Coleman 5459 Series Instructions For Use

Screw regulator into stove hand
To Light
tight. (Fig. 5)
DANGER
EXPLOSION - FIRE HAZARD
• Propane is heavier than air and can
accumulate in low places. If you smell
Fig. 5 gas, leave the area immediately.
• Always attach or detach propane source
Remove plastic cap from top of
outdoors; never while stove is lighted,
propane bottle and screw propane
near flame, pilot lights, other ignition
bottle into regulator hand tight. (Fig. 6)
sources or while stove is hot to touch.
• This stove is very hot during use and
can ignite flammables too close to the
burners. Keep flammables at least 12
inches from the sides and 48 inches from
the top of the stove. Keep gasoline and
other flammable liquids and vapors well
away from stove.
• The stove must not be exposed to
flammable vapors or liquids
during lighting.
Fig. 6
Propane cylinder correctly
WARNING
installed. (Fig. 7)
BURN HAZARD
• Never leave stove unattended when
hot or in use.
• Keep out of reach of children.
Standard Ignition Stoves
Set on sturdy, flat surface. For outdoor
Fig. 7
use only.
Never operate stove with propane Hold lighted match near burner and
open burner valve. (Fig. 9 and 10)
cylinder in an inverted position. (Fig. 8)
Fig. 9
Fig. 8
Leak Check
WARNING
• Perform leak test outdoors.
• Extinguish all open flames.
• NEVER leak test when smoking. Fig. 10
• Do not use the outdoor stove until
• Keep stove area clear and free from
connection has been leak tested and
combustible materials, gasoline and
does not leak.
other flammable vapors and liquids.
• Do not obstruct the flow of
combustion and ventilation air.
• A good flame should be blue with
minimal yellow tip. Some yellow tips
on flames are acceptable as long as
no carbon or soot deposits appear.
English - 5
(ECN20022590-04) 4010016264
(NYSE:JAH) Corporation Jarden de compagnie une
company/ Corporation Jarden a Inc., Company, Coleman The
Inc. Company, Coleman The
de déposées marques des sont et , Coleman réservés. droits Tous Inc. Company, Coleman The 2012 ©
®
Inc. Company, Coleman
The of trademarks registered are and , Coleman reserved. rights All Inc. Company, Coleman The 2012 ©
®
www.coleman.com
1-316-832-8707 TDD: 1-800-835-3278
U.S.A. 67219 KS Wichita, • Hydraulic North 3600 • Inc. Company, Coleman The
To Turn Off To Clean
Close both burner valves firmly. (Fig. 11) Make sure stove is cool.
Move stove away from flame (including
pilot lights) and other ignition sources.
Remove propane cylinder from
regulator and replace protective cap
on cylinder. (Fig. 12)
Fig. 11
Fig. 12
Remove regulator from stove. (Fig. 13)
Fig. 13
MAINTENANCE
• Wipe clean with soft cloth and mild
dish detergent. Do not use
abrasives. (Fig. 14)
Fig. 14
English - 6
4 - English
flame. a use
Never leak. a indicate Bubbles water.
soapy using leaks for fittings and
connections all check up, set During •
attaching. before damage
for connections propane stove and
cylinder propane Inspect clean.
fittings and connections all Keep •
SAFETY SERVICE
CAUTION
B339. CAN/CSA
Canada, Transport or Transportation of
Department U.S. the of cylinders LP-gas
4 Fig.
for specifications the with accordance
in marked and constructed be must
stoves with used cylinder(s) LP-gas
The cylinders. propane disposable
oz. 16.4 Coleman Use NOTE:
®
life. your endangering avoid
4) (Fig. firmly. valves burner both Close to areas enclosed or unventilated in
use not Do (CO). monoxide carbon
produces and (oxygen) air consumes
3 Fig.
stove This areas. enclosed or
unventilated other or vehicle tent,
camper, house, inside use Never •
only. use outdoor For •
HAZARD MONOXIDE CARBON
DANGER
3) (Fig. shown. as grates Install
Up Set To
2 Fig.
5430-565 Regulator:
cylinders propane disposable oz. 16.4 Fuel:
propane regulated Pressure Category:
burner per BTU/h 7,000 Input:
2) (Fig. hands. by lid the Open
Characteristics
1 Fig.
Technical
3
flame. a use Never
2
water. soapy using leaks for fittings
4
all check set-up, stove During parts.
or accessories Coleman only Use •
®
adjust. to
attempt not Do stove. the with
came that regulator preset the Use •
cylinders. disposable refill Never •
these. about you advise can
authorities local Your uses. specific for
products producing heat and gases
fuel of use the govern standards Other
1
use. about questions have you if
authority safety fire local your with
model. stove
Check products. our of made be may
non-lidded the for used be can't Lid NOTE:
which use every foresee cannot We
Regulator 4.
use. vehicle recreational
Grate 3.
or home for Not
Screw 2.
