Table of Contents
Advertisement
Owner's Manual
CRRFrSMRM °
TRACTO
42" Mower
Electric Start
6-Speed Transaxle
Model No.
917.274811
This product has a low emission
engine
which operates
differently
from
previously
built
engines.
Before
you start the
engine,
read and understand
this Owner's
Manual.
IMPORTANT:
Read and follow all Safety
Rules and Instructions
before
operating
this equipment.
For answers to your questions
about this product, Call:
1-800-659-5917
Sears Craftsman Help Line
5 am - 5 pm, Mon - Sat
SEARS,
ROEBUCKAND
CO., HOFFMAN
ESTATES, IL 60179
U.S.A.
Visit our Craftsman
website:www.sears.com/craffsman
193813
Rev. 4
*As rated
by the engine
manufacturer
Advertisement
Table of Contents
Related Manuals for Craftsman 917.274811
Summary of Contents for Craftsman 917.274811
- Page 1 IMPORTANT: For answers to your questions about this product, Call: Read and follow all Safety 1-800-659-5917 Rules and Instructions before Sears Craftsman Help Line operating this equipment. 5 am - 5 pm, Mon - Sat SEARS, ROEBUCKAND CO., HOFFMAN ESTATES, IL 60179 U.S.A.
- Page 2 ..........Repair Parts .......... Maintenance Schedule ......Sears Service ......Back Cover CRAFTSMAN FULL WARRANTY TWO YEARS ON RIDING EQUIPMENT When operated and maintained according to all supplied instructions, if this riding equipment fails due to a defect in material...
-
Page 3: General Operation
IMPORTANT." This cutting machine is capable of amputating hands and feet and throw- ing objects. Failure to observe the following safety instructions could result in serious injury or death. • Never direct discharged material _,WARNING" In order to prevent acci- toward anyone. -
Page 4: Slope Operation
li. SLOPE OPERATION • Never carry children, even with the blades shut off. They may fall off and Slopes are a major factor related to loss of be seriously injured or interfere with control and tip-over accidents, which safe machine operation. Children who result in severe... -
Page 5: General Service
• Remove gas-powered equipment from Check their proper operation regularly. the truck or trailer and refuel it on the • Keep machine free of grass, leaves, ground. If this is not possible, then other debris build-up. Clean oil or fuel refuel such equipment with a portable... -
Page 6: Product Specifications
3.5 Pints REPAIR PROTECTION AGREEMENTS Filter: 3.0 Pints Congratulations on making a smart purchase. Spark Plug: Champion RC12YC Your new Craftsman® product is designed (Gap: .030") and manufactured for years of dependable Forward: operation. But like all products, it may require... - Page 7 Steering Wheel Steering Wheel insert © (1) Large Flat Washer Steering Wheel Adapter Steering Extension Shaft (1) 5/16 Lock Washer (1) Hex Bolt 5/16-18 x 4 (1) Washer 17/32 x 1-3/16 x 12 Gauge _(1) Knob For Future Use Keys Slope Sheet...
-
Page 8: Tools Required
Your new tractor has been assembled at the factory with the exception of those parts left unassembled for shipping purposes. To ensure safe and proper operation of your tractor all parts and hardware you assemble must be tightened securely. Use the correct tools as necessary to insure... -
Page 9: Install Seat
INSTALL SEAT NOTE: You may now roll or drive your tractor off the skid. Follow the appropriate Adjust seat before tightening adjustment instruction below to remove the tractor knob. from the skid. Remove adjustment knob and flat washer securing seat to cardboard TO ROLL TRACTOR OFF SKID packing... - Page 10 CHECK TIRE PRESSURE v_CHECKLIST The tires on your tractor were overinflated Before you operate and enjoy your new at the factory for shipping purposes. Cor- tractor, we wish to assure that you receive rect tire pressure is important for best the best performance and satisfaction cutting...
-
Page 11: Hot Surfaces
These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning. I'-,I SLOW REVERSE NEUTRAL HIGH CHOKE FAST IGNITION SWITCH 45 o;[ ENGINE OFF REVERSE ENGINE ON ENGINE START PARKING DRAKE PARKING BRAKE PARKING BRAKE... - Page 12 KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations various controls and adjustments. Save this manual for future reference. ROS "ON" Position Ignition Switch Attachment Clutch Lever Ammeter...
- Page 13 The operation of any tractor result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety SAFETYGLASSES glasses or eye shields while operating your tractor or performing adjustments or repairs. We recommend a wide vision safety mask over...
- Page 14 TO STOP MOWER BLADES • The average lawn should be cut to approximately 2-1/2 inches during Disengage attachment clutch control. the coo! season and to over 3 inches _,CAUTION: Do not operate the mower during hot months. For healthier without either the entire grass catcher,...
