Page 1: Table Of Contents
PORTABLE CELLULAR TELEPHONE SCH-1500 Series SERVICE Manual PORTABLE CELLULAR TELEPHONE CONTENTS 1. General Introduction 2. Specification 3. Installation 4. Nam Programming 5. Product Support Tools 6. Circuit Description 7. Test Procedure TALK END/ 8. Trouble Shooting 9. Exploded Views and Parts List...
Page 2 ELECTRONICS Samsung Electronics Co.,Ltd.
Page 3: General Introduction
Unit shall comply with Personal Station Class II. Analog Receiver/Transmitter Specifications and Requirements The Subscriber Unit shall comply with TIA/EIA IS-95A and meet or exceed TIA/EIA IS-95. The Subscriber Unit shall comply with Mobile Station Power Class III (600mW). Samsung Electronics...
Page 4 General Introduction Memo Samsung Electronics...
Page 5: Specification
: 13.7V DC (± 10%) Size and Weight including standard battery : 14.6 x 5.4 x 2.5 cm, 191 cc, 220 g (7.7 ounces) including extended-life battery : 14.6 x 5.4 x 3.35 cm, 250 cc, 226 g (7.9 ounces) Samsung Electronics...
Page 6 : above 65 dB + 90 kHz ~ 2f : above 63 + 10LOG (Py) dB (where f = carrier frequency, Py = mean output power in watts) Harmonic and Conducted Spurious Emissions : above 43 + 10 LOG (Py) dB Samsung Electronics...
Page 7 25 ~ 70 MHz -45 dBm 70 ~ 130 MHz -41 dBm 130 ~ 174 MHz -41 ~ -32 dBm 174 ~ 260 MHz -32 dBm 260 ~ 470 MHz -32 ~ -26 dBm 470 ~ 1 GHz -21 dBm Samsung Electronics...
Page 8 Intermodulation Spurious Response Attenuation : lower than 1% Rx power = -101 dBm Tone power 1 = -43 dBm Tone power 2 = -43 dBm Tone 1 offset from carrier = ±1.25 MHz Tone 2 offset from carrier = ±2.05 MHz Samsung Electronics...
Page 9 9 TV : Tx vocoder rate (8 is full rate, 1 is 1/8th rate) 10 RV : Rx vocoder rate (8 is full rate, 1 is 1/8th rate) 11 xx : Walsh code used in traffic channel 12 System acquisition state Samsung Electronics...
Page 10 SATx CHxxxx 5 RSSIxxx : RSSI value 6 CHxxx : Using Channel 7 Handset Status : 1 - Initialization state 2 - Idle state 3 - System Access state 4 - Voice channel state 8 System acquisition state Samsung Electronics...
Page 11: Installation
Standard Battery Extended battery SCH-1500 MAIN EXTENDED BATTERY BATTERY PACK (Li-Ion, 850mAH) (Li-Ion, 1350mAH) PACK : BTL859S : BTL1359L Charging Time 3 hours 5 hours SEC. code GH43-10114A GH43-10113A DTC : DTC59 Figure 3-1 Charging the Phone and Battery Samsung Electronics...
Page 12 Tighten the antenna nut fully. Reassemble the two halves of the clamshell together. Adjust the mounting angle and tighten the two slotted screws. CRADLE ANTENNA CLAM SHELL MOUNT UPPER HANDS FREE BOX FIXED SCREW CLAM SHELL MOUNT LOWER Figure 3-2 Cradle Installation Samsung Electronics...
Page 13 Normal place is the sun visor. Once the microphone has been correctly positioned, connect the microphone wire to the MIC jack on the hands-free box. MOUNTING BRACKET Figure 3-3 Hands-Free Box Installation Samsung Electronics...
Page 14 (+) terminal, black wire to the vehicle metal edge that may damage it. chassis. Then connect the battery (-) terminal to the vehicle chassis. Connect the other end of the power cable to the PWR jack of the hands-free box. Figure 3-4 Cable Connections Samsung Electronics...
Page 15: Nam Programming
Slot Mode Slot mode. ÔYesÕ indicates the slot mode. m or i -changes the status. -store it. Slot Index Slot mode index. The higher, the longer sleeping time. 0 ~ 7 -to change, enter new one. -stores it. Samsung Electronics...
Page 16 -stores it. IMSI Mobile Network Code, current code is displayed. IMSI_MNC Number -to change, enter new one. -stores it. CDMA Access Overload Class, current status is displayed. CDMA ACCOLC Class number -to change, enter new one. -stores it. Samsung Electronics...
Page 17 -stores it. HOME SID SID written in the list, current status is displayed. 1700 Number -to change, enter new one. -store it. NID written in the list, current status is displayed. Number -to change, enter new one. -stores it. Samsung Electronics...
Page 18: General Setup
Slot mode. ÔYesÕ indicates the slot mode. Slot Mode m or i -changes the status. -store it. Slot mode index. The higher, the longer sleeping time. Slot Index 0 ~ 7 -to change, enter new one. -stores it. Samsung Electronics...
