Carrier 58UVB Owner's Manual
  1. Manuals
  2. Brands
  3. Carrier Manuals
  4. Furnace
  5. 58UVB series
  6. Owner's manual

Carrier 58UVB Owner's Manual

Condensing gas furnace
Hide thumbs Also See for 58UVB:
Table of Contents

Advertisement

Quick Links

CONDENSING GAS FURNACE
NOTE TO INSTALLER:
THIS MANUAL MUST BE LEFT WITH THE
EQUIPMENT USER.
USER: PLEASE READ ALL INSTRUCTIONS
IN THE MANUAL AND RETAIN ALL
MANUALS FOR FUTURE REFERENCE.
WARNING
!
FIRE OR EXPLOSION HAZARD
Failure to follow warnings could result in injury, death,
or property damage.
Do not store or use gasoline or other flammable vapors
and liquids in the vicinity of this or any other appliance.
WHAT TO DO IF YOU SMELL GAS
- -Do not try to light any appliance.
- -Do not touch any electrical switch; do not use any
phone in your building.
- -Leave the building immediately.
- -Immediately call your gas supplier from a neighbor's
phone. Follow the gas supplier's instructions.
- -If you cannot reach your gas supplier, call the fire
department.
Installation and service must be performed by a
qualified installer, service agency or the gas supplier.
WARNING
!
CARBON MONOXIDE POISONING HAZARD
Failure to follow this warning could result in personal injury
and/or death.
Carbon Monoxide is invisible, odorless, and toxic! Install a
carbon monoxide alarm in your home, even if you do not
own a gas appliance. Locate the carbon monoxide alarm in
the living area of your home and away from gas appliances
and doorways to attached garages. Follow the alarm
manufacturer's instruction included with the alarm.
Owner's Manual
WARNING
!
ELECTRICAL OPERATION HAZARD
Failure to follow this warning could result in personal injury,
death, or property damage.
Do not use this furnace if any part has been under water. A
flood- -damaged furnace is extremely dangerous. Attempts to
use the furnace can result in fire or explosion. A qualified
service agency should be contacted to inspect the furnace and
to replace all gas controls, control system parts, electrical parts
that have been wet or the furnace if deemed necessary.
A05097

Advertisement

Table of Contents
loading

Related Manuals for Carrier 58UVB

Summary of Contents for Carrier 58UVB

  • Page 1 CONDENSING GAS FURNACE Owner’s Manual NOTE TO INSTALLER: THIS MANUAL MUST BE LEFT WITH THE EQUIPMENT USER. USER: PLEASE READ ALL INSTRUCTIONS IN THE MANUAL AND RETAIN ALL MANUALS FOR FUTURE REFERENCE. WARNING FIRE OR EXPLOSION HAZARD Failure to follow warnings could result in injury, death, or property damage.

  • Page 2: Table Of Contents

    WELCOME TO TODAY’S GENERATION OF COMFORT Congratulations! In light of rising energy costs, a 90+% AFUE Condensing Gas Furnace from Carrier Corporation is among the soundest investments today’s homeowner can make. Your new furnace is truly a triumph of technology in home heating.

  • Page 3: Furnace Components

    FURNACE COMPONENTS 1. Combustion- -air intake connection (right or left side). (Furnace shown in upflow position; may be used in downflow or 2. Burner sight glass for viewing burner flame. horizontal orientation or applications. 3. Burner assembly (inside), operates with energy- -saving, in- shot burners and hot surface igniter for safe, dependable heating.

  • Page 4: Safety Considerations

    SAFETY CONSIDERATIONS Installing and servicing of heating equipment can be hazardous due to gas and electrical components. Only trained and qualified personnel should install, repair, or service heating equipment. Untrained personnel can perform basic maintenance functions such as cleaning and replacing air filters. All other operations must be performed by trained service personnel.

  • Page 5: Before Starting Your Furnace

    S Do not cover the furnace, store trash or debris near it, or in any 5. There are no obvious signs of deterioration of the furnace. 6. The burner flames are in good adjustment, See Fig. 4 (by way block the flow of fresh air to the unit. comparison with pictorial sketches or drawings of the main S In addition to the safety rules above, make sure that the burner flame.)