-
Page 15: Before Starting
BEFORE STARTING THE ENGINE Look down and behind before backing CHECK ENGINE OIL LEVEL Move gear shift lever to reverse (R) po- The engine in your tractor has been sition and slowly release clutch/brake shipped, from the factory, already filled pedal to start movement. -
Page 16: To Start Engine
TO START ENGINE MOWING TIPS When starting the engine for the first time • Mower should be properly leveled or if the engine has run out of fuel, it will best mowing performance. See "TO LEVEL MOWER HOUSING" in the take extra cranking time to move fuel from the tank to the engine. - Page 17 DATES Check Brake Operation Check Tire Pressure Check Operator Presence ROS Systems Check for Loose Fasteners Sharpen/Replace Mower Blades Lubrication Chart Check Battery Level I" _" Clean Battery and Terminals Check Transaxle Cooling Check V-Belts Check Engine Oil Level Change Engine Oil (with oil filter)
- Page 18 TRACTOR CHECK REVERSE OPERATION (ROS) SYSTEM Always observe safety rules when per- • When the engine is running with the ig- forming any maintenance. BRAKE OPERATION nition switch in the engine "ON" position and the attachment clutch is engaged, If tractor requires more than five (5) feet any attempt...
-
Page 19: Engine Oil Filter
TO CLEAN BATTERY AND TERMINALS TO CHANGE ENGINE Corrosion and dirt on the battery Determine temperature range expected terminals can cause the battery to "leak" before oil change. All oil must meet API service classification SG-SL power. Disconnect BLACK battery cable first •... - Page 20 ENGINE COOLING SYSTEM AIR FILTER Debris may clog the engine's air cool- Your engine will not run properly using ing system. Remove blower housing dirty air filter. Replace pre-cleaner after clean area shown to prevent overheating every 25 hours of operation or every and engine damage.
- Page 21 SERVICE OR ADJUSTMENTS: ARNING: TO AVOID SERIOUS INJURY, BEFORE PERFORMING Depress clutch/brake pedal fully and set parking brake. Place gearshift lever in neutral (N) position. Place attachment clutch in "DISENGAGED" position. Turn ignition key to "STOP" and remove key. Make sure the blades and all moving parts have completely...
-
Page 22: Side-To-Side
TO LEVEL MOWER HOUSING • To lower front of mower loosen nut "E" on both front links an equal number Adjust the mower while tractor is parked turns. on level ground or driveway. Make sure • When distance "D" is 1/8" to 1/2" tires are properly inflated (See "PROD-... - Page 23 TO REPLACE MOWER BLADE DRIVE TO REPLACE MOTION DRIVE BELT BELT Park the tractor on level surface. Engage The mower blade drive belt may be parking brake. For assistance, there is a belt installation guide decal on bottom side replaced without tools.
- Page 24 TRANSAXLE GEAR SHIFT LEVER NEU- Repair tire and reassemble. TRAL ADJUSTMENT NOTE: On rear wheels only: align grooves The transaxle should be in neutral when in rear wheel hub and axle. Insert square key. the gear shift lever is in neutral (N) (lock Replace washers...
- Page 25 REPLACING BATTERY REPLACE HEADLIGHT BULB Raise hood. _IWARNING: Do not short battery Pull bulb holder out of the hole in the terminals by allowing a wrench or any other object to contact both terminals backside of the grill. the same time.
- Page 26 ENGINE iMPORTANT: Damage to the needle valve and the seat in carburetor may result Maintenance, repair, or replacement of the if screw is turned in too tight. emission control devices and systems, which are being done at the customers expense, PRELIMINARY SETTING may be performed...
- Page 27 Immediately prepare your tractor for stor- hol blended fuels (called gasohol or using age at the end of the season or if the trac- ethanol or methanol) can attract moisture tor will not be used for 30 days or more. which leads to separation and formation...
-
Page 28: Troubleshooting
TROUBLESHOOTING CHART: See appropriate section in manual unless directed to a Sears service center PROBLEM CAUSE CORRECTION Out of fuel. Fill fuel tank. Will not start See "TO START ENGINE" Engine not "CHOKED" properly. Operation section. Wait several minutes before Engineflooded. - Page 29 TROUBLESHOOTING CHART: See appropriate section in manual unless directed to a Sears service center PROBLEM CAUSE CORRECTION Engine clicks but Weak or dead battery. Recharge or replace battery. will not start Corroded battery terminals. Clean battery terminals. Loose or damaged wiring.
- Page 30 TROUBLESHOOTING CHART: See appropriate section in manual unless directed to a Sears service center PROBLEM CAUSE CORRECTION Poor cut = uneven Replace blade. Tighten blade bolt. Worn, bent or loose blade. cutting Level mower deck. Mower deck not level. Clean underside of mower Buildup of grass, leaves, and trash under mower.