Page 19 Mobile ID 1234567890 4-2-3 Phone # NAM2 LCD Display Key in Function SVC Menum i Choose ÔPhone#Õ. 1:Phone# 2:General 3:NAM1 4:NAM2 Choose ÔNAM2Õ. Phone # 1:NAM1 2:NAM2 Phone # Phone number 1234567890 Mobile ID # Mobile ID 1234567890 Samsung Electronics...
Page 20 -stores it. SID written in the list, current status is displayed. HOME SID Number -to change, enter new one. 1700 -store it. NID written in the list, current status is displayed. Number -to change, enter new one. -stores it. Samsung Electronics...
Page 21 -stores it. SID written in the list, current status is displayed. HOME SID Number -to change, enter new one. 1700 -store it. NID written in the list, current status is displayed. Number -to change, enter new one. -stores it. Samsung Electronics...
Page 22 NAM Programming Memo Samsung Electronics...
Page 23: Product Support Tools
Caution : When you use the PST program with a notebook PC, you might encounter some problems. Check your serial port setup in your notebook PC (see your notebook PC manual). DonÕt worry about the serial port setup when you use a desktop PC. Samsung Electronics...
Page 24: Getting Started
<Alt-X> key, and the PST program is over. Use this command to enter the name of a file whose extension is ÒmmcÓ. The values read from the named file will initialize the parameter values seen on the ÒEdit Parameters.Ó Samsung Electronics...
Page 25 All fields display the question marks instead of data. After reading from a phone or a file, if the question marks still show in a field, then that item has never been written to the phone or saved to the file. Samsung Electronics...
Page 26 3. Press <ALT-D> key to begin download. Various messages and progress bar will inform the user of the progress of the download. Caution : DO NOT REMOVE POWER WHILE THE PHONE IS BEING DOWNLOADED ! 4. Press <Esc> key to return to Main Menu. Samsung Electronics...
Page 27: Circuit Description
LCD module contains a controller which will display the information onto the LCD by 8-bit data from the MSM. It also consists a DC-DC converter to supply -3.5V for fine view angle and LCD reflector to improve the display efficiency. Samsung Electronics...
Page 28 Digital Converter (ADC) reference clock used in SLEEP/ changes to LOW, all the pins except for the TX mode. TXCO is disabled. ¥CHIPX8 : ADC reference clock used in CDMA RX mode. ¥FMCLK : Reference clock in FM RX mode. Samsung Electronics...
Page 29 Q5312 I_OFFSET, Q_OFFSET CDMA CDMA TXCLK, TXCLK/ MODE BASEBAND TX_IQDATA0~7 PCM_CLK ANALOG 2 VOCODER PCM_SYNC (BBA2) CORE MODE PCM_DIN CODEC FM_RX_IDATA PCM_DOUT FM_RX_QDATA FM_RX_STB FM_RX_CLK PROCESSING TXCO/4 ADC_ENABLE GENERAL ADC_DATA PURPOSE ADC_CLK SUPPORT Figure 6-1 Baseband Block Diagram Samsung Electronics...
Page 30: Audio Part
2 serial LPF consisting of R341, C342, R340, and C341, amplified at the speaker amp (U330), and comes out to speaker. In hands-free mode, the key tone is applied to RX audio line through the LPF and C338, R335. Samsung Electronics...
Page 31 The band width is 60MHz. DUPLEXER Duplexer (F406) controls to transmit through the antenna only the signals within acceptable Tx frequency range (1880 ±30MHz). It also matches LNA (U401) input in receiving part and PA out in transmitter part with the antenna. Samsung Electronics...
Page 32 The RF BPF (F403) passes only a specific frequency LNA (U404) input in receiving part and PA out in (881.49±12.5MHz) from the signal received from the transmitter part with the antenna. mobile station. The band width is 25MHz. Samsung Electronics...
Page 33 The signal out to BBA (Base Band Analog) should supplies 4.2V to the others. be a constant level. The TX IF AGC amp (U501) controls power to keep the signal at a constant level. Dynamic range is 85dB, up gain -40dB, and down gain -45dB. Samsung Electronics...
Page 34 The TX IF AGC Amp (U501) TX AGC Amp (U501). U130 supplies 4.8V to power controls power to keep the signal at a constant level. amp (U571). Dynamic range is 85dB, up gain -40dB, and down gain -45dB. Samsung Electronics...
Page 35 Secondary filter : L1, L2, C9, C12 This circuit minimizes the ripple noise in the dc VOLTAGE DETECTION : HIC signal output from the rectifier. HIC pin 12 and 13 detect the input voltage which applies to u-COM A/D terminal. Samsung Electronics...
Page 36: Travel Charger
Secondary filter circuit : L20, C22 It minimizes the high frequency ripple noise, which is caused by primary oscilation. Reverse current protection circuit : D20 When power is off, it protects the reverse flow of current from battery pack. 6-10 Samsung Electronics...