) (Optional Lid 1. WARNING
1) (Fig. carton. from components Remove
To Store
Things You Should
Know
DANGER
1. It is unsafe and illegal in some places
to store or use propane cylinders of
greater than 1.14 kg (2.5 lbs.) water
capacity (approximately 1 lb. propane)
EXPLOSION - FIRE HAZARD
• Never store propane near high heat, in occupied enclosures.
2. The usual storage areas for camping
open flames, pilot lights, direct
and picnic equipment are the
sunlight, other ignition sources or
where temperatures exceed basement, attic, or garage. To avoid
120 ºF (49 °C). the accumulation of dust, cobwebs,
etc., that is common in these storage
• The cylinder must be disconnected
areas, place your stove in a plastic bag
when the stove is in storage.
and seal it with a rubber band.
3. For repair service call one of the
For storage or transport, the regulator
numbers listed on the front cover
may be located below the heat
for location of your nearest Coleman
shields. (Fig. 15)
Service Center. If product must be
mailed to Service Center, attach to the
product a tag that includes your name,
address, daytime telephone number
and a description of problem. DO
NOT send propane cylinder. Carefully
package the product and send
either by courier or insured mail with
shipping and insurance prepaid to:
For products purchased
Fig. 15
in the United States:
The Coleman Company, Inc.
3600 North Hydraulic
Wichita, KS 67219 U.S.A.
1-800-835-3278 • TDD: 1-316-832-8707
For products purchased in Canada:
Sunbeam Corporation (Canada) Limited
DBA Jarden Consumer Solutions
20B Hereford Street
Brampton, ON L6Y 0M1
1-800-387-6161
4. If not completely satisfied with the
performance of this product, please
call one of the numbers listed on the
cover of this manual.
www.coleman.com
English - 7
3 - English
life. your endangering
avoid to areas enclosed or
unventilated in use not Do (CO).
monoxide carbon produces
and (oxygen) air consumes
stove This areas. enclosed or
unventilated other or vehicle tent,
camper, house, inside use Never •
only. use outdoor For •
immediately! air fresh
children. of reach of out Keep • get product this of operation during
use. in or hot present are symptoms these If killer.
when unattended stove leave Never • invisible an It's it. smell can't you and
HAZARD BURN it see can't You death. possibly and
fatigue dizziness, headaches, eyes,
watery symptoms, flu-like produces
poisoning (CO) Monoxide Carbon •
stove. the of out or into flow air block
not Do instructions. and warnings
WARNING
all with accordance in maintained
and used if CO of amounts
non-hazardous minute, extremely
fires. grease
produce to designed is product This
possible and accumulation grease
process. combustion the during
avoid to frequently stove Clean •
(CO) monoxide carbon produce
Coleman. by approved
appliances combustion All appliance.
expressly not part or device any
combustion a is stove This •
with use or way any in alter Never
HAZARD MONOXIDE CARBON
only. appliance cooking a as Use •
repairs. or service for Coleman
contact and cylinder the remove
leak, a still is there If check. leak
another Perform tight. is it that and
DANGER
cross-threaded not is connection
the that Check leak. a indicate
Bubbles flame. a use Never water.
chamber. combustion
soapy using leaks for fittings and
the into openings air around
connections all check up, set During • clearances adequate Provide •
attaching. before damage
top. the
for connections propane stove and
from inches 48 and sides the from
cylinder propane Inspect clean. inches 12 materials: combustible
fittings and connections all Keep •
from clearances Minimum •
SAFETY SERVICE
chemicals. unknown
or particles dust thinner,
CAUTION
paint solvents, gasoline, as such
products or combustibles, airborne
or volatile contain may or contain
use. in
that spaces in stove the use Never
not when propane off Turn 58. NFPA
ignition. of source a be can product
ANSI/ with or codes and ordinances
this operation, and lighting During •
local with compliance in used or
touch. to
stored be should gas Propane •
hot is stove outdoor while or sources
withdrawal. vapor for up set
ignition other lights, pilot flame, near
gas propane only Use leak. original
lighted, is stove outdoor while tank
the from away feet many kind any
propane remove or install Never •
of flames open or sparks lighters,
immediately.
