY ATS ATP ATD ATY AUS AUP AUD AUY AWS AWP AWD AWY AEU AEF 91CB2U B2F B3U B3F)
Page 529
1.8 SSD to 3.5 HDD Conversion Kit, no bezel, with PCB (all models) 43N9593 7484 Keyboards (Lenovo Preferred Pro USB - without hub) FRU # US English (models A7H ACM ACA ACQ ADM ADA AFM AFA AFQ AQM AQA AQQ...
Page 530
7484 Keyboards (Lenovo Preferred Pro USB - without hub) FRU # Arabic (models A1G A2G A3G 91C) 41A5290 Arabic/French (models A1G A2G A3G 91C) 41A5291 Belgium French (models A1G A2G A3G 91C) 41A5292 Belgium English (models A1G A2G A3G 91C)
Page 534
7484 Adapters and miscellaneous FRUs FRU # Modem phone cable (models 91C) 39K5120 Thermal Grease Syringe (models 91C) 91P8835 NVIDIA FX370 256MB 64BIT DMS59 LP Video card (models) 53Y6807 Dongle DMS-59 to single VGA & single DVI cable (models) 42Y8183 Dongle DMS-59 to dual VGA cable (models) 42Y8181 Dongle DMS-59 to dual DVI - I cable (models)
Page 535
7484 Power Cords (Secondary) FRU # Power cord - Australia / New Zealand (models ACA ACT ADA ADT AFA AFT AQA AQT 41R3197 ARA ART ASA AST ANU ANF AMU AMF AGU AGF AHU AHF AJU AJF AKU AKF ALU ALF A8U A8F A8S A8L A8Y A9U A9F A9S A9Y ABS ABY ATS ATY AUS AUY AVS AVY AWS AWY B1S B1Y AEU AEF 91C B2U B2F B3U B3F) Power cord - Korea (models 91C) 41R3261...
Page 536
7484 Windows XP Home Recovery CDs FRU # Hong Kong-TC (models 91C) Korean (models 91C) 7484 Windows XP Pro Recovery CDs FRU # US English (models AQM AQA AQQ ARM ARA ARQ 91CB2U) 53Y7073 French (models 91CB2F) 53Y7074 German (models 91C) 53Y7075 Italian (models 91C) 53Y7078...
Page 537
7484 Vista Home Basic 32 Recovery DVDs FRU # Japanese (models 91C) 53Y7225 Norwegian (models 91C) Swedish (models 91C) Danish (models 91C) Dutch (models 91C) 53Y7232 Czech (models 91C) 53Y7219 Finland (models 91C) Polish (models 91C) 53Y7220 Russian (models 91C) 53Y7221 Turkish (models 91C) 53Y7222...
Page 539
7484 Vista Home Premium 32 Recovery DVDs FRU # Czech (models 91C) Finland (models 91C) Polish (models 91C) Russian (models 91C) Turkish (models 91C) Hungarian (models 91C) Greek (models 91C) Simplified Chinese (models 91C) Traditional Chinese (models 91C) Hong Kong (models 91C) Korean (models 91C) Slovenian (models 91C) Hebrew (models 91C)
Page 540
7484 Vista Business 64 Recovery DVDs FRU # Traditional Chinese (models 91C) Hong Kong - Traditional Chinese (models 91C) Korean (models 91C) Slovenian (models 91C) Portuguese (models 91C) Arabic Localized (models 91C) Hebrew (models 91C) Slovakian (models 91C) 7484 Vista Ultimate 32 Recovery DVDs FRU # US English (models 91C) 53Y7241...
Page 541
7484 Vista Starter 32 Recovery DVDs FRU # English (models 91C) Chapter 10. FRU lists...
Sources for obtaining the latest level BIOS available 1. Lenovo support web site: http://www.lenovo.com/support/ 2. Lenovo Customer Support Center 3. Levels 1 and 2 Support To update (flash) the BIOS, see “Updating (flashing) BIOS from a disc.” Updating (flashing) BIOS from a disc This section provides instructions on how to update (flash) BIOS from a disc.
8. Reinstall or close the computer cover and reconnect the power cords for the computer and monitor to electrical outlets. See “Completing the FRU replacement” on page 122 or “Completing the FRU replacement” on page 158. 9. Turn on the computer and the monitor, and then insert the POST/BIOS update (flash update) disc into the optical drive.
Macrovision Corporation. Reverse engineering or disassembly is prohibited. Trademarks The following terms are trademarks of Lenovo in the United States, other countries, or both: Lenovo Rescue and Recovery...
Page 758
Part Number: 46R4780 Printed in USA (1P) P/N: 46R4780...