1. Manuals
  2. Brands
  3. Honeywell Manuals
  4. Security System
  5. Manning GM-1
  6. Instruction and installation manual

Honeywell Manning GM-1 Instruction And Installation Manual

Gas monitoring alarm system
Hide thumbs
Table of Contents

Advertisement

Quick Links

Gas Monitoring Alarm System
Manning GM-1
Instruction and Installation Manual
07/09
Release D Draft
Honeywell Confidential & Proprietary
This work contains valuable, confidential, and proprietary information. Disclosure, use
or reproduction outside of Honeywell Inc. is prohibited except as authorized in writing.
This unpublished work is protected by the laws of the United States and other countries.
Manning GM-1 Gas Monitoring Alarm System
1
19546 GM1 07/09 REVD Copyright © 2009 Honeywell Analytics. All Rights Reserved.

Advertisement

Table of Contents
loading

Related Manuals for Honeywell Manning GM-1

Summary of Contents for Honeywell Manning GM-1

  • Page 1 Honeywell Confidential & Proprietary This work contains valuable, confidential, and proprietary information. Disclosure, use or reproduction outside of Honeywell Inc. is prohibited except as authorized in writing. This unpublished work is protected by the laws of the United States and other countries.
  • Page 2 In no event is Honeywell liable to anyone for any indirect, special or consequential damages. The information and specifications in this document are subject to change without notice.
  • Page 3 (data) on the system being damaged or lost, or may result in the inability to properly operate the process. Manning GM-1 Gas Monitoring Alarm System 19546 GM1 07/09 REVD Copyright © 2009 Honeywell Analytics. All Rights Reserved.
  • Page 4 Limited Warranty Introduction This manual has been prepared to help in the use and installation of the Manning GM-1 Gas Monitoring Alarm System. This manual will convey the operating details of the alarm system, ensure proper installation, and demonstrate start-up and routine maintenance procedures.

  • Page 5: System Description

    All components that are in contact with voltages above 40 volts are UL listed, including the enclosure. Note: The Manning GM-1 is for use in non-classified areas only. Manning GM-1 Gas Monitoring Alarm System 19546 GM1 07/09 REVD Copyright © 2009 Honeywell Analytics. All Rights Reserved.

  • Page 6: System Specifications

    Relay Ratings: 3 amps at 24 VDC or 120 VAC Form C providing NO (normally open) or NC (normally closed) option Manning GM-1 Gas Monitoring Alarm System 19546 GM1 07/09 REVD Copyright © 2009 Honeywell Analytics. All Rights Reserved.

  • Page 7: Installation

    • If hole drilling is required, be sure to remove all metal filings. • Mounting dimensions are included in Figure 1. Manning GM-1 Gas Monitoring Alarm System 19546 GM1 07/09 REVD Copyright © 2009 Honeywell Analytics. All Rights Reserved.
  • Page 8 Electrical Power: 120 VAC, 50/60 Hz, 0.35 amps. • Electrical power ground: The unit must be properly grounded. Risk of electric shock. Manning GM-1 Gas Monitoring Alarm System 19546 GM1 07/09 REVD Copyright © 2009 Honeywell Analytics. All Rights Reserved.
  • Page 9 Installation continued Figure 2: Wiring diagram for the Manning GM-1 Gas Monitoring Alarm System WARNING ALARM ADJUST ADJUST +20V BOT TOP WARNING ALARM WARNING ALARM FAULT RELAY RELAY RELAY FUSE RATING 250V 1.0 AMP + 24 SHLD GND 120 VAC...

  • Page 10: Operation

    DIP switches on bottom of board Do Not Adjust! Factory set pots Black Risk of electrical shock. Potential hazard. Manning GM-1 Gas Monitoring Alarm System 19546 GM1 07/09 REVD Copyright © 2009 Honeywell Analytics. All Rights Reserved.

  • Page 11: Troubleshooting

    Manning GM-1 Gas Monitoring Alarm System 19546 GM1 07/09 REVD Copyright © 2009 Honeywell Analytics. All Rights Reserved.

  • Page 12: Replacement Parts

    RELAY* RELAY* RELAY* MODEL G/M MAINBOARD REV D Signal from sensor Power supply voltage to sensor Risk of electrical shock. Potential hazard. Manning GM-1 Gas Monitoring Alarm System 19546 GM1 07/09 REVD Copyright © 2009 Honeywell Analytics. All Rights Reserved.

  • Page 13: Limited Warranty

    PURCHASER MORE THAN ONE YEAR AFTER THE CAUSE OF ACTIONS HAS OCCURRED. Manning GM-1 Gas Monitoring Alarm System 19546 GM1 07/09 REVD Copyright © 2009 Honeywell Analytics. All Rights Reserved.

Table of Contents