Page 37 ID and GND. reference voltage. CURRENT DETECTION CIRCUIT : R14, R15, R16, U4 Battery charging current is changed voltage through R14, R15, R16. This voltage inputted U-COM to 16 times amplifiered through U4. Samsung Electronics 6-11...
Page 38: Cigarette Lighter Adaptor
Protection Circuit is the circuit against the (Cigarette Lighter Adapter) for the SCH-1500 electrical stress which is occured at unexpected DBDM phone of SAMSUNG. conditions of the source power of CLA unit such as reverse voltage or overcurrent. ¥ Detection of DBDM phone...
Page 39 HHP, and to convert from u-processor controls this circuit to attenuate echo hands-free mode to private mode, and vice verse. It which may occur in Land side. adjusts speaker volume at 8 steps and attenuates echo and noise occurred during conversation. Samsung Electronics 6-13...
Page 40: Test Command Table
34(A2, 0, 0) T_CDATA_I Transmit continuous 5-word Reverse CTL CH message. 35(A3, 0, 0) T_VOLUME_UP_I Increase value of the last command. (Only for autotest) 36(A4, 0, 0) T_VOLUME_DOWN_I Decrease value of the last command. (Only for autotest) 6-14 Samsung Electronics...
Page 41 Change pdm TX AGC in CDMA. 72(D2, 3, 0) T_AMPS_TXADJ_I Change pdm TX AGC in AMPS. 73(D3, 1, 0) T_SET_PA_R_I Set PA R1, R0 in CDMA. 74(D4, 4, 0) T_TXRAS_ADJ_I TX Ras table adjust. 75(D5, 0, 3) T_READ_RSSI_I Read a RSSI. Samsung Electronics 6-15...
Page 42 EEPROM, use T-SAVE-VAL-I command to store the test value into the corresponding position. *OP: Operation Command Number AB: Input Argument Byte Number RB: Return Byte Number *SAT 32, 33 are not operating in MSM2 CHIP test *46 command is required in Rx, and Tx path test at AMPS mode. 6-16 Samsung Electronics...
Page 43: Test Procedure
Test Cable Duplexer Out Antenna In From To ANT In Duplexer Out RF In/Out HP83236B Directional Coupler Test Jig DC Power Supply (+7.2 V) 7-2-2 Hands-Free HANDS FREE KIT BOX ANTENNA CRADLE DATA DC POWER Orange SUPPLY Black (+13.7V) Samsung Electronics...
Page 44 CONNECT TO DB25 CONNECTOR OF CONNECT TO HHP TEST CABLE BNC CONNECTOR CONNECT TO RF IN/OUT PORT OF TEST EQUIPMENT Cable Loss : 1.2 ~ 2.1 dB Items needed to purchase from SAMSUNG ITEMS PARTS# REMARK RF TEST CABLE GH97-00687A * Cable Loss : 1.9 GHz (PCS) 2.1 dB, 800 MHz (Cellular) 1.2 dB...
Page 45 [SEND]/[END/ ] keys. ¥ The command [0 7] means carrier on. ex) [7 2 X X X] ¥ If you enter the command [3 4] you can ¥ [#] key means the escape of current command. spread the carrier. Samsung Electronics...
Page 46 Test Procedure Memo Samsung Electronics...
Page 47: Troubleshooting
U120 pin 3,4 input =5.2V? Check U120 and its neighboring circuits Check U110 and its neighboring circuits. U110 pin6 input = S5.2V? U120 pin 6 output=3.3V? Check U120 and its neighboring circuits. U110 pin 4 output=3.3V? Check U110 and its neighboring circuits. Samsung Electronics...
Page 48 U200 pin59, U600 pin79. U600 pin 52? Check the LED and its neighboring LED on? circuits. Replace if required. Normal initial Check the LCD pins and its neighboring display on LCD? circuits. Replace if required. Samsung Electronics...
Page 49 U100 pin 60 drive Q140 Replace if required. through R144? Check R146, R147, R148 and Normal Q141 operation? Q141. Replace if required. The voltage applied Resolder R141 and R142. to LCD pins 38, 41? Backlight LED on Samsung Electronics...
Page 50 8-1-4 Abnormal Key Data Input Check initial status. Scanning signals Resolder U100 pins 159, 160 outputted from U100 pins159, and 163-167. 160, 163-167? Resolder U100 pins 168, 169, 170, 172 and 173. Resolder J100. Normal Key data input? Replace the Keypad assembly. Samsung Electronics...
Page 51 U100 pin 49? CLK waveform applied Resolder R341, C342, R340, C341, from U330 pin 2? C337, and C334 Check U330, C333, and C334. CLK waveform applied Replace if required. to U330 pin 3? Normal keytone? Replace the Keypad assembly. Samsung Electronics...
Page 52 Check U100 pin 56. Replace if required. Check Q350, Q351, R350 and D350. CLK waveform applied Replace if required. to J100 pin 12? Is the buzzer Connect the buzzer correctly. connection correct? Check the buzzer and replace if required. Samsung Electronics...
