Related Manuals for Montgomery Ward TMO-3395309
Summary of Contents for Montgomery Ward TMO-3395309
- Page 1 42" Lawn Tractors Operating Manual Model Nos. TMO-3100002 TMO-3395309 Model TM0-3395309 Shown Mom_me_ Wazd...
- Page 2 In the State of California the above is required by law (Section 4442 of the California Public Resources Code). Other states may have similar laws. Federal laws apply on federal lands, A spark arrester for the muffler is avail- able through your nearest engine authorized service center or contact the parts sales center of Montgomery Ward.
- Page 3 IMP0 RTAN T sA,=,= oP,=.,,-.o. AL SAFETY AND/OR PROPERTY OF YOURSELF AND OTHERS. READ AND FOLLOW ALL INSTRUCTIONS IN THIS MANUAL THIS SYMBOL POINTS OUT IMPORTANT SAFETY INSTRUCTIONSWHICH, IF NOT FOLLOWED,COULD ENDANGERTHE PERSON- BEFOREATTEMPTINGTO OPERATEYOUR UNIT. WHEN YOU SEETHIS SYMBOL-- ,_ HEEDITS WARNING.
- Page 4 IV. _r, BYJ £_ other debris build-up. Clean up oil or fuel spillage. Allow 1.Use extra c are in handling gasoline and other fuels. They are machine to cool before storing. flammable and vapors are explosive. 6. Stop and inspect the equipment for damage if you strike an a.
- Page 5 ACTIVATING THE BATTERY ,;_Battery Screwdriver Do not activate battery (fill with battery acid) until Cover battery is actually placed in service. Be certain to read previous warnings before activating the bat- Battery tery. Caps 1. Lift the seat. Remove the battery cover by press- ing in on the sides and lifting up.
- Page 6 Steerin Lock AllACHING THE STEERING WHEEL 1. Remove the hex lock nut and cupped washer from the steering shaft, and remove the steering bellow. Pry the steering cap off the center of the Washer steering wheel. 2. Attach one end of steering bellow to the steering -<------ wheel as shown in figure 4, inset.
- Page 7 TIRE PRESSURE .Negative Terminal The tires on your unit may be over-inflated for ship- ping purposes. Reduce the tire pressure before oper- Battery Positive ating the unit. Recommended operating tire pressure Drain :rminal is approximately 12 p.s,i. (check sidewall o! tire for tire Tube manufacturer's recommended...
- Page 8 controlleverout of the notches andbackward to slow the notches to the desired position. Release lawntractor, f orward to increase speed. W hendesired speed control lever and the clutch-brake pedal. speedhas beenobtained, r eleaseleverin thatposi- NOTE: The parking brake must be set ff the operator tion.Whenever c lutchis engaged, unit will automati-...
- Page 9 OPERATION 3.. Set the throttle control in the FAST position. See figure 9. WARNING 4. Pull out choke knob to choke engine (a warm engine may not require choking). AVOID SERIOUS INJURY OR DEATH GO UP AND DOWN SLOPES, NOT ACROSS.• AVOID SUDDENTURNS. 5.
- Page 10 WARNING: B eforeleavingthe operator's ADJUSTMENTS position for any reason, disengage the blades, place the shift lever in neutral, SEAT ADJUSTMENT engage the parking brake, shut engine off andremovethe key. The seat may be adjusted to different positions. Refer to seat installation section of assembly instructions.
- Page 11 D. Release the clutch-brake pedal completely, then If the full range of speeds cannot be obtained on your slowly depress the pedal all the way (to park unit, adjust the speed control as follows. position). Hold the pedal in this position. 1.
- Page 12 NEUTRAL ADJUSTMENT Dimension "B" should be approximately 1/8" less than 1. Place the transmission in neutral. (The unit will Dimension "A." See figure 16. move freely when pushed forward and backward A.) To increase Dimension "B," screw tie rod into tie with the parking brake released.)
- Page 13 To adjustthe brake,removethe cotterpinfromthe TRANSAXLE castlenut(if so equipped). Adjust t he nutsothe brake The transaxle is lubricated at the factory and does not startsto engage whenthe brakeleveris 1/4"to 5/16" require checking. If disassembled for any reason, awayfromthe axlehousing. lubricate with 10 oz. of Shell grease, part number 737-0148.
- Page 14 CUTTING BLADES DRIVE BELTREMOVAL AND REPLACEMENT A. Removal for Sharpening or Replacement wire and ground it against the engine. WARNING: Disconnect the spark plug ground the spark plug wire and remove Block the wheels of the unit, WARNING: Be sure to disconnect ignition key before working on the cutting NOTE: Figures...
- Page 15 5. Remove the two bolts which hold the shift lever 9. Slide the deck from beneath the lawn tractor. bracket to the frame on the left side of the unit. 10. Remove the belt guards at each deck pulley by Swing the bracket toward the right so the belt can removing the self-tapping screws.
- Page 16 6. Place the clutch-brake pedal in park position. 2. Attach second jumper cable from Negative terminal of the good battery to the 7. Push forward on the variable speed pulley, and FRAME OF THE UNIT WITH THE DEAD BAT- lift the belt off the engine and remove the belt TERY.
- Page 17 TIRES 4. Refer to battery storage instructions on page 16. Recommended operating tire pressure is approxi- 5. Store unit in a clean, dry area. Do not store next mately 12 p.s.i. (check sidewall of tire for tire manu- to corrosive materials, such as fertilizer. facturer's recommended pressure).
- Page 18 TROUBLE SHOOTING GUIDE TROUBLE LOOK REMEDY Engine will not Battery installed incor- battery must be installed with the negative terminal, identified at the terminal post (Neg, N or crank rectly groundecL positive terminal (Pos. P or +) attaches to the large cable from...
