Summary of Contents for Craftsman WEEDWACKER Incredi-Pull 316.796170
Page 1
• OPERATION • MAINTENANCE • PARTS LIST • ESPANOL, P. 17 CAUTION: Before using this product, read this manual and follow safety rules and operating instructions. Sears, Roebuck and Co., Hoffman Estates, IL 60179, U.S.A. Visit our website" www.sears.com/craftsman 769-02806...
SPARK ARRESTOR NOTE CALIFORNIA PROPOSITION 65 WARNING NOTE: For users on U.S. Forest Land and in the states of California, Maine, Oregon and Washington. All U.S. Forest Land and the state of California (Public Resources Codes 4442 and 4443), Oregon and Washington require, by law that certain internal combustion engines operated on forest brush and/or...
Page 3
• Avoid accidental starting. Be in the starting position whenever pulling the starter rope. The operator and unit this tool that are distributed by Sears or a Craftsman outlet. must be in a stable position while starting. Refer to Use of any replacement parts or accessories purchased Starting/Stopping Instructions.
If this Craftsman product fails due to a defect in material or workmanship within two years from the date of purchase, return it to any Sears store, Sears Service Center, or other Craftsman outlet in the United States for free repair. This warranty does not include: •...
Oil Fill Plug Muffler Plug Starter Rope Grip X Shaft Grip On/Off Stop D-Handle Control Fuel Cap Twist & Edge and Choke Lever Craftsman Convertible Coupler Throttle Control Line Cutting Blade Shaft Housing Primer Bulb Air Filter Cover Cutting Attachment...
Page 6
WARNING: OVERFILLING OIL CRANKCASE Using Blended Fuels CAUSE S ERIOUS PERSONAL INJURY. Check a nd If you choose to use a blended fuel, or its use is unavoidable, maintain theproper oillevel inthecrank case; itis follow recommended precautions: important andcannot beoveremphasized. Check •...
Stop/Off WARNING: Operate this unit only in a well- Start/On ventilated outdoor area. Carbon monoxide exhaust fumes can be lethal in a confined area. WARNING: Avoid accidental starting. Make sure you are in the starting position when pulling the starter rope (Fig. 8). To avoid serious injury, the operator and unit must be in a stable position while starting.
Page 8
Hassle-Free Cutting Head the engine. • Cut grass over 8 inches (200 mm) by working from top to Always use Craftsman Hassle-Free bottom in small increments to avoid premature line wear or XTRA QUIET Spiral Line. Choose the engine drag.
Page 9
Upper Shaft Boom CAUTION: Before operating this unit, be sure that the release button is fully snapped into the CRAFTSMAN CONVERTIBLE Attachment primary hole (Fig. 16), and that the knob (Fig. 17) is FEATURE securely tightened. The coupler allows you to convert...
Page 10
NOTE: Maintenance, replacement, or repair of the emission WARNING: Toprevent serious injury, never control devices and system may be performed by a perform maintenance or repairs with unit running. Sears or other qualified service dealer. Always service and repair a cool unit. Disconnect the In order to assure peak performance of your engine, inspection spark pug w re to ensure that the un t cannot start.
NOTE: Use the bottle and spout saved from initial use to measure the correct amount of oil. The top of the label on the bottle measures approximately 3.04 ounces (90 ml) or 3/8 cup (Fig. 22). Check the level, See Checking the Oil Level.
Adjust Idle Speed Screw Remove the engine cover (Fig. 30). WARNING: To prevent serious personal injury, Clean dirt from around the Rocker i make sure the cutting attachment has stopped rocker arm cover. Remove rotating before you turn it off and set it down. the screw holding the rocker If, after checking the fuel and cleaning the air filter, the engine arm cover with a large flat...
Page 13
Muffler Adjusting Nut Spark Arrestor Screen Rocker Arm Diverter T-25 Screw .003-.006in. (.076-.152 Slot qlp_ T-20 Screw _auge Fig. 35 Clean the spark arrestor screen with a wire brush or replace it. Valve Stem Reinstall the spark arrestor screen, spark arrestor diverter Fig.33 and screws.
Page 14
Baffled with Guard Throttle ..................................Manual Spring Return Fuel Tank Capacity ................................14 oz (414 ml) Drive Shaft Housing ........................Steel Tube (Craftsman Convertible Throttle Control ................................Finger-Tip Trigger Approximate Unit Weight (No fuel, with Hassle Free shield & D-handle) .............
Page 15
Felicidades por haber hecho una compra inteligente. Su nuevo Craftsman@ product is designed and manufactured for years of producto Craftsman esta dise_ado y fabricado para que opere de manera confiable durante a_os. Pero como todos los dependable operation. productos, pudiera necesitar una reparaci6n cada cierto But like all products, it may require repair from time to time.
Page 17
PARACH ISPAS CALIFORNIA PROPOSITION 65 WARNING NOTA: Para los usuarios en tierras forestales de los EE.UU. y en los estados de California, Maine, Oregon y Washington. Todos los terrenos forestales de los EE.UU. y el estado de California (C6digos de Recursos PQblicos 4442 y 4443), Oregon y Washington, requieren por decreto, que ciertos motores de LAS EMISIONES DEL MOTOR DE ESTE PRODUCTO combusti6n interna que se hagan funcionar en zonas boscosas...
Page 18
• Use la unidad Onicamente con la luz del dfa o con buena luz • Use s61opiezas y accesorios de repuesto del fabricante del artificial. equipo original para esta unidad. Puede obtenerlos en su proveedor de servicio autorizado. El uso de piezas y accesorios •...