Page 53: Receiver Section
Check IF Filter Check IF Filter in/output OK? soldering. (Loss: -5dB) Check 2nd Check AGC amp Check PLL(U640) local & AGC control in/output OK? & BBA #80. vlotage OK? (Gain: +/-45dB) RF RX AMPS OK. (BBA input: -53dBm) Samsung Electronics...
Page 54 Troubleshooting 8-2-2 PCS mode Start PCS mode. Normal PCS SVC Check PCS Rx path. & ROAM OK? Check Transmitter. Setup PCS call. OK? Measure PCS FER. Normal PCS RF? Samsung Electronics...
Page 55: Transmitter Section
Check PLL OK? U524(PCS) (AMPS) RF out TX IF Level OK? local level. Level OK? AMPS:-21dBm AMPS:-17dBm AMPS:-10dBm PCS:-13dBM PCS:-4dBM PCS:-3dBm Check U550(PCS) Check U522 (PCS) U562(AMPS) RF U571(AMPS) Out level OK? Pout level. AMPS:3dBm AMPS:28dBm PCS:7dBm PCS:23dBm Samsung Electronics...
Page 56 Set Bat. B as Trickle charge mode Trickle charge mode Bat. B Bat. A Bat. B removed? Bat. A removed? charging finished? charging finished? Set Bat. B as Set Bat. A as Trickle charge mode Trickle charge mode 8-10 Samsung Electronics...
Page 57 Is LED turned on ? Is Q7 turned on? Change AH1504F Check R14, 15, 16, U2B, U2A Is Q7 turned on ? Check F1, L1, AH1504G Is charge curent Check R14, 15, 16, U2B, U2A over 630mA ? Samsung Electronics 8-11...
Page 58 Is battery pack connected ? Connect battery to a phone Is the value of V/F correct ? Battery pack fault Is the voltage at Check F1, U1, U3, Q8, Q7 pin-5 of U1 high ? Check the interface plug and phone 8-12 Samsung Electronics...
Page 59 Check Q6, U2B, Q4, U1 Is the voltage at Check R6, R7, VR1, U4 R7 under 2.48V ? Is the voltage at Check F1, U1, U3, Q8, Q7 pin-5 of U1 high ? Check the interface plug and phone Samsung Electronics 8-13...
Page 60: Hands Free Kit
Call on Signal Check. and R101, more than 12V(?). Q13, E2 Check To connect Hand Set. Check low state HFPWR > 12V from MGND. Check low STATE from R96 and, Check EXPWR > 12V R19//18//18+//18++//17 (more than 0.3V ?) 8-14 Samsung Electronics...
Page 61 Check C12, R34, and 35 Check U6C(8PIN), Signal OK? Check C14, and U7 SPEAKER Check SPEAKER, output OK? Check SPK PIN, Signal OK? Check Cradle, and Cable Check U8B(7PIN), Signal OK? Check U8, R72, 49, 60, and U10 Samsung Electronics 8-15...
Page 62 Troubleshooting 8-7-3 Data Comm & Cont. Check INTPWR PIN, and U4 Check MPU (1PIN), 5V? Normal X1 output? Check C40, and C41 Check MPU 17, and 18PIN, Check D11, D15, Q11, and 12 DATA PULSE? 8-16 Samsung Electronics...
Page 63: Exploded Views And Parts List
9-11 Main Packing Layout 9-11-1 Main Packing Layout (with DTC) 9-11-2 Main Packing Parts List (with DTC) 9-11-3 Main Packing Layout (with TC) 9-11-4 Main Packing Parts List (with TC) 9-12 Hands-Free Kit Packing Layout 9-13 Hands-Free Kit Packing Parts List Samsung Electronics...
Page 64: Dbdm Phone Exploded View
Exploded Views and Parts List 9-1 DBDM Phone Exploded View Samsung Electronics...
Page 65: Dbdm Phone Parts List
RUBBER BUZZER GH73-40649A BUZZER TAPE GH74-10742A KEYPAD PCB ASS’Y GH59-10072A HOLDER MIC GH73-40538A CLOTH POLYESTER GH63-20001A RUBBER BUZZER GH73-40649A SHIELD COVER GH72-41557A GASKET CLOTH BUZZER GH63-20001A SHIELD STRIP(A) GH71-10639A SHIELD TAPE GH74-00100A SHIELD COVER SPONGE GH74-00082A GASKET GH63-00002A Samsung Electronics...
Page 66 EXCEPT SCH-1530/1531 ANTENNA TUBE ANTENNA GH42-10521A BAR CODE LABEL JF68-30527H MACHINE BH M2 L8 STAR 6001-000101 LABEL ID MAIN GH68-31107A SCH-1500 GH68-31166A SCH-1510 GH68-31168A SCH-1530/1531 STD BATT. ASS’Y GH43-10114A LONG BATT. ASS’Y GH43-10113A CONTACT SPONGE GH74-00065A ANTENNA CONTACT GH71-10694A Samsung Electronics...