matches, including sources ignition
area the leave gas, smell you If
by ignite can It possible. level lowest
places. low in accumulate can
the to sink will propane leaking
and air than heavier is Propane •
and air than heavier is gas Propane •
°C). (49 ºF 120
alone. smell by detectable always
exceed temperatures where
not is gas leaking so time over fade
or sources ignition other sunlight,
can odorant The smell. egg" "rotten
direct lights, pilot flames, open
a as described be can and leaks
heat, high near propane store Never •
detect help to added normally is
HAZARD FIRE - EXPLOSION
odorant An flammable. and odorless,
invisible, is gas Propane gas.
propane by fueled is product This •
WARNING DANGER
Parts List
Item Part No. Description
1 5010001227 Grate & Screw
2 5010001193 Burner Assembly & Screw
3 R430B565T Regulator Assembly
4 R413-149T Knob & Screw
5 5010001194 Steel Wire Leg
6 5010001192 Lid Assembly (For Stove with lid only)
6
1
2
5
3
4
English - 8
2 - English
harm. reproductive other or
defects, birth cancer, cause to California
of state the to known chemicals
contain fuel, this of combustion of
products by and fuel, This WARNING:
65: PROPOSITION CALIFORNIA
Inc. Company,
Coleman The contact labels, or
manual instruction an as such
information or assistance need you If •
stoves. these service or use
should instructions the follow and
understand can who persons Only •
poisoning. monoxide
carbon and/or asphyxiation, burn,
explosion, fire, of hazards from
damage or loss property and injury
bodily serious death, in result
can stoves these with provided
instructions and precautions
the with comply to Failure •
DANGER
5459 Series
© 2012 The Coleman Company, Inc
www.coleman.com
Propane Stoves
Standard Ignition
Réchauds à propane
Allumage standard
Instructions for use
Notice d'emploi
CERTIFIED
® ®
ANSI Z21.72-2011/CSA 11.2-2011
Note:
Propane tank is not included.
Remarque :
La bouteille de propane n'est pas incluse.
IMPORTANT
Read this manual carefully before assembling, using or servicing these
stoves. Keep this manual for future reference. If you have questions
about assembly, operation, servicing or repair of these stoves, please
call Coleman in the United States at 1-800-835-3278 or
TDD: 1-316-832-8707 and in Canada at 1-800-387-6161.
IMPORTANT
Lisez attentivement ce manuel avant d'assembler, d'utiliser ou de
réparer le réchaud et gardez-le pour référence ultérieure. Pour toute
question en ce qui concerne l'assemblage, le fonctionnement,
l'entretien ou la réparation, appelez Coleman au 1-800-835-3278 ou
ATS 1-316-832-8707 aux États-Unis et au 1-800-387-6161 au Canada.
1 - English
equipment. fueled
propane or mechanical any using
when essential are they as precautions,
these heed Always instructions. these
home. or car tent,
throughout extensively used are below
shown symbols following The
camper, a as such
space enclosed
damage. property
or injury personal of possibilities the
an in appliance
reduce will demanded caution and respect
this use • Never the with equipment this Using servicing.
and storing, using, when necessary are
you. kill
precautions These involved. is equipment
can space enclosed fueled propane or mechanical any when
essential are precautions Safety
an in it • Using
product. the on labeling the
odor. no
with conjunction in read be should manual
has which monoxide
This product. this of users new educate to
and reference future for manual this Keep
carbon produce
can appliance • This
CAUTION".
WARNING", " DANGER",
HAZARD
symbol alert safety the by accompanied
MONOXIDE CARBON
information to paid be should attention
Particular instructions. these throughout
located also is and page this on presented
is information safety General appliance.
propane outdoor this of maintenance and
operation assembly, the about information
important contains manual This
appliance. other any
or this of vicinity the
in vapors flammable
with liquids other
or gasoline use
DANGER
or store not Do
SAFETY
damage. property
or injury, personal moderate or
minor in result may avoided, not
YOUR FOR
if which, situation hazardous
potentially a indicates CAUTION
CAUTION
supply. fuel
from Disconnect 3.
injury. serious
flame. open
or death in result could avoided,
not if which, situation hazardous
any Extinguish 2.
potentially a indicates WARNING
appliance. light
WARNING
to attempt not Do 1.
gas: smell you If
injury. serious
or death in result will avoided,
SAFETY
not if which, situation hazardous
imminently an indicates DANGER
YOUR FOR
DANGER
"
"