Page 1
DSC-P73 SERVICE MANUAL LEVEL US Model Ver 1.0 2004.04 Canadian Model Revision History AEP Model Revision History UK Model E Model How to use How to use Hong Kong Model Acrobat Reader Acrobat Reader Australian Model Chinese Model Korea Model...
DSC-P73 SPECIFICATIONS x Camera [LCD screen] x BC-CS2A/CS2B Ni-MH battery [System] charger LCD panel used 3.8 cm (1.5 type) TFT drive Image device 6.85 mm (1/2.7 type) color Power requirements Total number of dots AC 100 to 240V 50/60Hz Primary color filter 67 200 (280×240) dots...
Page 3
CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS REMPLACER CES COMPOSANTS QUE PAR DES PIÈSES SONY APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU PUBLISHED BY SONY.
DSC-P73 SECTION 1 SERVICE NOTE 1-1. NOTE FOR REPAIR Make sure that the flat cable and flexible board are not cracked of When remove a connector, don’t pull at wire of connector. bent at the terminal. It is possible that a wire is snapped.
1-4. DESCRIPTION ON SELF-DIAGNOSIS DISPLAY Self-diagnosis display • C: ss: ss You can reverse the camera malfunction yourself. (However, contact your Sony dealer or local authorized Sony service facility when you cannot recover from the camera malfunction.) • E: ss: ss Contact your Sony dealer or local authorized Sony service facility.
DSC-P73 SECTION 2 HELP HELP DISASSEMBLY 2-1. FLOW CHART The following flow chart shows the disassembly procedure. 1 Tape (A) HELP 1 Open the BT lid. 1 Mic unit flexible: CN707 2 FP-854: CN702 2 Screw (M1.7) x5 2 Claw 3 Lens block flexible: CN601 3 Close the BT lid.
Page 8
DSC-P73 2-2. SY-100 BOARD SERVICE POSITION Rear cabinet block Flush unit ST-097 board Control switch block MS board FP-860 flexible board Lens block Color monitor SY-100 board AC power AC IN adaptor...
DSC-P73 2-3. CIRCUIT BOARDS LOCATION SY-100 (including CH-146) SW-419 CH-146 (included in SY-100) CD-500 ST-097 MS (FP-861) Board Name Function CD-500 CCD IMAGER CH-146 CCD SIGNAL PROCESS (included in SY-100) MS (FP-861) MEMORY STICK CONNECTOR ST-097 FLASH DRIVE SW-419 CONTROL SWITCH, LCD DRIVE...
Page 10
DSC-P73 HELP Sheet attachment positions and procedures of processing the flexible boards/harnesses are shown. Tape (A) CN702 RL electrostatic SY-100 board Lens block SW-419 board Reset sheet HELP...
DSC-P73 3. BLOCK DIAGRAMS Link Link OVERALL BLOCK DIAGRAM (1/2) POWER BLOCK DIAGRAM (1/2) OVERALL BLOCK DIAGRAM (1/2) POWER BLOCK DIAGRAM (1/2) OVERALL BLOCK DIAGRAM (2/2) POWER BLOCK DIAGRAM (2/2) OVERALL BLOCK DIAGRAM (2/2) POWER BLOCK DIAGRAM (2/2)
Page 12
DSC-P73 SECTION 3 3. BLOCK DIAGRAMS 3. BLOCK DIAGRAMS BLOCK DIAGRAMS 3-1. OVERALL BLOCK DIAGRAM (1/2) ( ) : Number in parenthesis ( ) indicates the division number of schematic diagram where the component is located. CD-500 BOARD (1/2) SY-100 BOARD (1/2)
Page 13
DSC-P73 3. BLOCK DIAGRAMS 3. BLOCK DIAGRAMS ( ) : Number in parenthesis ( ) indicates the division number of schematic diagram where the component is located. 3-2. OVERALL BLOCK DIAGRAM (2/2) SY-100 BOARD (2/2) FP-860 FLEXIBLE BOARD CN751 (1/2)
Page 14
DSC-P73 3. BLOCK DIAGRAMS 3. BLOCK DIAGRAMS 3-3. POWER BLOCK DIAGRAM (1/2) ( ) : Number in parenthesis ( ) indicates the division number of schematic diagram where the component is located. SY-100 BOARD (1/2) CONTROL SWITCH BLOCK CN001 Q006, 007...
Page 15
DSC-P73 3. BLOCK DIAGRAMS 3. BLOCK DIAGRAMS ( ) : Number in parenthesis ( ) indicates the division number of schematic diagram where the component is located. 3-4. POWER BLOCK DIAGRAM (2/2) SY-100 BOARD (2/2) ST-097 BOARD CN703 CN851 T851...
DSC-P73 4-2. SCHEMATIC DIAGRAMS Link Link CD-500 BOARD CD-500 BOARD (CCD IMAGER) FP-860 FLEXIBLE BOARD (CCD IMAGER) FP-860 FLEXIBLE BOARD (JACK) (JACK) SW-419 BOARD SW-419 BOARD MIC UNIT MIC UNIT (MA-002) (MA-002) (CONTROL SWITCH, LCD DRIVE) (CONTROL SWITCH, LCD DRIVE)
Page 18
DSC-P73 4-2. SCHEMATIC DIAGRAMS 4-2. SCHEMATIC DIAGRAMS 4-2. SCHEMATIC DIAGRAMS THIS NOTE IS COMMON FOR SCHEMATIC DIAGRAMS (In addition to this, the necessary note is printed in each block) (For schematic diagrams) 1. Connection • All capacitors are in µF unless otherwise noted. pF : µ...