Page 67: Desk-Top Rapid Charger Exploded View
Exploded Views and Parts List 9-3 Desk-Top Rapid Charger Exploded View Charging Standard Battery 3 hours Time (850mAH) Extended Battery 5 hours (1350mAH) Environmental Charge C ~ 40 Specification Storage C ~ 80 Desk-Top Rapid Charger Ass’y : GH44-40072A Samsung Electronics...
Page 68: Desk-Top Rapid Charger Parts List
CASE, TOP HOUSING, BATTERY HOOK, PLATE (LARGE) HOOK (B) WASHER VH, M2.6, L6 (2W), BLK HOOK (A) VH, M3, L8, BLK ASS’Y, AC POWER CORD ASS’Y, R/C BOARD CASE, BOTTOM BUMPON VH, M2.6, L12(2W), BLK LABEL, ID, R/C Samsung Electronics...
Page 69 Exploded Views and Parts List 9-5 Travel Charger Travel Charger Ass’y : GH44-40082A Charging Standard Battery 3 hours Time (850mAH) Extended Battery 6 hours (1350mAH) Environmental Charge C ~ 40 Specification Storage C ~ 80 Samsung Electronics...
Page 70 Exploded Views and Parts List 9-6 Cigarette Lighter Adaptor Cigatte Lighter Adaptor Ass’y : GH44-40075A Charging Standard Battery 4 hours Time (850mAH) Extended Battery 5 hours (1350mAH) Environmental Charge C ~ 40 Specification Storage C ~ 80 Samsung Electronics...
Page 71: Hands Free Kit Exploded View
Exploded Views and Parts List 9-7 Hands Free Kit Exploded View Hands Free Kit Ass’y : GH96-01103A Samsung Electronics...
Page 72: Hands Free Kit Parts List
LABEL, LOGO, H/F GA68-30642A FELT, SPEAKER, H/F GH74-10521A AUDIO SPEAKER, C/D 3001-000186 TAPTITE, B, BH, +, M3, L6 6003-000115 GH41-1056AA(100) HEATSINK, H/F GH71-10559A BUMPON HOUSING, LOWER, H/F GH97-00694A TAPTITE, B, BH, +, M3, L12 6003-000161 LABEL, ID, HFK GH68-30841A 9-10 Samsung Electronics...
Page 73: Cradle Exploded View
Exploded Views and Parts List 9-9 Cradle Exploded View Samsung Electronics 9-11...
Page 74: Cradle Parts List
TAPTITE, B, BH, +, M2.6, L6, C BLK 6003-000107 PBA, CRADLE GH41-10573A HOUSING, LOWER GH72-40740A TAPTITE, B, BH, +, M2, L6, C BLK 6002-000342 HOLDER, CRADLE GH72-40622A CURL CORD GH39-60506A MAS, B, BH, +, M3, L8 6001-000133 LABEL, ID GH68-30832A DATA CABLE GH81-10504A 9-12 Samsung Electronics...
Page 75: Main Packing Layout
Exploded Views and Parts List 9-11 Main Packing Layout 9-11-1 Main Packing Layout (with DTC) 9 10 11 17 18 19 Samsung Electronics 9-13...
Page 76: Main Packing Parts List (With Dtc)
USER MANUAL GH68-60671A IPR CARD GH68-60564A QUICK REFERENCE GH68-70688A WARRANTY CARD GH68-70560A MAN(BOOK)-INSURANCE GH68-60564A MAIN SET SCH-1500B/XAR GH44-40072A STD BATTERY GH43-10114A HANGER STRAP GH72-41051A SILICAGEL GA69-90502A ACCESSORY GUIDE GH68-00218A ACTIVITY CARD GH68-70750A TERMS & CONDITION CARD GH68-70751A 9-14 Samsung Electronics...
Page 77: Main Packing Layout (With Tc)
Exploded Views and Parts List 9-11-3 Main Packing Layout (with TC) 11 12 14 15 16 17 18 Samsung Electronics 9-15...
Page 78: Main Packing Parts List (With Tc)
GH68-00051A EXCEPT SCH-1510 QUICK REFERENCE (FRENCH) GH68-00053A EXCEPT SCH-1510 WARRANTY CARD GH68-70737A EXCEPT SCH-1510 RESISTRATION CARD GH68-70735A EXCEPT SCH-1510 USER MANUAL (ENGLISH) GH68-00050A EXCEPT SCH-1510 USER MANUAL (FRENCH) GH68-00052A EXCEPT SCH-1510 USER MANUAL GH68-00244A SCH-1510 SILICAGEL GA69-90502A 9-16 Samsung Electronics...
Page 79: Hands-Free Kit Packing Layout
Exploded Views and Parts List 9-12 Hands-Free Kit Packing Layout Samsung Electronics 9-17...
Page 80: Hands-Free Kit Packing Parts List
9-13 Hands-Free Kit Packing Parts List DESCRIPTION SEC. CODE Q’TY REMARK USER’S MANUAL, H/F GH68-60560A ASS’Y, CRADLE GH90-00578A POWER CABLE GH39-10501A ASS’Y, HANDS-FREE MICROPHONE CLAMSHELL, MOUNT ASS’Y, HANDS-FREE KIT/BRACKET MOUNTING GH90-00577A CUSHION, BASE GH69-20550A BOX, GIFT GH69-10842A 9-18 Samsung Electronics...