- Page 31 TROUBLESHOOTING CHART: See appropriate section in manual unless directed to a Sears service center PROBLEM CAUSE CORRECTION Battery will not Bad battery cell(s). Replace battery. charge Poor cable connections. Check/clean all connections. Faulty regulator (if so equipped). Replace regulator. Faulty alternator. Replace alternator.
- Page 32 Decal Lower Dash 138311 Decal, Lift Handle 193564 Decal Pad Footrest LH STLT Rptcmnt 184310X428 186572 Decal Fender, Craftsman White 184311 X428 Pad Footrest RH STLT 164065 Decal Strng Whl Domed 193813 Owner's Manual, English 193308 Decal Owner's Manual, Spanish...
-
Page 33: Ignition Switch
TRACTOR - - MODEL NUMBER 917.274811 SCHEMATIC 02836 193374 / 390 BATTERY o111o SOLENOID STARTER FUSE _)AMMETER WHITE AJr%E_ME'NT C-_ _n_H (PEDAL A_T_'_L_UTCH OFF) BLACK SEAT SWITCH ___.__._ (_N_O_T ___CC_U_P_E_D_ _ _ _ BLACK GRAY i ..REVERSE SWITCH SHORTING CONNECTOR r.. - Page 34 TRACTOR - - MODEL NUMBER 917.274811 ELECTRICAL 1193372 ROS...
- Page 35 73510400 Nut Keps Hex 1/4-20 uric 145491 Cable Ground 192749 Switch Seat DP w/Ramps 193350 Switch Ign 140403 Key Molded Craftsman 110712X Switch Light 193374 Harness Ign 71110408 Bolt Btk. Fin Hex 1/4-20 unc x 1/2 131563 Cover Terminal 178861...
-
Page 36: Chassis And Enclosures
TRACTOR = - MODEL NUMBER 917.274811 CHASSIS AND ENCLOSURES chassis-Laser -it. stlt 45... - Page 37 TRACTOR =- MODEL NUMBER 917.274811 CHASSIS AND ENCLOSURES KEY PART DESCRIPTION 174619 Chassis Assembly 176554 Drawbar 155272 Bumper Hood/Dash 193511X013 Dash STD533710 Bolt, Carriage 3/8-16 x 1 174996 Panel, Dash, L.H. 172105X010 Panel, Dash, R.H. 17490608 ScrewThdrot 3/8-16x 184272X615 Hood Assembly 184921 Bumper Hood STD541437...
- Page 38 TRACTOR - = MODEL NUMBER 917.274811 GROUND DRWE drive-fender.stlt_38...
-
Page 39: Ground Drive
TRACTOR - - MODEL NUMBER 917.274811 GROUND DRIVE KEY PART KEY PART DESCRIPTION DESCRIPTION Transaxle Peerless 206-545C 8883R Cover, Pedal (See Breakdown) 175410 Pulley, Engine 173937 Bolt, Hex 7/16-20 x 4 Gr. 5 146682 Spring, Return, Brake STD551143 Washer 123666X Pulley, Transaxle 12000028 Ring, Retainer... - Page 40 TRACTOR - - MODEL NUMBER 917.274811 STEERING t2_?, m-.-___ 37_--___ ----_37 steering pl.lt...
- Page 41 TRACTOR - - MODEL NUMBER 917.274811 STEERING KEY PART DESCRIPTION 186093X428 Steering Wheel 184706 Axle Assembly 169840 Spindle Assembly, L.H. 169839 Spindle Assembly, R.H. 6266H Bearing, Race, Thrust, Hardened 121748X Washer 25/32 x 1-5/8 x 16 Ga. 12000029 Ring, Klip 175121 Dragtink STD551137...
- Page 42 TRACTOR - - MODEL NUMBER 917.274811 ENGINE OPTIONAL EQUIPMENT Spark Arrester engine-bs. 1 cyl_30...
- Page 43 TRACTOR - - MODEL NUMBER 917.274811 ENGINE KEY PART DESCRIPTION 170545 Control, Throttle/Choke 17720408 Screw, Hex Thd Cut 1/4-20 x 1/2 Engine, B&S, No. 31P777-0296-E1 (See Breakdown) 137352 Muffler Exhaust 165291 Gasket, Muffler 148456 Tube Drain Oil Easy 169837 Shield, Brn/Dbr Guard 137180 Arrestor, Spark 157103...
-
Page 44: Mower Deck
TRACTOR - - MODEL NUMBER 917.274811 MOWER DECK 2/3 24 42 D man-t-path stlt 3... - Page 45 TRACTOR - - MODEL NUMBER 917.274811 MOWER DECK KEY PART KEY PART DESCRIPTION DESCRIPTION 165892 Mower Deck Assembly, 42" 139888 Bolt, Shoulder 5/16-18 unc STD533107 Bolt 184907 Arm Assembly, Pad, Brake Washer, Hardened 138017 Bracket Assy., Sway Bar, Front 178515 165460 Bracket Sway Bar 38/42"...