Page 19
DSC-P73 4-2. SCHEMATIC DIAGRAMS 4-2. SCHEMATIC DIAGRAMS CD-500 BOARD CD-500 BOARD For Schematic Diagram • Refer to page 4-37 for printed wiring board. Note:Voltage and Waveform of mounted IC801,Q801,Q804 and Q805 CD-500 BOARD on CD-500 board can not be measured because they are mounted by the side of the lens.
Page 20
Schematic diagrams of the CH-146 and SY-100 boards are not shown. Pages from 4-9 to 4-26 are not shown.
Page 21
DSC-P73 4-2. SCHEMATIC DIAGRAMS 4-2. SCHEMATIC DIAGRAMS SW-419 BOARD SW-419 BOARD For Schematic Diagram • Refer to page 4-43 for printed wiring board. SW-419 BOARD CONTROL SWITCH,LCD DRIVE (PB BLOCK) L203 Q202 SSM3J09FU(TE85L) 10uH SWITCH XX MARK:NO MOUNT NO MARK:REC/PB MODE...
Page 22
DSC-P73 4-2. SCHEMATIC DIAGRAMS 4-2. SCHEMATIC DIAGRAMS ST-097 BOARD ST-097 BOARD For Schematic Diagram • Refer to page 4-45 for printed wiring board. ST-097 BOARD FLASH DRIVE (ST BLOCK) T851 D852 XX MARK:NO MOUNT HAU160C030STP NO MARK:REC/PB MODE LND851 XE_H...
Page 23
DSC-P73 4-2. SCHEMATIC DIAGRAMS 4-2. SCHEMATIC DIAGRAMS MS BOARD MS BOARD FP-860 FLEXIBLE BOARD FP-860 FLEXIBLE BOARD For Schematic Diagram For Schematic Diagram • Refer to page 4-47 for printed wiring board. • Refer to page 4-48 for printed wiring board.
Page 24
DSC-P73 4-2. SCHEMATIC DIAGRAMS 4-2. SCHEMATIC DIAGRAMS MIC UNIT (MA-002) CONTROL SWITCH BLOCK (RL530TT) MICROPHONE UNIT (MA-002) is replaced as block, CONTROL SWITCH BLOCK (RL530TT) is replaced as block, so that PRINTED WIRING BOARD is omitted. so that PRINTED WIRING BOARD is omitted.
DSC-P73 NOTE NOTE 5. REPAIR PARTS LIST NOTE: Characters A to Z of the electrical parts list indicate location of exploded views in which the desired part is shown. EXPLODED VIEWS EXPLODED VIEWS Link Link FRONT CABINET FRONT CABINET LENS BLOCK SECTION...
Page 36
DSC-P73 5. REPAIR PARTS LIST 5. REPAIR PARTS LIST SECTION 5 REPAIR PARTS LIST NOTE: • -XX, -X mean standardized parts, so they may have some differences from When indicating parts by reference number, the original one. please include the board name.
Page 37
DSC-P73 5. REPAIR PARTS LIST 5. REPAIR PARTS LIST 5-1. EXPLODED VIEWS 5-1-1. FRONT CABINET BLOCK SECTION Rear cabinet block section (See page 5-5.) BT holder block section (See page 5-4.) Lens block section (See page 5-3.) Ref. No. Part No.
Page 38
DSC-P73 5. REPAIR PARTS LIST 5. REPAIR PARTS LIST 5-1-2. LENS BLOCK SECTION - 5 0 IC801 (Note 1, 2) (Note 1) IC801 is not included in CD-500 complete board. (Note 2) Be sure to read “Precuations for Replacement of CCD Imager”...
DSC-P73 5. REPAIR PARTS LIST 5. REPAIR PARTS LIST 5-1-3. BT HOLDER BLOCK SECTION ns: not supplied C852 (Note) - 1 0 - 0 9 (including CH-146 board) BT001 BT901 SP901 (Note) C852 is not included in ST-097 complete board.
DSC-P73 5. REPAIR PARTS LIST 5. REPAIR PARTS LIST 5-1-4. REAR CABINET BLOCK SECTION ns: not supplied - 4 1 LCD901 D901 The components identified by Les composants identifiés par une mark 0 or dotted line with marque 0 sont critiques pour la mark 0 are critical for safety.
DSC-P73 CD-500 5-2. ELECTRICAL PARTS LIST Ref. No. Part No. Description Ref. No. Part No. Description A-7113-094-A CD-500 BOARD, COMPLETE *********************** (IC801 is not included in this complete board.) < CAPACITOR > C801 1-164-850-11 CERAMIC CHIP 10PF 0.5PF C803 1-107-826-11 CERAMIC CHIP 0.1uF...
Page 46
[Description of main button functions on toolbar of the Adobe Acrobat Reader Ver5.0 (for Windows)] Toolbar Printing a text Reversing the screens displayed once • To reverse the previous screens (operation) one by one, click 1. Click the Print button 2.