Page 81: Pcb Diagrams
10. PCB Diagrams 10-1 DBDM Phone 10-1-1 Main Board PCB (REV : 2.1) Top View Bottom View...
Page 82 10-1-2 Memory Board PCB (REV : 2.0)
Page 83 10-2 Desk-Top Rapid Charger Board PCB...
Page 84 10-3 Travel Charger Board PCB...
Page 85 10-4 Cigarette Lighter Adaptor Board PCB...
Page 86 10-5 Hands-Free Kit Board PCB...
Page 87 10-6 Cradle PCB...
Page 88 Memo...
Page 89: Electrical Parts List
Ceramic, 0.1U 2203-000189 C321 Ceramic, 220P 2203-000585 C323 Ceramic, 1U 2203-005065 C324 OPEN_C OPEN_C C325 Ceramic, 0.1U 2203-000189 C326,C327,C328 Ceramic, 15P 2203-000386 C330 Ceramic, 1500P 2203-000138 C331 Ceramic, 5600P 2203-001033 C332 Ceramic, 0.1U 2203-000189 C333,C334 Ceramic, 680P 2203-001124 Samsung Electronics 11-1...
Page 90 2203-000254 C399 Ceramic, 0.1U 2203-000189 C401 Ceramic, 1000P 2203-000438 C402 Ceramic, 2700P 2203-000530 C403 Ceramic, 4P 2203-001017 C405 Ceramic, 100P 2203-000234 C407 Ceramic, 1000P 2203-000438 C408,C409 Ceramic, 100P 2203-000234 C410 Ceramic, 5P 2203-001437 C411 Ceramic, 3P 2203-000870 11-2 Samsung Electronics...
Page 91 2404-000232 C457,C459 Ceramic, 1000P 2203-000438 C462 Ceramic, 0.047UF 2203-001432 C463 Ceramic, 1000P 2203-000438 C464 Ceramic, 47P 2203-000995 C465 Ceramic, 56P 2203-001072 C467 Ceramic, 3P 2203-000870 C468 Ceramic, 1000P 2203-000438 C469,C470 Ceramic, 100P 2203-000234 C471 Ceramic, 20P 2203-000550 Samsung Electronics 11-3...
Page 92 C558 Ceramic, 100P 2203-000234 C559,C560,C561 Ceramic, 15P 2203-000386 C562,C563,C564 Ceramic, 100P 2203-000234 C565 Ceramic, 15P 2203-000386 C566,C567,C568,C569 Ceramic, 100P 2203-000234 C570 Ceramic, 1000P 2203-000438 C571,C572,C573 Tantalum, Chip 3.3U/6.3V 2404-000216 C574 Ceramic, 1000P 2203-000438 C576 Ceramic, 100P 2203-000234 11-4 Samsung Electronics...
Page 93 C632 Ceramic, 6P 2203-001178 C633 Ceramic, 470P 2203-000941 C635 Ceramic, 1000P 2203-000438 C636 Ceramic, 0.047UF 2203-001432 C637 Tantalum, Chip 2.2U/16V 2404-000167 C638,C639,C640 Ceramic, 1000P 2203-000438 C641 Ceramic, 100P 2203-000234 C642 Ceramic, 0.01U 2203-000254 C643,C644 Ceramic, 100P 2203-000234 Samsung Electronics 11-5...
Page 94 C753 Ceramic, 0.1U 2203-000189 C754,C755 Ceramic, 0.01U 2203-000254 C756 Tantalum, Chip 4.7U/10V 2404-000232 C761 Ceramic, 12P 2203-000330 C762,C763 Ceramic, 15P 2203-000386 C764 Ceramic, 100P 2203-000234 C765,C766 Ceramic, 15P 2203-000386 C767,C768 Ceramic, 100P 2203-000234 C770 Ceramic, 15P 2203-000386 11-6 Samsung Electronics...
Page 95 F405 Filter,Duplexer 2909-001004 F406 Filter,Duplexer 2909-001037 F501 Filter-BPF,SAFC130.4 2904-001082 F521,F522 Filter, SAW, 1880MHz 2904-001020 F562 Filter, SAW 2904-001012 F601 FILTER, SAW 2904-001103 - Connectors - J100 Connector,Socket 3710-000341 J200 Connector,Socket 3711-003924 J300 Connector,Socket 3710-001021 J390 Connector,Socket 3710-001105 Samsung Electronics 11-7...
Page 96 Inductor, SMD, 3.3N 2703-001291 L524 Inductor, SMD, 2.2N 2703-001205 L527 Inductor, SMD, 3.9N 2703-001295 L528 Inductor, SMD, 2.2N 2703-001205 L529 Inductor, SMD, 1.8N 2703-001289 L530 Inductor, SMD, 3.3N 2703-001291 L531 Inductor, SMD, 2.7U 2703-000301 L532 Inductor, SMD, 5.6U 2703-001255 11-8 Samsung Electronics...