- Page 19 TROUBLE SHOOTING GUIDE (Continued) TROUBLE LOOK REMEDY No fuel to the carburetor Gasoline tank empty. Fill Fuel line or in-line fuel filter plugged. Remove and clean fuet line. Replace filter if necessary. Air filter dirty If the air cleaner is dirty, the engine not start.
- Page 20 TMO-3100002 TMO 3395309 " 16 AND 18 H.P. 42" LAWN TRACTORS PARTS LIST FOR MODELS TMO-3100002 AND TMO-3395309 REF. PART iREF. PART DESCRIPTION DESCRIPTION NO. _ 17551A Hood 725-0634 Light Switch 738-0724 725-0925 Ammeter Shld. Bolt .375" Dia. x .125" Lg. 736-0342 Fl-Wash.
- Page 21 TMO-3100002 TMO-3395309 26 _ 16 AND 18 H.P. 42" LAWN TRACTORS PARTS LIST FOR MODELS TMO-3100002 AND TMO-3395309 PART REF, REF, PART DESCRIPTION DESCRIPTION 736-0159 FI-Wash. 344" I.D. x .875" FI-Wash..25" I.D. x .625" O.D. 37 i 736-0463 710-1208 710-0118 Hex Wash.
- Page 22 TMO-3100002 TMO-3395309 To Engine. //7 1. 7...
- Page 23 TMO-3100002 TMO-3395309 16 AND 18 H.P, 42" LAWN TRACTORS PARTS LIST FOR MODELS TMO-3100002 AND TMO-3395309 PART REF. PART DESCRIPTION DESCRIPTION Hex Jam Nut 3/8-24 Thd.* 712-0711 731-0220 Steering Wheel Cap 712-0237 Hex L-Nut 5/16-24 Thd. 17584 Front Axle Ass'y,--R.H, REF.
- Page 24 TMO-3100002 TMO-3395309 TOEN61NE 89', IMPORTANT: only Original Equipment Manufacturer (O.E.M.) V-belts when replacing belts. They of special construction (type cord, cord location, length, etc.). of V-belts other than O.E.M. belts generally will provide only temporary service. best results, use only factory approved parts.
- Page 25 TMO-3100002 TMO-3395309 16 AND 18 H.P. 42" LAWN TRACTORS PARTS LIST FOR MODELS TMOo3100002 AND TMO-3395309 REF. PART PART REF. DESCRIP_ON DESCRIPTION 17840 732-0568 Transaxle Mtg, Brkt. Ext. Spring Switch Plate 17962 732-0384 Ext. Spring .62" O.D. x 6.12" L-Wash. 5/16" I.D.* 736-0119 16554A Variable Speed Torque...
- Page 26 TMO-3100002 TMO-3395309 16 AND 18 H.P. 42" LAWN TRACTORS PARTS LIST FOR MODELS TMO-3100002 AND TMO-3395309 REF. PART REF. PART DESCRIPTION DESCRIPTION 09735A 728-0272 Connecting Rod Clamp 17640 738-0526 Pivot Link Ass'y.--L.H. Running Board Rod 17641 710-3007 Pivot Link Ass'y.--R.H. Hex Wash, Hal.
- Page 27 TMO-3100002 TMO-3395309 20_t 20"- 6 II** 16 AND 18 H.P. 42" LAWN TRACTORS PARTS LIST FOR MODELS TMO-3100002 AND TMO-3395309 REF. PART REF. PART DESCRIPTION DESCRIPTION 17600A 754-0371A 42" Deck Ass'y. V-Belt 813-06119 736-0270 42" Deck Ass'y. Comp. Bell-Wash. 1/4" I.D. 09322 (For Service Only) Brake Disc...
- Page 28 TMO-3100002 TMO-3395309 1-/8 SINGLE SPEED TRANSAXLEmR.H. MODEL 618-0073...
- Page 29 TM0-3100002 TMO-3395309 PARTS LIST FOR SINGLE SPEED TRANSAXLE RIGHT HAND 618-0073 REF. PART REF. PART DESCRIPTION DESCRIPTION 736-0445 732-0614 Wire Ring FI-Wash..760" I.D. x 1.5" O.D. 716-0171 Retaining--Ring 719-0313 Lower Housing 710-1026 Hex Wash. TT-Tap Scr. 1/4-20 x 718-0150 Anti-Rotation Brkt.
- Page 30 TMO-3100002 TMO-3395309 Black • _i_ _ Yellow _ L_White Yellow LBlack Blue Blue Green PARTS LIST FOR ELECTRICAL SYSTEM REF. PART PART REF. DESCRIPTION DESCRIPTION 725-1438 Cable Tie 726-0197 Battery 725-1426 Solenoid 725-0803C Safety Switch (Deck) 725-1625 725-0759 Safety Switch (Reverse) Fuse 7.5 Amps 725-0634 Socket...
- Page 31 USE THIS SHEET AS A GUIDE TO DETERMINE SLOPES WHERE YOU MAY NOT OPERATE SAFELY. SIGHT AND HOLD THIS LEVEL WITH A VERTICAL TREE ..A POWER POLE • ... I .... A CORNER OF A BUILDING I..l_'_ "'" ",... I'_._ ..
- Page 32 SERVICE NATIONWIDE Mor,cgommy Wind HOW TO OBTAIN. REPLACEMENT PARTS AND SERVICE The merchandise you have purchased from us has been carefully engineered and manufactured under Montgomery Ward's rigid quality standards and should give you satisfactory and dependable operation. However, like all mechanical merchandise, Jt may occa- sionally require adjustment,...