Table of Contents
Advertisement
Parts Included*
• Generator
• Wheel kit
• Locking 30 Amp plug
• Engine oil
• Two packets of fuel stabilizer
• Owner's manual
• Engine manual
*If any parts are missing or damaged, call 1-800-270-1408.
Model No. 1646-3 (5,550 Watt AC Generator) Manual No. 193711GS Revision 4 (11/29/2004)
Owner's Manual
Questions? Help is just a moment away!
Call: Generac Generator Helpline - 1-800-270-1408 M-F 8-5 CT
Web: www.generac-portables.com or www.briggsandstratton.com
Table of Contents
Safety Rules . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-4
Know Your Generator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-7
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-11
Product Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Notes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Last Page
Advertisement
Table of Contents
Related Manuals for Generac Power Systems WHEELHOUSE 1646-3
Summary of Contents for Generac Power Systems WHEELHOUSE 1646-3
-
Page 1: Table Of Contents
• Owner's manual • Engine manual *If any parts are missing or damaged, call 1-800-270-1408. Call: Generac Generator Helpline - 1-800-270-1408 M-F 8-5 CT Web: www.generac-portables.com or www.briggsandstratton.com Model No. 1646-3 (5,550 Watt AC Generator) Manual No. 193711GS Revision 4 (11/29/2004) Owner’s Manual... -
Page 2: Safety Rules
EQUIPMENT DESCRIPTION Read this manual carefully and become familiar with your generator. Know its applications, its limitations and any hazards involved. The generators are an engine–driven, revolving field, alternating current (AC) generator. It was designed to supply electrical power for operating compatible electrical lighting, appliances, tools and motor loads.The generator’s revolving field is driven at about 3,600 rpm by a single- cylinder engine. - Page 3 WheelHouse™ 5550 Watt Generator WARNING Running generator gives off carbon monoxide, an odorless, colorless, poison gas. Breathing carbon monoxide will cause nausea, fainting or death. • Operate generator ONLY outdoors. • Keep exhaust gas from entering a confined area through windows, doors, ventilation intakes or other openings.
- Page 4 • Use generator only for intended uses. • If you have questions about intended use, ask dealer or call the Generac generator helpline at 1-800-270-1408. • Operate generator only on level surfaces. • DO NOT expose generator to excessive moisture, dust, dirt, or corrosive vapors.
-
Page 5: Know Your Generator
KNOW YOUR GENERATOR Read this owner’s manual and safety rules before operating your generator. Compare the illustrations with your generator, to familiarize yourself with the locations of various controls and adjustments. Save this manual for future reference. Oil Fill Cap/Dipstick Removable Fuel Tank 120 Volt AC, 20 Amp Duplex Receptacle... -
Page 6: Assembly
ASSEMBLY Your generator requires some assembly and is ready for use after it has been properly serviced with the recommended oil and fuel. If you have any problems with the assembly of your generator, please call the generator helpline at 1-800-270-1408. Remove Generator From Carton •... - Page 7 is relieved by turning the vent knob fully counterclockwise or loosening and retightening the fuel cap/gauge.When installing the tank on your generator, relieve tank pressure before tightening the four large plastic wing nuts. IMPORTANT: The vent knob should be closed whenever you move the generator or transport the fuel tank.
-
Page 8: Using The Generator
USING THE GENERATOR System Ground The generator has a system ground that connects the generator frame components to the ground terminals on the AC output receptacles.The system ground is connected to the AC neutral wire (see “Equipment Description”, earlier in this manual). Special Requirements There may be Federal or State Occupational Safety and Health Administration (OSHA) regulations, local codes, or... -
Page 9: Starting/Stopping Engine
OPERATING THE GENERATOR CAUTION Exceeding generators wattage/amperage capacity can damage generator and/or electrical devices connected to it. • See “Don’t Overload Generator”. • Start generator and let engine stabilize before connecting electrical loads. • Connect electrical loads in OFF position, then turn ON for operation. - Page 10 RECEPTACLES CAUTION Receptacles may be marked with rating value greater than generator output capacity. • NEVER attempt to power a device requiring more amperage than generator or receptacle can supply. • DO NOT overload the generator. See “Don’t Overload Generator”. 120 Volt AC, 20 Amp, Duplex Receptacle Each receptacle (Figure 9) is protected against overload by...
-
Page 11: Power Management
DON'T OVERLOAD GENERATOR Capacity You must make sure your generator can supply enough rated (running) and surge (starting) watts for the items you will power at the same time. Follow these simple steps: Select the items you will power at the same time. Total the rated (running) watts of these items.This is the amount of power your generator must produce to keep your items running. -
Page 12: Product Specifications
NEVER operate a damaged or defective generator. NOTE: Should you have questions about replacing components on your Generac Portable Products generator, please call 1-800-270-1408 for assistance. Engine Maintenance See engine owner’s manual for instructions. -
Page 13: Storage
STORAGE The generator should be started at least once every seven days and allowed to run at least 30 minutes. If this cannot be done and you must store the unit for more than 30 days, use the following guidelines to prepare it for storage. -
Page 14: Troubleshooting
TROUBLESHOOTING Problem Engine is running, but no AC output is available. Engine runs good but bogs down when loads are connected. Engine will not start; or starts and runs rough. Engine shuts down during operation. Engine lacks power. WheelHouse™ 5550 Watt Generator Cause Circuit breaker is open. -
Page 15: Notes
WheelHouse™ 5550 Watt Generator NOTES... -
Page 16: Warranty
GENERAC PORTABLE PRODUCTS OWNER EQUIPMENT WARRANTY POLICY "Generac Portable Products is a licensed trademark of Briggs & Stratton Power Products. Briggs & Stratton Power Products will repair or replace, free of charge, any part, or parts of the equipment** that are defective in material or workmanship or both.