Lanier Toner for 9060 POD 117-0237 Material Safety Data Sheet

Identity:
Toner for 9060 POD
Product ID: 117-0237
Synonyms
& Common Toner, Black Tonerer for Lanier
Names: 9060 POD
Uses: 9060 POD
Chemical
Formula: Mixture
Carbon black
Polyester resin
Polyester resin
Wax
Pigment
3
*PEL as the product: 15mg/m (total dust), 5mg/m
3
*TLV as the product: 10mg/m (total dust), 5mg/m
Hazard Rating:
FIRE = 1
REACTIVITY = 0
Health Hazards (Acute, Chronic, Immediate and Potential): Minimum irritation to respiratory tract may occur as with exposure to any
non-toxic dust. May cause gasping if inhaled. Inhalation should be avoided. May cause temporary eye discomfort.
Health Hazards of Long Term exposure (Chronic):
toner revealed there were no lung changes at all in the lowest exposure level (1mg/m
exposures. A very slight degree of fibrosis was noted in 25% of the animals at the middle exposure level (4mg/m
degree of fibrosis was observed at the highest exposure level (16mg/m
Overloading", a generic response to excessive amount of any dust retained in the lungs for a prolonged interval. The special test
toner was ten times more respirable than commercially available toner to comply with EPA testing protocol and would not function
properly in Xerographic equipment.
Remove to fresh air if effects occur. Consult
Inhalation:
local medical personnel
Wash with soap and water.
Skin Contact:
Suitable extinguishing media:
Extinguishing media which may not be used for safety reasons: none
MATERIAL SAFETY DATA SHEET
Section 1: Chemical Product and Company Information
Section 2: Composition / Information on Ingredients
PERCENT
6 - 8
<94 TSCA Confidential
3
(respirable dust)
3
(respirable dust)
Section 3: Hazards Identification
A manufacturer sponsored chronic inhalation study in rats using a special test
Section 4: First Aid Measures
Section 5: Fire Fighting Measures
CO , dry chemical, foam or water.
2
Emergency Telephone: (800)526-4371
MSDS No.
CP-312
Issued: 01/05/98
Supersedes: none
Date:
01/26/98
Prepared by:
Lanier QA/EH&S Department
European
Lanier Worldwide, WSM Europe,
Contact:
Walter Fricke,
Im Taubental D-41468 Neuss,
Germany +49-2131-387-177
CAS No. EXPOSURE LIMITS
1333-86-4 3.5mg/m
75214-60-7
Trade Secret No.
80100252-5001-P
9003-07-0
31714-55-3
HEALTH = 1
SPECIAL = none
3
), the most relevant level to potential human
3
) in all animals. These findings are attributed to "Lung
Eye Contact In case of contact, immediately flush eyes with
:
water for 5 minutes.
Ingestion Dilute stomach contents with water. Call a
:
physician
1
Lanier Worldwide, Inc.
2300 Parklake Dr., N. E.
Atlanta, GA 30345-2979
SOURCE
3 3
3.5mg/m OSHA PEL
not listed
not listed
not listed
3
), while a slight
ACGIH TLV
n/a
n/a
n/a
n/a