Page 97 0501-000457 Q351 Digital, DTA144EE 0504-000172 Q380 Digital, DTC144EE 0504-000168 Q390 Small Signal 0501-000457 Q391 Small Signal 0501-000218 Q581 Small Signal 0501-000162 Q582 Small Signal 0501-000218 Q583 Small Signal 0501-000462 Q690 Digital, DTA114EE 0504-001016 Q741,Q742,Q751,Q752 Digital, DTC114EE 0504-000167 Samsung Electronics 11-9...
Page 98 2007-002970 R149,R150 Chip, 10K 2007-000148 R151 Chip, 0 2007-000171 R152,R153 Chip, 10K 2007-000148 R154 Chip, 4.7K 2007-000143 R155 Chip, 39K 2007-000831 R156 Chip, 10K 2007-000148 R157 Chip, 2.2K 2007-000141 R158,R159 Chip, 10K 2007-000148 R160 Chip, 100K 2007-000162 11-10 Samsung Electronics...
Page 99 Chip, 470 2007-000932 R386 Chip, 22K 2007-000153 R387 OPEN_R OPEN_R R388,R389 Chip, 470 2007-000932 R390 OPEN_R OPEN_R R391 Chip, 2.2K 2007-000141 R394 Chip, 4.7K 2007-000143 R395 Chip, 10K 2007-000148 R396 Chip, 4.7K 2007-000143 R397 Chip, 10K 2007-000148 Samsung Electronics 11-11...
Page 100 2007-000138 R521 Chip, 430 2007-003019 R523 Chip, 4.7K 2007-000143 R524 Chip, 18 2007-001288 R528 Chip, 390 2007-007095 R529 Chip, 18K 2007-001333 R561 Chip, 27 2007-003112 R562 Chip, 130K 2007-001336 R563 Chip, 100 2007-000138 R564 Chip, 430 2007-003019 11-12 Samsung Electronics...
Page 101 2007-002796 R644 Chip, 150 2007-001306 R654 Chip, 1K 2007-000140 R655 Chip, 75 2007-007009 R656 Chip, 75 2007-007009 R665,R667,R669 Chip, 100 2007-000138 R670 Chip, 510 2007-002796 R671 Chip, 5.1K 2007-000144 R680 Chip, 100 2007-000138 R690 Chip, 3K 2007-001323 Samsung Electronics 11-13...
Page 102 IC, AGC Amp, 5505 1201-001076 U502 IC, SW-395, SWITCH 1001-001048 U521 Freq, Mixer, MRFIC1813 1205-001267 U522 IC, Drive Amp, BFP450 0501-002067 U524 IC, Drive Amp, AT32011 0501-002060 U542 IC, Freq Isolator 4709-001092 U550 IC, Power Amp, RI21108U 1201-001329 11-14 Samsung Electronics...
Page 103 IC, CMOS Logic, TC7S04F 0801-002192 U712,U713 IC, CMOS Logic, TC7S08F 0801-000303 U741 IC, Voltage Regulator 1203-001501 U742,U750 FET-S/W, SI9933ADY 0505-001170 U751 IC, Voltage Regulator 1203-001501 U752 FET-S/W, SI9933ADY 0505-001170 U760 IC, PWR Splittor, STH03R 4709-001119 X100 Resonator Ceramic, 27MHz 2802-001048 Samsung Electronics 11-15...
Page 104 11-1-2 Memory Board Assembly DESCRIPTION SEC.CODE REMARK - Capacitor - C220 Ceramic 0.1uF 2203-000189 - Connector - J210 60PIN CONN SOCKET 3710-001340 - Resistor - R220, R221 Chip, 10K 2007-000148 - IC’s - U220 FLASH MEMORY 1107-001033 MBM29LV800T 11-16 Samsung Electronics...
Page 105 DIODE SW 75V 225MA, D0-35 D4, 5 DIODE SCHOTKY 5A 60V D0-201AD D6, 7, 8 DIODE SCHOT 40V 1A, D0-41 -Connectors - JUMP WIRE 0.6PHI 10mm JUMP WIRE 0.6PHI 7.5mm JUMP WIRE 0.6PHI 10mm JUMP WIRE 0.6PHI 7.5mm Samsung Electronics 11-17...
Page 106 10K OHM J, MCR10 - Miscellaneous - 1CARTON=1/40 CARTON BOX 0.025 1CARTON=1/40 3PO-233A, (CP-RC800) 0.020 VINYL SACK 4PO-393, 170X350X. 05 1CARTON=2/40 MAIN BOARD 0.050 1CARTON=6/40 CARD BOARD(B) 0.150 1CARTON=12/40 CARD BOARD(A) 0.300 DIODE BRDG 600V 1A, DB TYPE 11-18 Samsung Electronics...
