Hayter Limited warrants to the original user / purchaser that this unit shall be free from defects in material and workmanship under normal use and service for a period of three years from the date of purchase. The manufac- turers of the engine and battery pack system (where applicable) furnish their own warranty and services are pro- vided through their authorised network (Refer to “Engine/Battery Pack Warranty Statement”).
CONTENTS LIMITED WARRANTY INTERNATIONAL PICTORIALS OWNER’S INFORMATION SAFE OPERATION PRACTICES ASSEMBLY OPERATION MAINTENANCE TROUBLE SHOOTING CHART INTERNATIONAL PICTORIALS IMPORTANT: The following pictorials are lo- cated on your unit or on literature supplied with the product. Before you operate the unit, learn and understand the purpose for each pictorial.
OWNER’S INFORMATION Know your product: If you understand the unit and how the unit operates, you will get the best performance. As you read this manual, compare the illustrations to the unit. Learn the location and the function of the controls. To help prevent an accident, follow the operating instructions and the safety rules.
ASSEMBLY All fasteners are in the parts bag. Do not dis- card any parts or material until the unit is as- sembled. WARNING: Before doing any as- sembly or maintenance to the mower, remove the wire from the spark plug. NOTE: In this instruction book, left and right describe the location of a part with the oper- ator on the seat.
OPERATION NOTE: Illustrations and pictorials begin on page 2. Location Of Controls (Figure 13) Blade Rotation Control (1): Use the blade rotation control to start and stop the rotation of the blade. Clutch / Brake Pedal (2): The pedal has two functions.
4. If you must stop or start on a hill, always have enough space for the unit to roll when you release the brake and engage the clutch. 5. Be very careful when you change directions on a hill. When on a slope or in a turn on a hill, move the throttle control to the SLOW position to help prevent an accident.
Page 16
8. (Figure 18) Pull the connector tube (3) through hole in rear plate (6). 9. Clean the connector tube (3) with soap and water. To Install 1. (Figure 16 and Figure 18) Slide the flange (7) end of the connector tube (3) through hole in rear plate (6).
Page 17
How To Check And Adjust The Drive Brake (Figure 24) Completely push the clutch/brake pedal forward. Set the parking brake. Move the shift lever to the neutral (N) position. Push the unit. If the rear wheels rotate, adjust or replace the brake pads. Adjust the drive brake (1) as follows.
Page 18
6. Disconnect the front hanger (9) from the axle support. See illustration “F”. 7. Remove the mower drive belt (7) from the stack pulley (8). See illustration “G”. 8. (Figure 16) Disconnect the rubber strap (1) from the connector tube (3). Slide the con- nector tube (3) off the extension tube (8).
TROUBLE SHOOTING CHART PROBLEM: The engine will not start. 1. Follow the steps, “How To Start The Engine” in this book. 2. Electric–Start Models: Clean the battery ter- minals. Tighten the cables. 3. Check for a loose wire. Tighten the limit switches.
Page 30
CODE131B REPAIR PARTS ENGINE MOUNT F–040730L...
Page 31
For information on Replacement Parts for this engine contact the manufacturer. F–040730L Part No. Description MU092317 Fuel Cap (Incl’d w/Key 2) MU690280 Fuel Tank MU095197 Hose Clamp (Incl’d w/Key 2) MU7601033 Fuel Line (Incl’d w/Key 2) (Must cut to Length) MU095197 Hose Clamp MU26x201...
Page 37
EG–Konformitätserklärung entsprechend der Richtlinie 98/37/EG entsprechend der Richtlinie 89/336/EWG entsprechend der Richtlinie 2000/14/EG EC Certificate of Conformity conforming to Directive 98/37/EC conforming to Directive 89/336/EEC conforming to Directive 2000/14/EC Déclaration de conformité pour la CEE conforme à la directive 98/37/CE conforme à...
Page 38
Wir / We / Nous / Noi / Nosotros / Wij / Nós / Vi / Vi / Vi / Me erklären in alleiniger Verantwortung, daß das Produkt declare in sole responsibility, that the product déclarons sous notre seule responsabilité que le produit dichiariamo sotto la nostra piena responsabilità...
Page 39
Bauart Category Categorie Categoria Categoría Categorie Categoria Kategori Kategori Kategori Kategoria Fabrikmarke / Make / Marque / Marca / Marca / Merk / Marca /Fabriksmärke / Merke / Mærke / Merkki Typ / Type / Type / Tipo / Tipo / Model / Tipo / Typ / Type / Type / Tyyppi Garantierter Schalleistungspegel Guaranteed sound power level Niveau de puissance acoustique garanti...
Name und Adresse der in der Europäischen Gemeinschaft etablierten benannten Stelle für Richtlinie 2000/14/EG Name and address of the notified body established in the European Community for Directive 2000/14/EC Nom et adresse de l’organisme notifié établi dans la Communauté européenne pour la directive 2000/14/CE Nome e indirizzo dell’organismo notificato stabilito nella Comunità...