Page 19
GARANTJA LIMITADA DE DOS ANOS, DE CRAFTSMAN Si este producto Craftsman falla debido a un defecto en el material o en la mano de obra dentro de un periodo de dos aSos a partir de la fecha de compra, devuelvalo a cualquier tienda Sears, Centro de Servicio Sears u otto establecimiento de Craftsman en Estados Unidos para que sea reparado sin costo alguno.
Page 20
Traba del regulador Tapbn del aceite Mango Controlde encendido y apagado Manija en D Tapa del combustible Palanca del obturador Craftsman Convertible acoplador Control del regulador Cuchilla de corte de linea Bastidor Cubierta del Bombilla del filtro de aire cebador...
ADVERTENClA: EL LLENAR DEMA- SIADO E L Uso de los combustibles de mezcla CARTER PUEDE CAUSAR LESIONES PERSONALES Si decide usar un combustible de mezcla o si su uso es inevitable, GRAVES Nopodemos exagerar laimportancia le recomendamos que tome las siguientes precauciones: control ymantenimiento del n ivel correcto deaceite •...
Page 22
Parado/ ADVERTENCIA: Use esta unidad s61o en un Area Arranque/ Apagado exterior bien ventilada. Los gases de escape de Encendido (I) mon6xido de carbono pueden ser letales en un Area cerrada. ADVERTENCIA: Evite los arranques accidentales. Col6quese en posici6n de inicio cuando tire de la cuerda de arranque (Fig.
Page 23
XTRA QUIET de linea realice el corte (en especial a Io largo de paredes). Si Craftsman. corta con mas de la punta reducira la eficacia del corte y Seleccione el tama_o de la Ifnea que mejor se adapte al trabajo puede sobrecargar el motor.
Page 24
USO DE I_A FUNCION TWIST AND EDGE Con la caracteristica Craftsman Convertible El acoplador permite que Bastidor accesorio, lea y comprenda el manual que viene usted convierta esta unidad eje inferior/ para uso con los con el accesorio. Siga toda la informaci6n...
PROGRAMA DE MANTENIMIENTO Para asegurar funcionamiento maximo de su motor, la inspecci6n del puerto del extractor del motor puede set Estos procedimientos requeridos para el mantenimiento deben necesaria despues de 50 horas de la operaci6n. Si usted nota ser realizados con la frecuencia indicada en la tabla. Deben ser la RPM perdida, degradaci6n de las prestaciones o carencia...
4. Seque t odoelaceite residual delaunidad y limpie todoel Apriete el filtro para esparcir y aceite q uepueda haberse derramado. Elimine todoel retirar el exceso de aceite (Fig. 26). aceite d eacuerdo conlasnormas federales, estatales y Vuelva a colocar el filtro (Fig. 23). locales.
Inspecci6n del Combustible Vista superior del motor En general, el combustible viejo es el motivo principal para que la unidad no funcione en forma adecuada. Drene y vuelva a Ilenar el tanque con combustible nuevo, limpio y sin plomo antes de hacer ningt]n ajuste. Consulte la InformaciOn acerca del Aceite y Combustible.
Page 28
Tuerca de ajuste 20 y un pedacito T-25, quite los tornillos que unen el desviador de los pararrayos de la chispa al silenciador (Fig. 35). Balancin Silenciador Pantalla del amortiguador de chispas Desviador 0,076 mm - 0,152 T-25 Tornillo mm (,003 pulg. ,006 pulg.) Ranura _::::_/...
Page 29
Regulador ............................... Retorno manual del resorte Capacidad del tanque de combustible ......................... 414 ml (14 onzas) Bastidor del eje impulsor ......................Tube en acier (Craftsman Convertible Control del regulador ..............................Gatillo para el dedo Peso de la unidad (sin combustible, con Hassle Free el protector y el accesorio de corte) ......
Page 30
Felicidades por haber hecho una compra inteligente. Su nuevo Craftsman@ product is designed and manufactured for years of producto Craftsman esta dise_ado y fabricado para que opere de manera confiable durante a_os. Pero como todos los dependable operation. productos, pudiera necesitar una reparaci6n cada cierto But like all products, it may require repair from time to time.
Page 31
REPLACEMENT PARTS - MODEL 316.796170 4-CYCLE GAS TRIMMER...
Page 32
REPLACEMENT PARTS - MODEL 316.796170 4-CYCLE GAS TRIMMER Description Item Part No. Description Item 791-181751 O-Ring 753-05206 Engine Cover Assembly (includes 2 & 3) 753-05302 753-04595 Cover Screw Air Cleaner Cover Assembly (includes 32) 753-05254 Air Filter 791-181003 Screw 753-05253 Screw 753-05209 Rocker Cover...
Page 33
REPLACEMENT PARTS - MODEL 316.796170 4-CYCLE GAS TRIMMER Item Part No. Description '53-04234 Throttle Housing Assembly (includes 2-4) '53-04119 Throttle Trigger '91-182690 Throttle Trigger Spring '91-182405 Switch Assembly '53-05266 Throttle Cable Assembly '53-04236 Upper Drive Shaft Housing '91-180869 Deluxe D-Handle Assembly (includes 8-10) Screw '91-181070...
Page 36
Your Home For repair--in your home--of all major brand appliances, lawn and garden equipment, or heating and cooling systems, no matter who made it, no matter who sold it! For the replacement parts, accessories owner s manuals that you need to do-it-yourself. For Sears professional installation of home appliances...