Page 107 PTF1 DTC58 TRANS MAIN TRANS ASS’Y Q1, 2, 3 TRANSISTOR SOT-89 CONN. HEADER 4PIN (5267-04A) CONN. HEADER 3PIN (5267-03A) THERMISTOR 10K OHM/25’C MICOM IC PIC16C72, 28PIN SOP P.C.B DTC57 PCB(CEM-1 1.2T) SEMI-FIXED RES 1K OHM 20% TOP Samsung Electronics 11-19...
Page 108 C28, 29 Ceramic 224 Z Ceramic 473 Z C31, 32, 33 Ceramic 102 Z Ceramic 103 Z C35, 36, 37, 38 Ceramic 100Z Ceramic 102 Z C40, 41 2012 Ceramic 470 Z - Connectors - CON1 HIROSE20 HIROSE20 11-20 Samsung Electronics...
Page 109 KSR1104 MTF - Resistors - Chip 200, 1/4W 3216 Chip 100, 1/4W R3, 4 Chip 390, 1/4W R5, 6, 7, 8, 9 0805 Chip 1 OHM Chip 300 OHM Chip 6.2K OHM Chip 3.9K OHM Chip 10K OHM Samsung Electronics 11-21...
Page 110 Chip 15K OHM Chip 27K OHM Chip 62K OHM Chip 120K OHM Chip 240K OHM Chip 510K OHM Chip 8.2K OHM Chip 3.9K OHM R46, 47 Chip 150k OHM Chip 56K OHM R49, 50, 51 Chip 20K OHM 1% 11-22 Samsung Electronics...
Page 111 Chip 5.1K OHM Chip 20K OHM Chip 30K OHM Chip 100K OHM Chip 1K OHM 0805 Chip 1 OHM R82, 83 Chip 150k OHM Chip 5.1K OHM Chip 100K OHM Chip 240K OHM Chip 3K OHM Chip 51K OHM Samsung Electronics 11-23...
Page 112 SOP-16 MC14051 DIL-28 PIC16C73 - Miscellaneou - CABLE ASS’Y DATA CABLE ASS’Y SCH-300 DATA CABLE CURL CORD ASS’Y 2PIN HARNESS ASS’Y MIC ASS’Y 66dB POWER CABLE ASS’Y FUSE(125V 1.5A) E1, 2 10X16 CAP 470u/35V 8X11.5 CAP 470u/16V 11-24 Samsung Electronics...
Page 113 SCREW TH1 4 x 20B LABEL (HFB21) PH2 3 x 12B PLATE SHIELD AL 0.5T SPONGE PI 15 x 5T L3, 4 L TYPE (13PIE) COIL 400uH 127X86X1.6T FR4 SPEAKER 4 ohm/3W WAFER 2PIN(2.54mm) STRAIGHT X-TAL 3.6864MHz Samsung Electronics 11-25...
Page 114 Chip 1K OHM Chip 12K OHM Chip 1K OHM 0805 Chip 1.5K OHM Chip 1K OHM Chip 220 OHM - Miscellaneou - LEDCON SAM5270 PHOTO INTERRUPT SG-215 53.1X1.6T FR4 THERMISTER 10K -J WAFER R/ANGLE 15p-2mm U$15 WAFER R/ANGLE 12p-2mm 11-26 Samsung Electronics...
Page 115: Block & Circuit Diagrams
12. Block & Circuit Diagrams 12-1 Main Block Diagram 12-2 Desk-Top Rapid Charger Block Diagram 12-3 Travel Charger Block Diagram 12-4 Cigarette Lighter Adaptor Block Diagram 12-5 Hands-Free kit Block Diagram 12-6 Logic Circuit Diagram (REV : 2.1) 12-7 Memory Board Circuit Diagram (REV : 2.0) 12-8 RF Circuit Diagram (REV : 2.1) 12-9 Desk-Top Rapid Charger Circuit Diagram 12-10 Travel Charger Circuit Diagram...
Page 116 12-1 Main Block Diagram...
Page 117 12-2 Desk-Top Rapid Charger Block Diagram...
Page 118 12-3 Travel Charger Block Diagram...
Page 119 12-4 Cigarette Lighter Adaptor Block Diagram...
Page 120 12-5 Hands-Free Kit Block Diagram...
Page 121 12-6 Logic Circuit Diagram (REV : 2.1)
Page 123 12-7 Memory Board Circuit Diagram (REV : 2.0)
Page 124 12-8 RF Circuit Diagram (REV : 2.1)
Page 125 12-9 Desk-Top Rapid Charger Circuit Diagram...
Page 126 12-10 Travel Charger Circuit Diagram...
Page 127 12-11 Cigarette Lighter Adaptor Circuit Diagram...
Page 128 12-12 Hands-Free Circuit Diagram 12-12-1 Power Supply...
Page 129 12-12-2 Audio Amp.
Page 130 12-12-3 Comm. & Cont.
Page 131 12-13 Cradle Circuit Diagram...
Page 132 Memo...

Samsung SCH-1500 series Service Manual

Quick Links

Related Manuals for Samsung SCH-1500 series

Summary of Contents for Samsung SCH-1500 series

Table of Contents