  • Page 6: Steps For Starting Your Furnace

    CHECK AIR FILTER: Before attempting to start your furnace, be sure the furnace filter is clean and in place. See “Performing Routine Maintenance” section in this manual. Do not run the furnace without a filter in place. Then proceed as follows: STEPS FOR STARTING YOUR FURNACE 1.

  • Page 7: Shutting Down Your Furnace

    12. Set your thermostat to the temperature that satisfies your comfort requirements. SUGGESTION: Setting the thermo- stat back a few degrees—and compensating for the differ- ence with warmer clothing—can make a big difference in your fuel consumption on extremely cold days. The few de- grees at the top of your thermostat “comfort level”...

  • Page 8: Performing Routine Maintenance

    CAUTION UNIT AND PROPERTY DAMAGE HAZARD Failure to follow this caution may result in unit component or property damage. Furnace is not to be installed, operated, and then turned off and left turned off in an unoccupied structure during winter. (See “Winterization”...

  • Page 9: Filtering Out Trouble

    FILTERING OUT TROUBLE 5. Reinstall clean air filter. 6. Reinstall filter retainer (for blower compartment locations CAUTION only.) 7. Replace blower access panel and main furnace door (See Fig. 33 and 34) or filter cabinet door (Fig. 29 and 30). UNIT PERFORMANCE HAZARD 8.
  • Page 10 A00225 A93012 Fig. 23 - - Removal of Filter Cabinet Door from Side Blower Fig. 27 - - Release Filter Retaining Rod (Side Inlet) Cabinet A00226 A93013 Fig. 24 - - Removal of Filter Cabinet Door from Bottom Fig. 28 - - Slide Filter Out of Furnace (Side Inlet) Blower Cabinet A00227 A93010...
  • Page 11 A00229 A93205 Fig. 31 - - Replacement of Filter Cabinet Door to Side Blower Fig. 33 - - Replace Blower Access Panel Cabinet A05099 A00230 Fig. 34 - - Removal of Furnace Door Fig. 32 - - Replacement of Filter Cabinet Door to Bottom Blower Cabinet Table 1 –...

  • Page 12: Combustion Air And Vent System

    2. Remove burner enclosure front. Inspect the gas burners, ig- CAUTION niter area, and remainder of furnace for dirt, rust, soot or scale. PERSONAL INJURY HAZARD Failure to follow this caution may result in personal injury. Use care when cutting support rods in filters to protect against flying pieces and sharp rod ends.

  • Page 13: Heading South For The Winter

    WINTERIZATION CAUTION UNIT AND PROPERTY DAMAGE HAZARD Failure to follow this caution may result in unit component or property damage. If the furnace is installed in an unconditioned space where the ambient temperatures may be 32_ F (0_ C) or lower, freeze protection measures must be taken to prevent minor property or product damage.

  • Page 14: A Check- -Up Checklist

    A CHECK- -UP CHECKLIST NOTE: Turn off electrical supply before continuing with Your furnace represents an important investment in your family’s checklist. comfort and your home’s value. To keep it performing properly S Is control switch on gas valve in ON position? (Follow start- -up and to prevent future problems, have a trained service specialist procedures if you must reset switch to ON position.) give your furnace a professional check- -up annually.

  • Page 15: Installation Data

    NOTE TO EQUIPMENT OWNER: For your convenience, please record the model and serial numbers of your new equipment in the spaces provided. This information, along with the installation data and dealer contact information will be helpful should your system require maintenance or service. FURNACE INSTALLATION INFORMATION: Model # _____________________________________...
  • Page 16 Catalog No: OM58---130 Copyright 2010 Carrier Corp. S 7310 W. Morris St. S Indianapolis, IN 46231 Printed in U.S.A. Edition Date: 01/10 Manufacturer reserves the right to change, at any time, specifications and designs without notice and without obligations. Replaces: New...

This manual is also suitable for:

Condensing gas furnace

Table of Contents