-
Page 46: Seat Assembly
TRACTOR - - MODEL NUMBER 917.274811 SEAT ASSEMBLY seat It.knob PART PART DESCRIPTION DESCRIPTION 188719 Seat 121248X Bushing, Snap 140551 Bracket, Pivot, Seat 72050412 Bolt, Carriage 1/4-20 x 1-1/2 71110616 Bolt 134300 Spacer, Split .28 x .88 19131610 Washer 13/32 x 1 x 10 Ga. 121250X Spring 145006... -
Page 47: Lift Assembly
TRACTOR - - MODEL NUMBER 917.274811 LiFT ASSEMBLY lift-rh. 1piece 3 KEY PART KEY PART DESCRIPTION DESCRIPTION Link Front 159460 Wire Asm Inner/Sprg W/plunger LT 173288 159471 Shaft Asm Lift RH w/Inf 73350800 Nut Jam Hex 1/2-13 unc 105767X Pin Groove 1 500 Zinc 175689 Trunnion Blk Zinc 12000002... - Page 48 TRACTOR = - MODEL NUMBER 917.274811 PEERLESS TRANSAXLE-=MODEL NUMBER 206-545C &SA MODEL and SERIAL NUMBERS HERE Model et S@riel Chiffre...
- Page 49 TRACTOR - - MODEL NUMBER 917.274811 PEERLESS TRANSAXLE==MODEL NUMBER 206=545C Dowel Pin PART 786026 Flat Washer .312 ID x DESCRIPTION 792076A .059W 772147 Transaxle Cover PART DESCRIPTION 780086A Needle Bearing 5/8" 770128 Transaxle Case Brake Lever 776395 Countershaft 790079 Screw 1/4 - 20 x 1-1 /4" 776409 Output Shaft 792073A...
- Page 50 TRACTOR = - MODEL NUMBER 917.274811 BRIGGS & STRATTON ENGINE=MODEL NUMBER 31P777, TYPE NUMBER 0296=E1 27 _ 691 @ 43<_ 584_ 1264_ 358 ENGINE GASKET 943 O _1022 127o!' 1266 0 524 _ 8420 1019 LABEL KIT 1058 OWNER'S MANUAL I 1036 EMISSION LABEL 48 SHORT...
- Page 51 TRACTOR - - MODEL NUMBER 917.274811 BRIGGS & STRATTON ENGINE=MODEL NUMBER 31P777, TYPE NUMBER 0296-E1 1095 VALVE GASKET 1022 238 ® 1022 6170 1022 654@ 1119,_ 334 _' 1091 _6N1 121 CARBURETOR OVERHAUL 634A_ 987 (_ 1370276@ 95 _' 634_.._ 1266 1068117,_ 6170...
- Page 52 TRACTOR - - MODEL NUMBER 917.274811 BRIGGS & STRATTON ENGINE=MODEL NUMBER 31P777, TYPE NUMBER 0296=E1 1267 1040 1070 697 _ 544_ 803 _ 31° 1 1°6%1 11090_ 50_3_ 462 [ 797/-t:_j...
- Page 53 TRACTOR == MODEL NUMBER 917.274811 BRIGGS & STRATTON ENGINE=MODEL NUMBER 31P777, TYPE NUMBER 0296=E1 PART PART DESCRIPTION DESCRIPTION 697174 Cylinder Assembly 108A 692344 Valve-Choke (Choke A Matic) 399265 Kit-Bushing/Seal (Magneto Side) 694352 Jet-Main (Standard) 391086 • Seat-Oil (Magneto Side) 697228 Jet-Main (High Altitude) 697188 Sump-Engine...
- Page 54 TRACTOR - - MODEL NUMBER 917.274811 BRIGGS & STRATTON ENGINE=MODEL NUMBER 31 P777, TYPE NUMBER 0296=E1 PART PART DESCRIPTION DESCRIPTION 697090 Pump-Fuel 694393 Solenoid-Fuel 691691 Washer (Governor Crank) 499613 Cover-Oil Pump 697122 Etbowdntake 697015 Fitter-Pre Cleaner 697153 Filter-Air Cleaner Cartridge 699848 Cover-Air Cleaner 691261...
- Page 55 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION I/v_ ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. down the face of slopes, never across the face. Do not mow ARNING: To avoid serious injury, operate your tractor up and slopes greater than 15 degrees.
-
Page 56: Need More Help
NEED MORE HELP? Yo_f([ f_nd the answer and mere on managemyhemeoCOm - for free! o Find this and at[ your other product manuals on[me. o Get answers from our team of home experts. o Get a personalized maintenance plan for your home. o Find information and too[s to help with home projects.