Lanier Toner for 6113, 6213, 6413, 6514 117- 0225 Datasheet

Identity:
Toner for 6113, 6213, 6413, 6514
Product ID: 117- 0225
Synonyms Toner, Black Toner for Lanier
& Common M6113, 6213, 6413, 6514
Names:
Uses: M6113, 6213, 6413, 6514 Copier
Chemical Mixture, Inert resinated black
Formula: powder
Styrene-acrylic resin
Carbon black
Wax
Organic pigment
Silica
3
*PEL of the product: 15mg/m (total dust), 5mg/m
3
*TLV of the product: 10mg/m (total dust), 5mg/m
HMIS Rating:
FLAMMABILITY = 0
REACTIVITY = 0
Health Hazards (Acute, Chronic, Immediate and Potential): Minimum irritation to respiratory tract may occur as with exposure to any non-toxic dust. May
cause gasping if inhaled. Inhalation should be avoided. May cause temporary eye discomfort.
Health Hazards of Long Term exposure (Chronic): A manufacturer sponsored chronic inhalation study in rats using a special test toner revealed there
were no lung changes at all in the lowest exposure level (1mg/m
noted in 25% of the animals at the middle exposure level (4mg/m
all animals. These findings are attributed to "Lung Overloading", a generic response to excessive amount of any dust retained in the lungs for a prolonged
interval. The special test toner was ten times more respirable than commercially available toner to comply with EPA testing protocol and would not function
properly in xerographic equipment.
Remove to fresh air if effects occur. Consult
Inhalation:
local medical personnel
Wash with soap and water.
Skin Contact:
Suitable extinguishing media:
Extinguishing media which may not be used for safety reasons: none
This material will burn in case of fire.
Special protective equipment for fire fighters: none
UEL: n/a
MATERIAL SAFETY DATA SHEET
Section 1: Chemical Product and Company Information
Section 2: Composition / Information on Ingredients
PERCENT
85 ~ 90
5 ~ 10
1 ~ 5
1 ~ 5
< 1
3
(respirable dust)
3
(respirable dust)
Section 3: Hazards Identification
3
), the most relevant level to potential human exposures. A very slight degree of fibrosis was
3
), while a slight degree of fibrosis was observed at the highest exposure level (16mg/m
Section 4: First Aid Measures
Section 5: Fire Fighting Measures
CO , dry chemical, foam or water.
2
The decomposition products are CO, CO
LEL: n/a
MSDS No.
CP-300
Issued: 9/17/98
Supersedes: 3/11/96
Date:
9/17/98
Prepared by:
Lanier QA/EH&S Department
European
Lanier Worldwide, WSM Europe,
Contact:
Walter Fricke,
Im Taubental D-41468 Neuss,
Germany +49-2131-387-177
CAS No. EXPOSURE LIMITS
25767-47-9
1333-86-4 3.5mg/m
9003-07-7
102561-46-6
7631-86-9
HEALTH = 0
SPECIAL = none
Eye Contact In case of contact, immediately flush eyes with
:
water for 5 minutes.
Ingestion Dilute stomach contents with water. Call a
:
physician.
, and No
2
1
Lanier Worldwide, Inc.
2300 Parklake Dr., N. E.
Atlanta, GA 30345-2979
Emergency Telephone: (800)526-4371
SOURCE
not listed
3 3
3.5mg/m OSHA PEL ACGIH TLV
not listed
not listed
not listed
. Avoid inhalation of smoke.
x
n/a
n/a
n/a
n/a
3
) in